Hydrogen supersaturation in extreme-thermophilic (70°C) mixed culture fermentation

Hydrogen supersaturation in extreme-thermophilic (70°C) mixed culture fermentation (MCF) was demonstrated for the first time by membrane inlet mass spectrometry. It was found that hydrogen supersaturation ratio (RH2) increased dramatically (from 1.0 to 20.6) when H2 partial pressure (PH2) was reduced by N2 flushing or sparging. The distribution change of metabolites was insignificant under low PH2 (<0.30atm) due to the high value of RH2, which indicated that it was more relevant to the concentration of dissolved H2 (H2aq) rather than PH2. To explain the cause of hydrogen supersaturation, the overall volumetric mass transfer coefficients (KLa) for H2 were calculated. KLa changed slightly (∼7.0/h) with N2 flushing, while it increased from 7.4 to 10.2/h when N2 sparging rate increased from 0.3 to 17.9mL/min/L. However, the required KLa values were orders of magnitude higher than the experimental ones when maintaining low RH2 by gas sparging, which indicated that hydrogen supersaturation was likely inevitable in MCF. Moreover, to improve the hydrogen yield of MCF, the gas sparging rate was suggested as 2–10times of the hydrogen production rate.

[1]  Robbert Kleerebezem,et al.  Influence of the pH on (open) mixed culture fermentation of glucose: A chemostat study , 2007, Biotechnology and bioengineering.

[2]  G. Zacchi,et al.  A kinetic model for quantitative evaluation of the effect of hydrogen and osmolarity on hydrogen production by Caldicellulosiruptor saccharolyticus , 2011, Biotechnology for biofuels.

[3]  Hang-Sik Shin,et al.  Effect of gas sparging on continuous fermentative hydrogen production , 2006 .

[4]  M. V. van Loosdrecht,et al.  Mixed culture biotechnology for bioenergy production. , 2007, Current opinion in biotechnology.

[5]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[6]  Margret Audur Sigurbjornsdottir,et al.  Combined hydrogen and ethanol production from sugars and lignocellulosic biomass by Thermoanaerobacterium AK54, isolated from hot spring , 2012 .

[7]  D. Bagley,et al.  Measurement of H2 consumption and its role in continuous fermentative hydrogen production. , 2008, Water science and technology : a journal of the International Association on Water Pollution Research.

[8]  N. Bernet,et al.  Gas controlled hydrogen fermentation. , 2012, Bioresource technology.

[9]  L. T. Angenent,et al.  Production of bioenergy and biochemicals from industrial and agricultural wastewater. , 2004, Trends in biotechnology.

[10]  Herbert H. P. Fang,et al.  Fermentative Hydrogen Production From Wastewater and Solid Wastes by Mixed Cultures , 2007 .

[11]  F. Smith,et al.  COLORIMETRIC METHOD FOR DETER-MINATION OF SUGAR AND RELATED SUBSTANCE , 1956 .

[12]  Dipankar Ghosh,et al.  Advances in fermentative biohydrogen production: the way forward? , 2009, Trends in biotechnology.

[13]  D. Bagley,et al.  Supersaturation of Dissolved H2 and CO2 During Fermentative Hydrogen Production with N2 Sparging , 2006, Biotechnology Letters.

[14]  M Perrier,et al.  Liquid-to-Gas Mass Transfer in Anaerobic Processes: Inevitable Transfer Limitations of Methane and Hydrogen in the Biomethanation Process , 1990, Applied and environmental microbiology.

[15]  Yan Zhang,et al.  Hydrogen supersaturation in thermophilic mixed culture fermentation , 2012 .

[16]  Hong Liu,et al.  Effect of pH on hydrogen production from glucose by a mixed culture. , 2002, Bioresource technology.

[17]  J. Puhakka,et al.  Hydrogenic and methanogenic fermentation of birch and conifer pulps , 2012 .

[18]  K. Riet,et al.  Review of Measuring Methods and Results in Nonviscous Gas-Liquid Mass Transfer in Stirred Vessels , 1979 .

[19]  Chiu-Yue Lin,et al.  Direct fermentation of sweet potato to produce maximal hydrogen and ethanol , 2012 .

[20]  Jing-Yuan Wang,et al.  Fermentative hydrogen production from cassava stillage by mixed anaerobic microflora: Effects of temperature and pH , 2010 .

[21]  B. Min,et al.  Biohydrogen production from wheat straw hydrolysate by dark fermentation using extreme thermophilic mixed culture , 2010, Biotechnology and bioengineering.

[22]  D. Bagley,et al.  Optimisation and design of nitrogen-sparged fermentative hydrogen production bioreactors , 2008 .

[23]  R. E. Treybal.  Mass-Transfer Operations , 1955 .

[24]  David M. Bagley,et al.  Improving the yield from fermentative hydrogen production , 2007, Biotechnology Letters.

[25]  Robbert Kleerebezem,et al.  Modeling product formation in anaerobic mixed culture fermentations , 2006, Biotechnology and bioengineering.

[26]  D. L. Hawkes,et al.  Enhancement of hydrogen production from glucose by nitrogen gas sparging. , 2000 .

[27]  J. Zeikus,et al.  Ethanol Production by Thermophilic Bacteria: Relationship Between Fermentation Product Yields of and Catabolic Enzyme Activities in Clostridium thermocellum and Thermoanaerobium brockii , 1980, Journal of bacteriology.

[28]  D. Karakashev,et al.  Biohydrogen production from arabinose and glucose using extreme thermophilic anaerobic mixed cultures , 2012, Biotechnology for Biofuels.

[29]  Banwari Lal,et al.  Improvement of hydrogen production under decreased partial pressure by newly isolated alkaline tolerant anaerobe, Clostridium butyricum TM-9A: Optimization of process parameters , 2012 .

[30]  Don W. Green,et al.  Perry's Chemical Engineers' Handbook , 2007 .

[31]  J. Steyer,et al.  Development of membrane inlet mass spectrometry for examination of fermentation processes. , 2010, Talanta.

[32]  J. Oost,et al.  A thermophile under pressure: Transcriptional analysis of the response of Caldicellulosiruptor saccharolyticus to different H2 partial pressures , 2013 .

[33]  Murray Moo-Young,et al.  Towards sustainable production of clean energy carriers from biomass resources , 2012 .