Influence of phase separation on the anaerobic digestion of glucose—I maximum COD-turnover rate during continuous operation

Abstract A mineral medium containing 1% of glucose as the main carbon source was subjected to one-phase and to two-phase anaerobic digestion processes under comparable conditions. The one-phase system consisted of an anaerobic up-flow reactor containing both acidogenic as well as methanogenic populations allowing a complete conversion of the carbon source into gaseous end products and biomass. The two-phase system consisted of an acid reactor and a methane reactor connected in series allowing sequential acidogenesis and methanogenesis of the glucose. Performance of the one-phase system and of the methane reactor of the two-phase system is presented by carbon mass balances. By gradually increasing the feed supply to both systems, maximum turnover of COD was determined. Maximum specific sludge loadings of the methanogenic phase of the two-phase system was over 3 times higher than that of the one-phase system. In a second experiment both systems were subjected to overloading, resulting in the accumulation of volatile fatty acids (VFA). In the one-phase system propionate and acetate were formed in considerable amounts. Although acetate disappeared rapidly after cessation of the feed supply, no turnover of propionate was observed within one week. On overloading the methane reactor of the two-phase system accumulation of several fatty acids within the reactor was observed. Rapid conversion of all fatty acids took place immediately after interruption of feed supply. The eco-physiological significance of phase separation is discussed briefly.

[1]  Andrews Jf,et al.  KINETICS AND CHARACTERISTICS OF VOLATILE ACID PRODUCTION IN ANAEROBIC FERMENTATION PROCESSES. , 1965 .

[2]  D. Klass,et al.  Anaerobic acidogenesis of wastewater sludge. , 1975, Journal - Water Pollution Control Federation.

[3]  K. Chung.  Inhibitory effects of H2 on growth of Clostridium cellobioparum , 1976, Applied and environmental microbiology.

[4]  R. L. Baldwin,et al.  Enzymatic Studies of Pure Cultures of Rumen Microorganisms , 1966, Journal of bacteriology.

[5]  D. Chynoweth,et al.  Volatile Acid Formation in Sludge Digestion , 1971 .

[6]  D. Demeyer,et al.  The effect of C18 unsaturated fatty acids of methane production in vitro by mixed rumen bacteria. , 1967, Biochimica et biophysica acta.

[7]  Watson O'Dell Pierce.  Air war , 1937 .

[8]  T. Miller,et al.  Formation of Hydrogen and Formate by Ruminococcus albus , 1973 .

[9]  D. M. Ward,et al.  Biogenesis of methane. , 1977, Annual review of microbiology.

[10]  J. Zeikus.  The Biology of Methanogenic Bacteria , 1977, Microbiological reviews.

[11]  C. V. Van Nevel,et al.  Effect of chloral hydrate on methane and propionic acid in the rumen. , 1969, Applied microbiology.

[12]  S. K. Ghosh,et al.  Developments in anaerobic stabilization of organic wastes--the two-phase concept. , 1971, Environmental letters.

[13]  L. A. Roth,et al.  Acetic acid and hydrogen metabolism during coculture of an acetic acid producing bacterium with methanogenic bacteria. , 1978, Canadian journal of microbiology.

[14]  M. P. Bryant,et al.  Growth of Desulfovibrio in Lactate or Ethanol Media Low in Sulfate in Association with H2-Utilizing Methanogenic Bacteria , 1977, Applied and environmental microbiology.

[15]  R. Thauer,et al.  Energy Conservation in Chemotrophic Anaerobic Bacteria , 1977, Bacteriological reviews.

[16]  I. Mahr.  Untersuchungen über die rolle der niederen fettsäuren beim anaeroben faulprozess und einblicke in seine biozönose , 1969 .

[17]  R. J. Zoetemeyer,et al.  Anaerobic digestion of glucose with separated acid production and methane formation , 1979 .

[18]  M. P. Bryant,et al.  Glucose Fermentation Products of Ruminococcus albus Grown in Continuous Culture with Vibrio succinogenes: Changes Caused by Interspecies Transfer of H2 , 1973, Journal of bacteriology.

[19]  M. Wolin,et al.  Effect of CCl4 on CH4 and volatile acid production in continuous cultures of rumen organisms and in a sheep rumen. , 1968, Applied microbiology.

[20]  M. Winfrey,et al.  Association of hydrogen metabolism with methanogenesis in Lake Mendota sediments , 1977, Applied and environmental microbiology.

[21]  J. A. Borchardt.  Anaerobic Phase Separation by Dialysis Technique , 1971 .

[22]  Perry L. McCarty,et al.  NUTRIENT REQUIREMENTS AND BIOLOGICAL SOLIDS ACCUMULATION IN ANAEROBIC DIGESTION , 1964 .

[23]  C. V. Van Nevel,et al.  Effect of fatty acid derivatives on rumen methane and propionate in vitro. , 1971, Applied microbiology.

[24]  R. R. Van Der Meer.  Anaerobic treatment of wastewater containing fatty acids in upflow reactors , 1980 .

[25]  M. Wolin,et al.  H2 production by Selenomonas ruminantium in the absence and presence of methanogenic bacteria. , 1975, Applied microbiology.

[26]  R S Wolfe,et al.  Microbial formation of methane. , 1971, Advances in microbial physiology.

[27]  R. Mah,et al.  Kinetics of acetate metabolism during sludge digestion. , 1966, Applied microbiology.

[28]  M. Wolin.  Metabolic interactions among intestinal microorganisms. , 1974, The American journal of clinical nutrition.