PEM fuel cell relative humidity (RH) and its effect on performance at high temperatures

The water balance inside a fuel cell was analysed and several equations were introduced as functions of fuel cell gas-stream inlet and outlet pressures, inlet relative humidities (RHs), temperature, pressure drops across flow channels, and reactant partial pressures. The effect of RH on PEM fuel cell performance was studied at elevated temperatures under ambient backpressure using Nafion®-based MEAs. The results showed that fuel cell performance could be depressed significantly by decreasing RH from 100 to 25%. AC impedance and cyclic voltammetry techniques were employed to diagnose the RH effect on fuel cell reaction kinetics. Reducing RH can result in slower electrode kinetics, including electrode reaction and mass diffusion rates, and higher membrane resistance.

[1]  T. Ohsaka,et al.  Exploring the effects of symmetrical and asymmetrical relative humidity on the performance of H2/air PEM fuel cell at different temperatures , 2007 .

[2]  James M. Fenton,et al.  Investigation of platinum oxidation in PEM fuel cells at various relative humidities , 2007 .

[3]  D. Desmarteau,et al.  Proton Conductivity in Nafion® 117 and in a Novel Bis[(perfluoroalkyl)sulfonyl]imide Ionomer Membrane , 1998 .

[4]  Vijay Ramani,et al.  Stabilized composite membranes and membrane electrode assemblies for elevated temperature/low relative humidity PEFC operation , 2005 .

[5]  James M. Fenton,et al.  Investigation of membrane property and fuel cell behavior with sulfonated poly(ether ether ketone) electrolyte: Temperature and relative humidity effects , 2005 .

[6]  C. Gardner,et al.  Studies on ion-exchange membranes. Part 1. Effect of humidity on the conductivity of Nafion® , 1996 .

[7]  Yanghua Tang,et al.  Polybenzimidazole-membrane-based PEM fuel cell in the temperature range of 120–200 °C , 2007 .

[8]  Wei-Mon Yan,et al.  Humidity of reactant fuel on the cell performance of PEM fuel cell with baffle-blocked flow field designs , 2006 .

[9]  In-Hwan Oh,et al.  Effects of cathode open area and relative humidity on the performance of air-breathing polymer electrolyte membrane fuel cells , 2006 .

[10]  M. Ciureanu.  Effects of Nafion® Dehydration in PEM Fuel Cells , 2004 .

[11]  J. C. Amphlett,et al.  Performance modeling of the Ballard Mark IV solid polymer electrolyte fuel cell. II: Empirical model development , 1995 .

[12]  James M. Fenton,et al.  Influence of temperature and relative humidity on performance and CO tolerance of PEM fuel cells with Nafion®–Teflon®–Zr(HPO4)2 higher temperature composite membranes , 2006 .

[13]  Yanghua Tang,et al.  PEM fuel cell open circuit voltage (OCV) in the temperature range of 23 °C to 120 °C , 2006 .

[14]  James M. Fenton,et al.  Effect of Elevated Temperature and Reduced Relative Humidity on ORR Kinetics for PEM Fuel Cells , 2005 .

[15]  Hubert A. Gasteiger,et al.  Effect of Relative Humidity on Oxygen Reduction Kinetics in a PEMFC , 2005 .

[16]  D. Wilkinson,et al.  Aging mechanisms and lifetime of PEFC and DMFC , 2004 .

[17]  T. Springer,et al.  A microelectrode study of oxygen reduction at the platinum-recast-nafion film interface , 1992 .

[18]  Thomas F. Fuller,et al.  Experimental Determination of the Transport Number of Water in Nafion 117 Membrane , 1992 .

[19]  G. Anilkumar,et al.  Proton conducting phosphated zirconia–sulfonated polyether sulfone nanohybrid electrolyte for low humidity, wide-temperature PEMFC operation , 2006 .

[20]  Eiji Endoh,et al.  Degradation study of MEA for PEMFCs under low humidity conditions , 2004 .

[21]  Ravindra Datta,et al.  Performance analysis and impedance spectral signatures of high temperature PBI–phosphoric acid gel membrane fuel cells , 2006 .

[22]  S. H. Kim,et al.  Improvement of low-humidity performance of PEMFC by addition of hydrophilic SiO2 particles to catalyst layer , 2006 .

[23]  Jingrong Yu,et al.  In Situ Analysis of Performance Degradation of a PEMFC under Nonsaturated Humidification , 2005 .

[24]  Tetsuo Sakai,et al.  Gas Diffusion in the Dried and Hydrated Nafions , 1986 .

[25]  James Larminie,et al.  Fuel Cell Systems Explained , 2000 .

[26]  Hui Xu,et al.  Analysis of proton exchange membrane fuel cell polarization losses at elevated temperature 120 °C and reduced relative humidity , 2007 .

[27]  T. Abe,et al.  Study of PEFCs by AC Impedance, Current Interrupt, and Dew Point Measurements I. Effect of Humidity in Oxygen Gas , 2004 .

[28]  P. Ekdunge,et al.  Proton Conductivity of Nafion 117 as Measured by a Four‐Electrode AC Impedance Method , 1996 .

[29]  Jing Li,et al.  PEM fuel cell reaction kinetics in the temperature range of 23–120 °C , 2007 .

[30]  E. Chalkova,et al.  Effect of TiO2 Surface Properties on Performance of Nafion-Based Composite Membranes in High Temperature and Low Relative Humidity PEM Fuel Cells , 2005 .

[31]  Jing Li,et al.  Temperature Dependent Performance and In Situ AC Impedance of High-Temperature PEM Fuel Cells Using the Nafion-112 Membrane , 2006 .

[32]  Serguei N. Lvov,et al.  Nafion ∕ TiO2 Proton Conductive Composite Membranes for PEMFCs Operating at Elevated Temperature and Reduced Relative Humidity , 2005 .

[33]  Ronghuan He,et al.  The CO Poisoning Effect in PEMFCs Operational at Temperatures up to 200°C , 2003 .

[34]  Xuan Cheng,et al.  PEM fuel cells operated at 0% relative humidity in the temperature range of 23–120 °C , 2007 .

[35]  P. Ekdunge,et al.  Oxygen and hydrogen permeation properties and water uptake of Nafion® 117 membrane and recast film for PEM fuel cell , 1997 .

[36]  Harvey G. Stenger,et al.  Flow rate and humidification effects on a PEM fuel cell performance and operation , 2007 .

[37]  David P. Wilkinson,et al.  High temperature PEM fuel cells , 2006 .

[38]  In-Hwan Oh,et al.  Effect of the ionomers in the electrode on the performance of PEMFC under non-humidifying conditions , 2004 .

[39]  J. Maruyama,et al.  Performance of PEFC Formed by Using Pt-Loaded Activated Carbon under High- and Low-Humidity Conditions , 2006 .

[40]  Shimshon Gottesfeld,et al.  The Water Content Dependence of Electro-Osmotic Drag in Proton-Conducting Polymer Electrolytes , 1995 .

[41]  H. Toghiani,et al.  Steady state and dynamic performance of proton exchange membrane fuel cells (PEMFCs) under various operating conditions and load changes , 2006 .