Thermodynamic analysis of a novel Ejector Enhanced Vapor Compression Refrigeration (EEVCR) cycle

Abstract This paper presents a theoretical thermodynamic analysis of a novel Ejector Enhanced Vapor Compression Refrigeration (EEVCR) cycle using zeotropic mixture of propane and isobutane (R290/R600a) as a refrigerant to replace R134a in domestic refrigerators/freezers. 1 D thermodynamic model for a constant area mixing ejector is used to estimate the cycle performance under the condition of optimal operating regime. The Coefficient of Performance (COP), the Volumetric Cooling Capacity (VCC), Qv and the compressor pressure ratio are studied for the novel EEVCR cycle and the results are compared to the conventional cycle using pure fluid R134a and zeotropic mixture R290/R600a. A comparative study was carried out to determine the propane mass fraction, z in the zeotropic mixture that would be a suitable replacement for R134a. The results indicated that the cycle COP and Qv could be improved by 23% and 62.71%, respectively. In addition, the cycle COP and Qv for the proposed EEVCR cycle were higher by 70% than those for a modified ejector expansion cycle. Finally, the propane mass fraction of 60% in the zeotropic R290/R600a mixture was found to have similar saturation pressure as R134a and the cycle COP and Qv were found similar to those of R134a.

[1]  J. C. Champoussin,et al.  Les paramètres géométriques optima d'un éjecto-compresseur frigorifique , 1993 .

[2]  Bourhan Tashtoush,et al.  Performance study of ejector cooling cycle at critical mode under superheated primary flow , 2015 .

[3]  M. El-Morsi.  Energy and exergy analysis of LPG (liquefied petroleum gas) as a drop in replacement for R134a in domestic refrigerators , 2015 .

[4]  Xiao Wang,et al.  An experimental investigation on a novel ejector enhanced refrigeration cycle applied in the domestic refrigerator-freezer , 2015 .

[5]  Leelananda Rajapaksha,et al.  Influence of special attributes of zeotropic refrigerant mixtures on design and operation of vapour compression refrigeration and heat pump systems , 2007 .

[6]  Mehdi Rasti,et al.  Enhancement of domestic refrigerator’s energy efficiency index using a hydrocarbon mixture refrigerant , 2012 .

[7]  Rahman Saidur,et al.  Performance investigation of domestic refrigerator using pure hydrocarbons and blends of hydrocarbons as refrigerants , 2007 .

[8]  E. Nehdi,et al.  Simulation of an ejector used in refrigeration systems , 2011 .

[9]  Bilal Akash,et al.  Assessment of LPG as a possible alternative to R-12 in domestic refrigerators , 2003 .

[10]  M. Sorin,et al.  Effects of component polytropic efficiencies on the dimensions of monophasic ejectors , 2018 .

[11]  S. Jayaraj,et al.  Improved energy efficiency for HFC134a domestic refrigerator retrofitted with hydrocarbon mixture (HC290/HC600a) as drop-in substitute , 2007 .

[12]  D. Jung,et al.  Testing of propane/isobutane mixture in domestic refrigerators , 2000 .

[13]  Eric Johnson,et al.  Global warming from hfc , 1998 .

[14]  Michel Feidt,et al.  Comparison of the working domains of some compression heat pumps and a compression-absorption heat pump , 1997 .

[15]  Jianlin Yu,et al.  Theoretical investigation on an ejector–expansion refrigeration cycle using zeotropic mixture R290/R600a for applications in domestic refrigerator/freezers , 2015 .

[16]  S. Jayaraj,et al.  Experimental investigation of R290/R600a mixture as an alternative to R134a in a domestic refrigerator , 2009 .

[17]  Jianlin Yu,et al.  Thermodynamic analysis on a modified ejector expansion refrigeration cycle with zeotropic mixture (R290/R600a) for freezers , 2016 .

[18]  Lawrence R. Grzyll,et al.  Thermodynamic properties of refrigerant mixtures , 1990 .

[19]  G. Venkatarathnam,et al.  Refrigerants for vapour compression refrigeration systems , 2012 .

[20]  Bourhan Tashtoush,et al.  Comparative Thermodynamic Study of Refrigerants to Select the Best Environment-Friendly Refrigerant for Use in a Solar Ejector Cooling System , 2018, Arabian Journal for Science and Engineering.

[21]  K. Stephan.  Two-phase heat exchange for new refrigerants and their mixtures , 1995 .

[22]  Yong Tae Kang,et al.  Development of high efficiency cycles for domestic refrigerator-freezer application , 2015 .

[23]  W. Tsai.  An overview of environmental hazards and exposure risk of hydrofluorocarbons (HFCs). , 2005, Chemosphere.

[24]  Bin-Juine Huang,et al.  A combined-cycle refrigeration system using ejector-cooling cycle as the bottom cycle. , 2001 .

[25]  Jianlin Yu,et al.  Energy and exergy analysis of zeotropic mixture R290/R600a vapor-compression refrigeration cycle with separation condensation , 2015 .

[26]  Pradeep Bansal,et al.  An experimental study on HC290 and a commercial liquefied petroleum gas (LPG) mix as suitable replacements for HCFC22 , 1998 .

[27]  S. Wongwises,et al.  Experimental study of hydrocarbon mixtures to replace HFC-134a in a domestic refrigerator , 2005 .

[28]  Bogdan Diaconu,et al.  Numerical assessment of steam ejector efficiencies using CFD , 2009 .

[29]  Jianlin Yu,et al.  Performance analysis of an ejector enhanced refrigeration cycle with R290/R600a for application in domestic refrigerator/freezers , 2017 .

[30]  Bourhan Tashtoush,et al.  Experimental study of new refrigerant mixtures to replace R12 in domestic refrigerators , 2002 .

[31]  M. Fatouh,et al.  Experimental evaluation of a domestic refrigerator working with LPG , 2006 .

[32]  A. Selvaraju,et al.  Experimental investigation on R134a vapour ejector refrigeration system , 2006 .

[33]  M. Fatouh,et al.  Assessment of propane/commercial butane mixtures as possible alternatives to R134a in domestic refrigerators , 2006 .