The effects of vacuum ultraviolet radiation on low-k dielectric films

Plasmas, known to emit high levels of vacuum ultraviolet (VUV) radiation, are used in the semiconductor industry for processing of low-k organosilicate glass (SiCOH) dielectric device structures. VUV irradiation induces photoconduction, photoemission, and photoinjection. These effects generate trapped charges within the dielectric film, which can degrade electrical properties of the dielectric. The amount of charge accumulation in low-k dielectrics depends on factors that affect photoconduction, photoemission, and photoinjection. Changes in the photo and intrinsic conductivities of SiCOH are also ascribed to the changes in the numbers of charged traps generated during VUV irradiation. The dielectric-substrate interface controls charge trapping by affecting photoinjection of charged carriers into the dielectric from the substrate. The number of trapped charges increases with increasing porosity of SiCOH because of charge trapping sites in the nanopores. Modifications to these three parameters, i.e., (1) VU...

[1]  H. Ren.  Plasma-processing-induced Damage Of Thin Dielectric Films , 2012 .

[2]  Yoshio Nishi,et al.  Charging response of back-end-of-the-line barrier dielectrics to VUV radiation , 2012 .

[3]  J. Shohet,et al.  Equivalent-circuit model for vacuum ultraviolet irradiation of dielectric films , 2012 .

[4]  G. A. Antonelli,et al.  Time-dependent dielectric breakdown of plasma-exposed porous organosilicate glass , 2012 .

[5]  Y. Nishi,et al.  Plasma and vacuum ultraviolet induced charging of SiO2 and HfO2 patterned structures , 2012 .

[6]  N. M. Russell,et al.  Effect of the dielectric–substrate interface on charge accumulation from vacuum ultraviolet irradiation of low-k porous organosilicate dielectrics , 2011 .

[7]  G. A. Antonelli,et al.  Effects of vacuum ultraviolet radiation on deposited and ultraviolet-cured low-k porous organosilicate glass , 2011 .

[8]  N. M. Russell,et al.  Effect of vacuum ultraviolet and ultraviolet irradiation on mobile charges in the bandgap of low-k-porous organosilicate dielectrics , 2011 .

[9]  David B. Graves,et al.  Synergistic damage effects of vacuum ultraviolet photons and O2 in SiCOH ultra-low-k dielectric films , 2010 .

[10]  G. A. Antonelli,et al.  Reflectance and substrate currents of dielectric layers under vacuum ultraviolet irradiation , 2010 .

[11]  G. A. Antonelli,et al.  Surface potential due to charge accumulation during vacuum ultraviolet exposure for high-k and low-k dielectrics , 2010 .

[12]  Patrick M. Lenahan,et al.  Ultraviolet radiation effects on paramagnetic defects in low-κ dielectrics for ultralarge scale integrated circuit interconnects , 2010 .

[13]  Yoshio Nishi,et al.  Charge Trapping within UV and Vacuum UV Irradiated Low-k Porous Organosilicate Dielectrics , 2010 .

[14]  S. Samukawa,et al.  Mechanism of increase in charge-pumping current of metal-nitride-oxide-silicon-field effect transistors during thick dielectric film etching using fluorocarbon gas plasma , 2010 .

[15]  叶超,et al.  Effect of F doping on capacitance－voltage characteristics of SiCOH low- k films metal－insulator－semiconductor structure , 2010 .

[16]  G. A. Antonelli,et al.  Numerical simulation of vacuum-ultraviolet irradiation of dielectric layers , 2010 .

[17]  Direct measurement of giant electrocaloric effect in BaTiO3 multilayer thick film structure beyond theoretical prediction , 2010, 1003.5032.

[18]  G. A. Antonelli,et al.  Effect of vacuum ultraviolet and ultraviolet Irradiation on capacitance-voltage characteristics of low-k-porous organosilicate dielectrics , 2010 .

[19]  Willi Volksen,et al.  Low dielectric constant materials. , 2010, Chemical reviews.

[20]  M. Ferenets,et al.  Thin Solid Films , 2010 .

[21]  A. Grill.  Porous pSiCOH Ultralow-k Dielectrics for Chip Interconnects Prepared by PECVD , 2009 .

[22]  Y. Nishi,et al.  Effect of thermal annealing on charge exchange between oxygen interstitial defects within HfO2 and oxygen-deficient silicon centers within the SiO2/Si interface , 2009 .

[23]  T. Spooner,et al.  Conduction Mechanisms of Ta/Porous SiCOH Films under Electrical Bias , 2008 .

[24]  N. Possémé,et al.  Modifications of dielectric films induced by plasma ashing processes: Hybrid versus porous SiOCH materials , 2008 .

[25]  F. Iacopi,et al.  Ultraviolet-Assisted Curing of Organosilicate Glass Low-k Dielectric by Excimer Lamps , 2008 .

