The effect of low pressure and mixing on biological hydrogen production via anaerobic fermentation

Abstract Two-stage anaerobic digesters are ideally suited for hydrogen production because primary fermentation is separated from methanogenesis, allowing for optimization of both processes. At low hydrogen partial pressures, hydrogen forming reactions become thermodynamically favorable and there is a shift in fermentation toward the production of acetate and away from butyrate, alcohols, and solvents. Increased acetate yields in first stage reactors enhance acetoclastic methanogenesis in second stage reactors. We evaluated the effects of headspace pressure and reactor mixing, two parameters that can be controlled at the industrial scale, on hydrogen production and fermentation products using anaerobic batch reactors. Control of methanogenesis was achieved with low pH caused by high loading of non-fat powered milk (4 gVS L − 1 ). In mixed reactors, hydrogen yields increased significantly from 87.5 to 121.4 ml g VS − 1 (p = 0.056) and the acetate to butyrate ratio increased from 0.44 to 0.68 (p = 0.11). Control of headspace pressure below atmospheric levels did not have a significant effect on gas production. These results demonstrate the rapid production of hydrogen and inhibition of methanogenesis via substrate loading and mixing, and provide a practical method for enhancing energy recovery in two-stage anaerobic digesters.

[1]  Hong Liu,et al.  Effect of pH on hydrogen production from glucose by a mixed culture. , 2002, Bioresource technology.

[2]  Heguang Zhu,et al.  Evaluation of alternative methods of preparing hydrogen producing seeds from digested wastewater sludge , 2006 .

[3]  J. Lay,et al.  Biohydrogen production as a function of pH and substrate concentration. , 2001, Environmental science & technology.

[4]  Awwa,et al.  Standard Methods for the examination of water and wastewater , 1999 .

[5]  Jacinto F. Fabiosa,et al.  Use of U.S. Croplands for Biofuels Increases Greenhouse Gases Through Emissions from Land-Use Change , 2008, Science.

[6]  Sangeun Oh,et al.  The relative effectiveness of pH control and heat treatment for enhancing biohydrogen gas production. , 2003, Environmental science & technology.

[7]  David M. Bagley,et al.  Improving the yield from fermentative hydrogen production , 2007, Biotechnology Letters.

[8]  K. Burton.  The oxidation-reduction potential of diphosphopyridine nucleotide , 1952 .

[9]  H. Drake,et al.  Ecological consequences of the phylogenetic and physiological diversities of acetogens , 2002, Antonie van Leeuwenhoek.

[10]  L. Yerushalmi,et al.  Effect of increased hydrogen partial pressure on the acetone-butanol fermentation by Clostridium acetobutylicum , 1985, Applied Microbiology and Biotechnology.

[11]  L. T. Angenent,et al.  Production of bioenergy and biochemicals from industrial and agricultural wastewater. , 2004, Trends in biotechnology.

[12]  S. Polasky,et al.  Land Clearing and the Biofuel Carbon Debt , 2008, Science.

[13]  D. White.  The Physiology and Biochemistry of Prokaryotes , 1999 .

[14]  Ruihong Zhang.  Biogasification of organic solid wastes : Green power from wastes , 2002 .

[15]  D. L. Hawkes,et al.  Enhancement of hydrogen production from glucose by nitrogen gas sparging. , 2000 .

[16]  C-C. Chen,et al.  Kinetics of hydrogen production with continuous anaerobic cultures utilizing sucrose as the limiting substrate , 2001, Applied Microbiology and Biotechnology.

[17]  R. Thauer,et al.  Energy conservation in chemotrophic anaerobic bacteria , 1977, Bacteriological reviews.

[18]  M. Delwiche,et al.  Development of a Low-Flow Meter for Measuring Gas Production in Bioreactors , 2011 .

[19]  Y. Ueno,et al.  Hydrogen Production from Industrial Wastewater by Anaerobic Microflora in Chemostat Culture , 1996 .

[20]  Y. Kawagoshi,et al.  Effect of inoculum conditioning on hydrogen fermentation and pH effect on bacterial community relevant to hydrogen production. , 2005, Journal of bioscience and bioengineering.

[21]  J. Lay,et al.  Feasibility of biological hydrogen production from organic fraction of municipal solid waste , 1999 .

[22]  J. Elliott,et al.  Isolation and characterization of an Fe,-S8 ferredoxin (ferredoxin II) from Clostridium thermoaceticum , 1982, Journal of bacteriology.

[23]  Philippe Soucaille,et al.  Characterization of Two 2[4Fe4S] Ferredoxins from Clostridium acetobutylicum , 2008, Current Microbiology.

[24]  G. R. Zoutberg,et al.  Glucose fermentation byClostridium butyricum grown under a self generated gas atmosphere in chemostat culture , 1985, Applied Microbiology and Biotechnology.

[25]  J. Linden,et al.  Agitation and pressure effects on acetone‐butanol fermentation , 1985, Biotechnology and bioengineering.

