The impact of temperature on nitrification rate in fixed film biofilters

Abstract The impact of temperature on nitrification rate was evaluated in this study through experimental tests, mathematical modeling and sensitivity analysis. The results show that the impact of temperature on fixed film nitrification rate is less significant than that predicted by the van't Hoff–Arrhenius equation. In a fixed film biofilter, the impact of temperature on nitrification rate due to DO (dissolved oxygen) limitation is different from that due to TAN (total ammonia nitrogen) limitation. Sensitivity analysis indicated that a temperature increment at 20 °C resulted in nitrification rate increase of 1.108% per °C and 4.275% per °C under DO and TAN limited conditions, respectively. Diffusion mass transport plays an important role in fixed film nitrification processes. Consequently, the effect of temperature on nitrification rate due to bacterial growth rate change in fixed film processes is greatly reduced compared with that of suspended growth processes. When oxygen is limited, the decrease in saturation DO concentration as temperature increases results in a negative temperature impact upon the nitrification rate.

[1]  B. Rittmann,et al.  Development and experimental evaluation of a steady‐state, multispecies biofilm model , 1992, Biotechnology and bioengineering.

[2]  S. Altobelli,et al.  NMR Imaging of Hydrodynamics Near Microbially Colonized Surfaces , 1992 .

[3]  Songming Zhu,et al.  An experimental study on nitrification biofilm performances using a series reactor system , 1999 .

[4]  Guanghao Chen,et al.  Determination of diffusion layer thickness on a biofilm , 1996 .

[5]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[6]  V. Lazarova,et al.  Influence of dissolved oxygen on the nitrification kinetics in a circulating bed biofilm reactor , 1998 .

[7]  R. Srna,et al.  Kinetic response of perturbed marine nitrification systems. , 1975, Journal - Water Pollution Control Federation.

[8]  A. Downing,et al.  DETERMINATION OF KINETIC CONSTANTS FOR NITRIFYING BACTERIA IN MIXED CULTURE, WITH THE AID OF AN ELECTRONIC COMPUTER. , 1965, Journal of general microbiology.

[9]  Yu Liu,et al.  Kinetic behaviors of nitrifying biofblm growth in wastewater nitrification process , 1994 .

[10]  Gerasimos Lyberatos,et al.  Effect of temperature and ph on the effective maximum specific growth rate of nitrifying bacteria , 1990 .

[11]  Miloslav Drtil,et al.  Kinetic constants of nitrification , 1993 .

[12]  O. E. Albertson,et al.  Evidence for oxygen-limiting conditions during tertiary fixed-film nitrification , 1989 .

[13]  R. C. Weast.  Handbook of chemistry and physics , 1973 .

[14]  J. Tramper,et al.  Immobilized cells: basics and applications. , 1996 .

[15]  F. W. Wheaton,et al.  Nitrification filter principles , 1994 .

[16]  George Tchobanoglous,et al.  Wastewater Engineering Treatment Disposal Reuse , 1972 .

[17]  W. G. Characklis,et al.  Reaction kinetics in biofilms , 1991, Biotechnology and bioengineering.

[18]  F. Fdz-Polanco,et al.  Temperature effect on nitrifying bacteria activity in biofilters: activation and free ammonia inhibition , 1994 .

[19]  P. Mccarty,et al.  Chemistry for environmental engineering , 1978 .

[20]  K. Vorlop,et al.  Nitrification in PVAL Beads: Influence of pH and Temperature on Nitrite Oxidation , 1996 .

[21]  S. Strand,et al.  Mathematical analysis of oxygen and nitrate consumption in deep microbial films , 1985 .

[22]  Denny S. Parker,et al.  Process Design Manual for Nitrogen Control. , 1975 .

[23]  W. Gujer,et al.  Design of a nitrifying tertiary trickling filter based on theoretical concepts , 1986 .

[24]  Y. Watanabe,et al.  Simultaneous Nitrification and Denitrification in Micro-Aerobic Biofilms , 1992 .

[25]  P L McCarty,et al.  A model of substrate utilization by bacterial films. , 1976, Journal - Water Pollution Control Federation.

[26]  Michael B. Timmons,et al.  Aquaculture water reuse systems: engineering design and management. , 1994 .

[27]  Bruce E. Rittmann,et al.  Advanced Modeling of Mixed Populations of Heterotrophs and Nitrifiers Considering the Formation and Exchange of Soluble Microbial Products , 1992 .

[28]  W. Gujer,et al.  Parameters affecting nitrifying biofilm reactors , 1994 .

[29]  Guanghao Chen,et al.  Modelling of the Simultaneous Removal of Organic Substances and Nitrogen in a Biofilm , 1989 .

[30]  H. Horn.  Dynamics of a nitrifying bacteria population in a biofilm controlled by an oxygen microelectrode , 1994 .

[31]  Z. Lewandowski,et al.  Microelectrode measurements of local mass transport rates in heterogeneous biofilms. , 1998, Biotechnology and bioengineering.

[32]  P. Mccarty,et al.  Model of steady-state-biofilm kinetics. , 1980, Biotechnology and bioengineering.