[26]  Charge trapping at the low-k dielectric-silicon interface probed by the conductance and capacitance techniques , 2008 .

[27]  Analysis of electrically biased paramagnetic defect centers in HfO2 and HfxSi1−xO2/(100)Si interfaces , 2008 .

[28]  M. Benoit,et al.  On the nature of native defects in high OH-content silica glasses: A first-principles study , 2008 .

[29]  Tony F. Heinz,et al.  Photocurrent spectroscopy of low-k dielectric materials: Barrier heights and trap densities , 2008 .

[30]  M. Hori,et al.  Plasma damage mechanisms for low-k porous SiOCH films due to radiation, radicals, and ions in the plasma etching process , 2008 .

[31]  S. Gates,et al.  Interface engineering for high interfacial strength between SiCOH and porous SiCOH interconnect dielectrics and diffusion caps , 2008 .

[32]  G. Upadhyaya.  Effects of vacuum-ultraviolet radiation on the plasma-induced charging of patterned-dielectric materials , 2008 .

[33]  J. L. Shohet,et al.  Direct measurement of topography-dependent charging of patterned oxide/semiconductor structures , 2007 .

[34]  E. Petitprez,et al.  Evaluation of a PECVD advanced barrier (k=3.7) for 32nm CMOS technology and below , 2007 .

[35]  G. Groeseneken,et al.  Real-Time Investigation of Conduction Mechanism With Bias Stress in Silica-Based Intermetal Dielectrics , 2007, IEEE Transactions on Device and Materials Reliability.

[36]  V. Jousseaume,et al.  Comparison Between E-beam and Ultraviolet Curing to Perform Porous a-SiOC : H , 2007 .

[37]  Patrick M. Lenahan,et al.  Electron spin resonance observations of oxygen deficient silicon atoms in the interfacial layer of hafnium oxide based metal-oxide-silicon structures , 2007 .

[38]  Gerbrand Ceder,et al.  First-principles study of native point defects in hafnia and zirconia , 2007 .

[39]  E. Martinez,et al.  Charging and Aging Effects in Porous ULK Dielectrics , 2007 .

[40]  I. Berry,et al.  Requirements and Constraints on Optimizing UV Processing of Low-k Dielectrics , 2007 .

[41]  J. Shohet,et al.  Coupling of a vacuum-ultraviolet-radiation source to a processing system , 2006 .

[42]  K. Lynn,et al.  Nanoporous structure of low-dielectric-constant films: A process compatibility study , 2006 .

[43]  J. Planelles,et al.  Trapping electrons in semiconductor air bubbles: A theoretical approach , 2006, cond-mat/0603599.

[44]  J. Lloyd,et al.  Simple model for time-dependent dielectric breakdown in inter- and intralevel low-k dielectrics , 2005 .

[45]  S. Samukawa,et al.  Prediction of ultraviolet-induced damage during plasma processes in dielectric films using on-wafer monitoring techniques , 2005 .

[46]  Y. Lan,et al.  Simulation study of junction effect on field emission from one-dimensional nanostructure grown on silicon substrates , 2005, 2005 International Vacuum Nanoelectronics Conference.

[47]  J. Shohet,et al.  Surface potential measurements of vacuum ultraviolet irradiated Al/sub 2/O/sub 3/, Si/sub 3/N/sub 4/, and SiO/sub 2/ , 2005, IEEE Transactions on Plasma Science.

[48]  J. Shohet,et al.  Monte Carlo simulation of the effects of vacuum-ultraviolet radiation on dielectric materials , 2005 .

[49]  A. Stesmans,et al.  Paramagnetic defects in annealed ultrathin layers of SiOx, Al2O3, and ZrO2 on (100)Si , 2004 .

[50]  G.B. Alers,et al.  Interlevel dielectric failures in copper/low-k structures , 2004, IEEE Transactions on Device and Materials Reliability.

[51]  K. Gleason,et al.  Organosilicon Thin Films Deposited from Cyclic and Acyclic Precursors Using Water as an Oxidant , 2004 .

[52]  Ahila Krishnamoorthy,et al.  Dependence of leakage mechanisms on dielectric barrier in Cu-SiOC damascene interconnects , 2004 .

[53]  Lu Shen,et al.  Comparison of mechanical properties of porous and non-porous low- k dielectric films , 2004 .

[54]  S. Lai.  A critical overview on spacecraft charging mitigation methods , 2003 .

[55]  J. Cluzel,et al.  Challenges of back end of the line for sub 65 nm generation , 2003 .

[56]  Kuei-Hsien Chen,et al.  Band-gap dependence of field emission from one-dimensional nanostructures grown on n-type and p-type silicon substrates , 2003 .