[26]  K. Wuhrmann,et al.  Product inhibition in sludge digestion , 1977, Microbial Ecology.

[27]  M. P. Bryant,et al.  Ferredoxin- and Nicotinamide Adenine Dinucleotide-Dependent H2 Production from Ethanol and Formate in Extracts of S Organism Isolated from “Methanobacillus omelianskii” , 1972, Journal of bacteriology.

[28]  J. J. Simmons,et al.  Hydrogen Production by Anaerobic Microbial Communities Exposed to Repeated Heat Treatments , 2007, Water environment research : a research publication of the Water Environment Federation.

[29]  Yibin Ying,et al.  Effect of food to microorganism ratio on biohydrogen production from food waste via anaerobic fermentation , 2008 .

[30]  Serge R. Guiot,et al.  Continuous measurement of dissolved H2 in an anaerobic reactor using a new hydrogen/air fuel cell detector , 1990, Biotechnology and bioengineering.

[31]  R. Lamed,et al.  Effects of Stirring and Hydrogen on Fermentation Products of Clostridium thermocellum , 1988, Applied and environmental microbiology.

[32]  F. Rombouts,et al.  Modeling of the Bacterial Growth Curve , 1990, Applied and environmental microbiology.

[33]  F L RODKEY.  The effect of temperature on the oxidation-reduction potential of the diphosphopyridine nucleotide system. , 1959, The Journal of biological chemistry.

[34]  B. Logan,et al.  Removal of headspace CO2 increases biological hydrogen production. , 2005, Environmental science & technology.

[35]  R. Dinsdale,et al.  Continuous fermentative hydrogen production from a wheat starch co‐product by mixed microflora , 2003, Biotechnology and bioengineering.

[36]  You-Kwan Oh,et al.  Biofilm microbial community of a thermophilic trickling biofilter used for continuous biohydrogen production. , 2005, FEMS microbiology letters.

[37]  Hang-Sik Shin,et al.  Effect of gas sparging on continuous fermentative hydrogen production , 2006 .

[38]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[39]  R. S. Wolfe,et al.  Methanobacillus omelianskii, a symbiotic association of two species of bacteria , 2004, Archiv für Mikrobiologie.

[40]  Jeffrey R. White,et al.  Effect of seasonal changes in the pathways of methanogenesis on the δ13C values of pore water methane in a Michigan peatland , 1999 .

[41]  S. Tanisho,et al.  Effect of CO2 removal on hydrogen production by fermentation , 1998 .

[42]  Akiko Miya,et al.  Studies on hydrogen production by continuous culture system of hydrogen-producing anaerobic bacteria , 1997 .

[43]  M. P. Bryant,et al.  Glucose Fermentation Products of Ruminococcus albus Grown in Continuous Culture with Vibrio succinogenes: Changes Caused by Interspecies Transfer of H2 , 1973, Journal of bacteriology.

[44]  R. Conrad,et al.  Acetoclastic and hydrogenotrophic methane production and methanogenic populations in an acidic West-Siberian peat bog. , 2004, Environmental microbiology.

[45]  Frederick C. Neidhardt,et al.  The Physiology and Biochemistry of Prokaryotes, 3rd ed. , 2007 .

[46]  James G. Ferry,et al.  Methanogenesis : Ecology, Physiology, Biochemistry and Genetics , 1994 .

[47]  R. J. Zoetemeyer,et al.  pH influence on acidogenic dissimilation of glucose in an anaerobic digestor , 1982 .

[48]  F. Rodkey.  Oxidation-reduction potentials of the diphosphopyridine nucleotide system. , 1955, The Journal of biological chemistry.

[49]  Chiu-Yue Lin,et al.  Hydrogen production during the anaerobic acidogenic conversion of glucose , 1999 .

[50]  Jeffrey R. White,et al.  Controls on methane production in a tidal freshwater estuary and a peatland: methane production via acetate fermentation and CO2 reduction , 2003 .

[51]  K. Chung.  Inhibitory effects of H2 on growth of Clostridium cellobioparum , 1976, Applied and Environmental Microbiology.

[52]  Sang-Eun Oh,et al.  Biological hydrogen production measured in batch anaerobic respirometers. , 2002, Environmental science & technology.

[53]  S. Hyun,et al.  Effect of low pH on the activity of hydrogen utilizing methanogen in bio-hydrogen process , 2003 .

[54]  J. Rabinowitz,et al.  Apparent oxidation-reduction potential of Clostridium acidi-urici ferredoxin. Effect of pH, ionic strength, and amino acid replacements. , 1976, The Journal of biological chemistry.

[55]  B. Schink.  Energetics of syntrophic cooperation in methanogenic degradation , 1997, Microbiology and molecular biology reviews : MMBR.

[56]  B. Logan,et al.  H2-Producing bacterial communities from a heat-treated soil inoculum , 2004, Applied Microbiology and Biotechnology.

[57]  Jean-Louis Garcia.  Taxonomy and ecology of methanogens , 1990 .