Effect of pH on the microbial hydrogen fermentation

The influence of initial pH of the culture medium on hydrogen production was studied using sucrose solution and a mixed microbial flora from a soybean-meal silo. Hydrogen production was not observed at pH values of 3.0, 11.0 and 12.0 but low production was observed at pH values 5.0 and 5.5. The pH of the experimental mixture decreased rapidly and produced hydrogen gas within 30 h. Methane was not detected at initial pH values between 6.0 and 10.0. The sucrose degradation efficiency increased as the initial pH value increased from 3.0 to 9.0. The maximum sucrose degradation efficiency of 95% was observed at pH 9.0. The maximum specific production yields of hydrogen, VFAs and alcohols were 126.9 cm3 g−1 sucrose (pH of 9.0), 0.7 gCOD g−1 sucrose (pH of 8.0) and 128.7 mgCOD g−1 sucrose (pH of 9.0), respectively. The relationship between the hydrogen ion concentration and the specific hydrogen production rate has been mathematically described. The best kinetic parameters on the specific hydrogen production rate were KOH = 1.0 × 10−7 mol dm−3 and KH = 1.1 × 10−4 mol dm−3 (r2 = 0.86). The maximum specific hydrogen production rate was 37.0 cm3 g−1 VSS h−1. © 2002 Society of Chemical Industry

[1]  Hubert Bahl,et al.  Parameters Affecting Solvent Production by Clostridium pasteurianum , 1992, Applied and environmental microbiology.

[2]  T. Noike,et al.  Response of mixed cultures of chlorella vulgaris and heterotrophic bacteria to variation of pH , 1994 .

[3]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[4]  D. P. Gregory.  The Hydrogen Economy , 1973 .

[5]  Shangtian Yang,et al.  Effects of pH and acetic acid on homoacetic fermentation of lactate by Clostridium formicoaceticum , 1989, Biotechnology and bioengineering.

[6]  J. Lay,et al.  Feasibility of biological hydrogen production from organic fraction of municipal solid waste , 1999 .

[7]  Gerasimos Lyberatos,et al.  Effect of temperature and ph on the effective maximum specific growth rate of nitrifying bacteria , 1990 .

[8]  J. Lay,et al.  The influence of pH and ammonia concentration on the methane production in high‐solids digestion processes , 1998 .

[9]  F. Smith,et al.  Colorimetric Method for Determination of Sugars and Related Substances , 1956 .

[10]  M. Levandowsky,et al.  Production of hydrogen by microbial fermentation , 1988 .

[11]  L. Huang,et al.  Transmembrane pH gradient and membrane potential in Clostridium acetobutylicum during growth under acetogenic and solventogenic conditions , 1985, Applied and environmental microbiology.

[12]  M. P. Bryant,et al.  Commentary on the Hungate technique for culture of anaerobic bacteria. , 1972, The American journal of clinical nutrition.

[13]  H. Gest,et al.  Biological Formation of Molecular Hydrogen , 1965, Science.

[14]  Fumiaki Taguchi,et al.  Efficient hydrogen production from starch by a bacterium isolated from termites , 1992 .

[15]  L. K. Bowles,et al.  Effects of butanol on Clostridium acetobutylicum , 1985, Applied and environmental microbiology.

[16]  S. Gatenbeck,et al.  Intermediary Metabolism in Clostridium acetobutylicum: Levels of Enzymes Involved in the Formation of Acetate and Butyrate , 1984, Applied and environmental microbiology.

[17]  P. Mccarty,et al.  Bioassay for monitoring biochemical methane potential and anaerobic toxicity , 1979 .

[18]  Naoki Mizukami,et al.  Isolation of a hydrogen-producing bacterium, Clostridium beijerinckii strain AM21B, from termites , 1993 .

[19]  K. Hara,et al.  Continuous hydrogen production by Clostridium sp. strain no. 2 from cellulose hydrolysate in an aqueous two-phase system☆ , 1996 .