[57]  Jr Dennison,et al.  Measurement of conductivity and charge storage in insulators related to spacecraft charging , 2003, 2003 Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[58]  A. Stesmans,et al.  Si dangling-bond-type defects at the interface of (100)Si with ultrathin HfO2 , 2003 .

[59]  T. Hayakawa,et al.  Formation of Sm2+ ions in femtosecond laser excited Al2O3 – SiO2 glasses , 2003 .

[60]  A. Grill.  Plasma enhanced chemical vapor deposited SiCOH dielectrics: from low-k to extreme low-k interconnect materials , 2003 .

[61]  Rusli,et al.  Atomic structure and defect densities in low dielectric constant carbon doped hydrogenated silicon oxide films, deposited by plasma-enhanced chemical vapor deposition , 2002 .

[62]  T. Wong,et al.  Surface modified silica mesoporous films as a low dielectric constant intermetal dielectric , 2002 .

[63]  S. Rhee,et al.  Remote Plasma-Enhanced Chemical Vapor Deposition of Nanoporous Low-Dielectric Constant SiCOH Films Using Vinyltrimethylsilane , 2002 .

[64]  D. Schroder.  Contactless surface charge semiconductor characterization , 2002 .

[65]  J. Shohet,et al.  Photoemission and conduction currents in vacuum ultraviolet irradiated aluminum oxide , 2002 .

[66]  J. Frejlich,et al.  Dark conductivity, photoconductivity, and light-induced absorption in photorefractive sillenite crystals , 2001 .

[67]  J. Shohet,et al.  Depletion of charge produced during plasma exposure in aluminum oxide by vacuum ultraviolet radiation , 2000 .

[68]  C. Cismaru,et al.  In situ electrical characterization of dielectric thin films directly exposed to plasma vacuum-ultraviolet radiation , 2000 .

[69]  M. R. Baklanov,et al.  Determination of pore size distribution in thin films by ellipsometric porosimetry , 2000 .

[70]  T. W. Hamilton,et al.  Absolute Intensities of the Vacuum Ultraviolet Spectra in a Metal-Etch Plasma Processing Discharge , 1999 .

[71]  Ming-Yi Lee,et al.  Comparison of CHARM-2 and surface potential measurement to monitor plasma induced gate oxide damage , 1999, 1999 4th International Symposium on Plasma Process-Induced Damage (IEEE Cat. No.99TH8395).

[72]  J. Shohet,et al.  Plasma vacuum ultraviolet emission in an electron cyclotron resonance etcher , 1999 .

[73]  C. Cismaru.  Charging and vacuum-ultraviolet radiation effects on plasma processing induced damage of semiconductor devices , 1999 .

[74]  I. D. Baikie,et al.  Low cost PC based scanning Kelvin probe , 1998 .

[75]  J. F. Conley,et al.  What can electron paramagnetic resonance tell us about the Si/SiO2 system? , 1998 .

[76]  W. Wilson,et al.  Tunneling induced charge generation in SiO2 thin films , 1998 .

[77]  J. Cazaux,et al.  A physical approach to the radiation damage mechanisms induced by X‐rays in X‐ray microscopy and related techniques , 1997 .

[78]  A. Hoff,et al.  A novel approach to monitoring of plasma processing equipment and plasma damage without test structures , 1997, 1997 IEEE/SEMI Advanced Semiconductor Manufacturing Conference and Workshop ASMC 97 Proceedings.

[79]  Robert F. Pierret,et al.  Semiconductor device fundamentals , 1996 .

[80]  Wang,et al.  Dark conductivity and photoconductivity in solid films of C70, C60, and KxC70. , 1994, Physical review. B, Condensed matter.

[81]  James H. Stathis,et al.  Interface defects of ultrathin rapid‐thermal oxide on silicon , 1993 .

[82]  K. D. Cummings,et al.  Charging effects from electron beam lithography , 1989 .

[83]  H. Hayakawa,et al.  Investigation of the charging effect on thin SiO2 layers with the electron beam lithography system , 1989 .

[84]  H. Queisser,et al.  Decay kinetics of persistent photoconductivity in semiconductors. , 1986, Physical review. B, Condensed matter.

[85]  H. Queisser,et al.  Nonexponential relaxation of conductance near semiconductor interfaces. , 1985, Physical review letters.

[86]  J. Robertson,et al.  Theory of defects in vitreous silicon dioxide , 1983 .

[87]  Theodore I. Kamins,et al.  Device Electronics for Integrated Circuits , 1977 .

[88]  R. Powell.  Hole photocurrents and electron tunnel injection induced by trapped holes in SiO2 films , 1975 .

[89]  M. Lenzlinger,et al.  Fowler‐Nordheim Tunneling into Thermally Grown SiO2 , 1969 .