Effects of ZnO film growth route and nanostructure on electron transport and recombination in dye-sensitized solar cells

The photovoltaic performances of ZnO-based dye-sensitized solar cells (DSSCs) have been studied for ZnO porous films prepared by different techniques. A comparison is made between nanoparticle (NP) films prepared by a sol–gel method and two different electrodeposited (ED) nanoporous films. The D149 indoline dye/ZnO with ZnO prepared by electrochemistry at rather high overvoltage has been found to be the best system. The cell functioning has been studied in-depth by electrochemical impedance spectroscopy (EIS) measurements made over a large potential range, in the dark and under illumination. It is shown that a much deeper sub-conduction band edge density of states (DOS) exists in the case of NP cells compared to ED cells. The electron dynamics have been analysed by determining the charge carrier lifetimes and transport/collection times. In the case of NP films, the charge carrier behaviour is characterized by rather long lifetimes and transport times with a marked voltage response typical of conduction that is governed by trapping–detrapping events. On the contrary, in the case of electrodeposited films, these two parameters are much shorter and the transport is characterized by a straight charge transport. Using photoluminescence data, the charge carrier lifetimes have been related to the surface defects of the ZnO nanostructures. The deduced electron collections were found to be very efficient with values greater than 90%. We have also determined that the ZnO film conductivities were higher than for anatase TiO2, and that the electron diffusion coefficient was higher in the ED film compared to the NP film.

[1]  T. Pauporté,et al.  Electrochemical design of ZnO hierarchical structures for dye-sensitized solar cells , 2012 .

[2]  F. Dufour,et al.  Effects of TiO2 nanoparticle polymorphism on dye-sensitized solar cell photovoltaic properties , 2012 .

[3]  Michael Grätzel,et al.  Porphyrin-Sensitized Solar Cells with Cobalt (II/III)–Based Redox Electrolyte Exceed 12 Percent Efficiency , 2011, Science.

[4]  Laurence M. Peter,et al.  Electron Transport and Recombination in ZnO-Based Dye-Sensitized Solar Cells , 2011 .

[5]  A. Zukal,et al.  ZnO solar cells with an indoline sensitizer: a comparison between nanoparticulate films and electrodeposited nanowire arrays , 2011 .

[6]  T. Pauporté,et al.  From nanowires to hierarchical structures of template-free electrodeposited ZnO for efficient dye-sensitized solar cells , 2011 .

[7]  F. Fabregat‐Santiago,et al.  Doping saturation in dye-sensitized solar cells based on ZnO:Ga nanostructured photoanodes , 2011 .

[8]  Ilaria Ciofini,et al.  Theoretical procedure for optimizing dye-sensitized solar cells: from electronic structure to photovoltaic efficiency. , 2011, Journal of the American Chemical Society.

[9]  Hsin-Ming Cheng,et al.  Electron transfer properties of organic dye-sensitized solar cells based on indoline sensitizers with ZnO nanoparticles , 2010, Nanotechnology.

[10]  T. Le Bahers,et al.  Electrodeposited nanoporous versus nanoparticulate ZnO films of similar roughness for dye-sensitized solar cell applications. , 2010, ACS applied materials & interfaces.

[11]  I. Ciofini,et al.  Effect of solvent and additives on the open-circuit voltage of ZnO-based dye-sensitized solar cells: a combined theoretical and experimental study. , 2010, Physical chemistry chemical physics : PCCP.

[12]  S. Darling,et al.  Electrolyte Effects on Electron Transport and Recombination at ZnO Nanorods for Dye-Sensitized Solar Cells , 2010 .

[13]  Thierry Pauporté,et al.  Hydrothermal treatment for the marked structural and optical quality improvement of ZnO nanowire arrays deposited on lightweight flexible substrates , 2010 .

[14]  Ion Tiginyanu,et al.  Well-aligned arrays of vertically oriented ZnO nanowires electrodeposited on ITO-coated glass and their integration in dye sensitized solar cells , 2010 .

[15]  Giovanni Scalmani,et al.  A TD-DFT investigation of ground and excited state properties in indoline dyes used for dye-sensitized solar cells. , 2009, Physical chemistry chemical physics : PCCP.

[16]  Guozhong Cao,et al.  ZnO Nanostructures for Dye‐Sensitized Solar Cells , 2009 .

[17]  Hsiu-Fen Lin,et al.  Efficient electron transport in tetrapod-like ZnO metal-free dye-sensitized solar cells , 2009 .

[18]  Chuan He,et al.  Electrochemical Impedance Spectroscopy Characterization of Electron Transport and Recombination in ZnO Nanorod Dye-Sensitized Solar Cells , 2009 .

