Theoretical Study and Experimental Validation on the Applicable Refrigerant for Space Heating Air Source Heat Pump

The air source heat pump (ASHP) is developing rapidly and is widely used for space heating due to its potential for increasing energy efficiency and reducing greenhouse gas emissions. The choice of appropriate low global warming potential (GWP) alternative refrigerants is one of the challenges that ASHP systems face. Alternative refrigerants also affect the energy performance of these systems. Thus, it is essential to evaluate the performance of ASHP using environmentally friendly refrigerants to facilitate reasonable refrigerant selection. A theoretical model for simulating ASHP performance with different refrigerants is developed in this study. Experiments are conducted to validate the theoretical model. The simulation and the experimental results are found to be in good agreement. The ASHP performance indices, such as compression ratio (CR), discharging temperature (DT) and coefficients of performance (COP), are investigated using R22, R417A, R410A, R134a, R152a, R161 and R1234yf as working fluids. The results show that R152a has an average COP of 2.7% higher than R22, and R161 has an average COP of 1.4% higher than R22. R152a and R161 also have a higher CR but a lower DT than R22 under the same design conditions. In addition, R152a and R161 have ozone depletion potentials (ODP) of zero and extremely low GWPs; thus, they can be candidates to replace R22 in ASHP heating systems. This research provides a reference on refrigerant replacements for ASHP heating systems in North China.

[1]  Fang Wang,et al.  Comparative Analysis on the Life Cycle Climate Performance of Ground Source Heat Pump Using Alternative Refrigerants , 2023, SSRN Electronic Journal.

[2]  C. Breyer,et al.  Mitigation of air pollution and corresponding impacts during a global energy transition towards 100% renewable energy system by 2050 , 2022, Energy Reports.

[3]  P. Hopke,et al.  Using the carbon balance method based on fuel-weighted average concentrations to estimate emissions from household coal-fired heating stoves. , 2022, Chemosphere.

[4]  S. O'Doherty,et al.  Estimate of hydrochlorofluorocarbon emissions during 2011-2018 in the Yangtze River Delta, China. , 2022, Environmental pollution.

[5]  A. Lucchini,et al.  Drop-in analysis of R450A and R513A as low-GWP alternatives to R134a in a water-to-water heat pump , 2021, International Journal of Refrigeration.

[6]  Jing Zhao,et al.  Combustion Characteristic and Mechanism of a Mixture Working Fluid C3H8/CO2 , 2021, Journal of Thermal Science.

[7]  S. Tao,et al.  A critical review of pollutant emission factors from fuel combustion in home stoves. , 2021, Environment international.

[8]  Abdulaziz M. Almutlaq,et al.  Thermo-economic analysis of working fluids for a ground source heat pump for domestic uses , 2021 .

[9]  Jianlin Yu,et al.  Analysis of a dual-temperature air source heat pump cycle with an ejector , 2021, Applied Thermal Engineering.

[10]  Ashish S. Utage,et al.  Performance simulation of HFC-161 as an alternative refrigerant to HCFC-22 for room air conditioner , 2021 .

[11]  C. Mateu-Royo,et al.  Semi-empirical and environmental assessment of the low GWP refrigerant HCFO-1224yd(Z) to replace HFC-245fa in high temperature heat pumps , 2021, International Journal of Refrigeration.

[12]  Meng Yu,et al.  Techno-economic analysis of air source heat pump combined with latent thermal energy storage applied for space heating in China , 2021 .

[13]  J. Sieres,et al.  Drop-in performance of the low-GWP alternative refrigerants R452B and R454B in an R410A liquid-to-water heat pump , 2021 .

[14]  C. Mateu-Royo,et al.  Comparative analysis of HFO-1234ze(E) and R-515B as low GWP alternatives to HFC-134a in moderately high temperature heat pumps , 2020 .

[15]  C. Yu,et al.  Experimental evaluation of a capillary heating bed driven by an air source heat pump and solar energy , 2020, Indoor and Built Environment.

[16]  N. Gao,et al.  Evaluation on Excess Entropy Scaling Method Predicting Thermal Transport Properties of Liquid HFC/HFO Refrigerants , 2020, Journal of Thermal Science.

[17]  Yongan Yang,et al.  Experimental and simulation study of air source heat pump for residential applications in northern China , 2020 .

[18]  Jinchen Tang,et al.  Computational modeling and prediction of the performance of air source heat pumps under frost prevention and retardation conditions , 2020 .

[19]  Yuying Yan,et al.  Prospect Evaluation of Low-GWP Refrigerants R1233zd(E) and R1336mzz(Z) Used in Solar-Driven Ejector-Vapor Compression Hybrid Refrigeration System , 2020, Journal of Thermal Science.

[20]  Yuehong Lu,et al.  Energy and exergy analysis of an air-source heat pump water heater system using CO2/R170 mixture as an azeotropy refrigerant for sustainable development , 2019, International Journal of Refrigeration.

[21]  Qiang Zhang,et al.  Underreported coal in statistics: A survey-based solid fuel consumption and emission inventory for the rural residential sector in China , 2019, Applied Energy.

[22]  Xiaowei Fan,et al.  Experimental investigation on a heat pump water heater using R744/R290 mixture for domestic hot water , 2018, International Journal of Thermal Sciences.

[23]  B. Li,et al.  Quantifying the rural residential energy transition in China from 1992 to 2012 through a representative national survey , 2018 .

[24]  Yuehong Lu,et al.  Thermodynamic analysis of CO2 blends with R41 as an azeotropy refrigerant applied in small refrigerated cabinet and heat pump water heater , 2017 .

[25]  Bjarne W. Olesen,et al.  Theoretical study on volatile organic compound removal and energy performance of a novel heat pump assisted solid desiccant cooling system , 2015 .

[26]  Zhiming Gao,et al.  Investigation of R417A as a Drop-In Alternative for R22 in a Residential Heat Pump , 2006 .