[19]  Thierry Pauporté,et al.  Key Growth Parameters for the Electrodeposition of ZnO Films with an Intense UV-Light Emission at Room Temperature , 2009 .

[20]  Juan Bisquert,et al.  Electron transport in dye-sensitized solar cells based on ZnO nanotubes: evidence for highly efficient charge collection and exceptionally rapid dynamics. , 2009, The journal of physical chemistry. A.

[21]  D. Lincot,et al.  Electrodeposition of Inorganic/Organic Hybrid Thin Films , 2009 .

[22]  Dong Chan Kim,et al.  A comparative analysis of deep level emission in ZnO layers deposited by various methods , 2009 .

[23]  W. K. Chan,et al.  Dye-sensitized solar cells using ZnO tetrapods , 2008 .

[24]  Guozhong Cao,et al.  Aggregation of ZnO nanocrystallites for high conversion efficiency in dye-sensitized solar cells. , 2008, Angewandte Chemie.

[25]  Juan Bisquert,et al.  A review of recent results on electrochemical determination of the density of electronic states of nanostructured metal-oxide semiconductors and organic hole conductors , 2008 .

[26]  H. Minoura,et al.  Electrodeposition of ZnO/Dye Hybrid Thin Films for Dye-Sensitized Solar Cells , 2008 .

[27]  J. Durrant,et al.  Influence of the TiCl4 Treatment on Nanocrystalline TiO2 Films in Dye-Sensitized Solar Cells. 2. Charge Density, Band Edge Shifts, and Quantification of Recombination Losses at Short Circuit , 2007 .

[28]  Guo-Qiang Lo,et al.  Improved dye-sensitized solar cells with a ZnO-nanoflower photoanode , 2007 .

[29]  Chen-Hao Ku,et al.  Effects of dye adsorption on the electron transport properties in ZnO-nanowire dye-sensitized solar cells , 2007 .

[30]  J. Rathouský,et al.  Electrodeposited Mesoporous ZnO Thin Films as Efficient Photocatalysts for the Degradation of Dye Pollutants , 2007 .

[31]  Qing Wang,et al.  Characteristics of high efficiency dye-sensitized solar cells. , 2006, The journal of physical chemistry. B.

[32]  Qing Wang,et al.  Electrochemical impedance spectroscopic analysis of dye-sensitized solar cells. , 2005, The journal of physical chemistry. B.

[33]  Peidong Yang,et al.  Nanowire dye-sensitized solar cells , 2005, Nature materials.

[34]  Hidetoshi Miura,et al.  High efficiency of dye-sensitized solar cells based on metal-free indoline dyes. , 2004, Journal of the American Chemical Society.

[35]  Wai Kin Chan,et al.  Different origins of visible luminescence in ZnO nanostructures fabricated by the chemical and evaporation methods , 2004 .

[36]  Tsukasa Yoshida,et al.  Electron Transport and Back Reaction in Electrochemically Self-Assembled Nanoporous ZnO/Dye Hybrid Films , 2004 .

[37]  Tsukasa Yoshida,et al.  Improved photoelectrochemical performance of electrodeposited ZnO/EosinY hybrid thin films by dye re-adsorption. , 2004, Chemical communications.

[38]  Juan Bisquert,et al.  Interpretation of the Time Constants Measured by Kinetic Techniques in Nanostructured Semiconductor Electrodes and Dye-Sensitized Solar Cells , 2004 .

[39]  Daniel Lincot,et al.  One-step electrodeposition of ZnO/eosin Y hybrid films from a hydrogen peroxide oxygen precursor , 2002 .

[40]  Anders Hagfeldt,et al.  A 5% efficient photoelectrochemical solar cell based on nanostructured ZnO electrodes , 2002 .

[41]  Juan Bisquert,et al.  Theory of the Impedance of Electron Diffusion and Recombination in a Thin Layer , 2002 .

[42]  Bixia Lin,et al.  Green luminescent center in undoped zinc oxide films deposited on silicon substrates , 2001 .

[43]  D. Lincot,et al.  Electrodeposition of semiconductors for optoelectronic devices: results on zinc oxide , 2000 .

[44]  Takafumi Yao,et al.  Plasma assisted molecular beam epitaxy of ZnO on c -plane sapphire: Growth and characterization , 1998 .

[45]  P. Mascher,et al.  Point defects and luminescence centres in zinc oxide and zinc oxide doped with manganese , 1992 .

[46]  M. Grätzel,et al.  A low-cost, high-efficiency solar cell based on dye-sensitized colloidal TiO2 films , 1991, Nature.