High surface area and mesoporous graphene/activated carbon composite for adsorption of Pb(II) from wastewater

Abstract Since lead is a carcinogenic and non-biodegradable substance, its removal from water is of vital importance. Of all different removal pollutants techniques the adsorption is a promising method to remove Pb(II). The choice of adsorbent is a key factor to carry out this process efficiently. As already the adsorption of Pb(II) onto different porous materials have been studied, however the adsorption properties of graphene/activated carbon composite (GAC) to metal ions have not been reported yet. In this work, GAC was synthesized from graphene oxide and glucose. The samples were characterized by X-ray diffraction, Raman spectroscopy, SEM image and N 2 adsorption–desorption isotherms. The GAC possessed high surface area (2012 m 2 /g), large pore volume (1.61 cm 3 /g) and mesopore structure. To study the adsorption behavior of Pb(II) on GAC, effects of solution pH, GAC dosage and stirring speed were examined. Afterwards the adsorption isotherms and kinetics of the GAC for removal of Pb(II) were studied by different models. The GAC was found to follow the pseudo-second order kinetic model better than the pseudo-first order. In addition it was understood that the intraparticle diffusion which studied by the Weber–Morris equation addressed the mechanism of the adsorption properly. Since the adsorption isotherm experimental data was fitted better by Langmuir model than Freundlich, the Pb(II) adsorption on the GAC is mainly homogeneous and monolayer. Finally, the maximum adsorption capacity of Pb(II) was measured up to 217 mg/g, which is higher than many other adsorbents.

[1]  Katsutoshi Inoue,et al.  Adsorption behavior of heavy metals onto chemically modified sugarcane bagasse. , 2010, Bioresource technology.

[2]  Mohamed Kheireddine Aroua,et al.  Removal of lead from aqueous solutions on palm shell activated carbon. , 2006, Bioresource technology.

[3]  W. E. Marshall,et al.  Adsorption of metal ions by pecan shell-based granular activated carbons. , 2003, Bioresource technology.

[4]  Tzong-Horng Liou.  Development of mesoporous structure and high adsorption capacity of biomass-based activated carbon by phosphoric acid and zinc chloride activation , 2010 .

[5]  L. R. Miranda,et al.  Kinetic and isotherm studies of Cu(II) adsorption onto H3PO4-activated rubber wood sawdust. , 2005, Journal of colloid and interface science.

[6]  Weihua Zhang,et al.  Relative distribution of Pb2+ sorption mechanisms by sludge-derived biochar. , 2012, Water research.

[7]  Jiaxing Li,et al.  Few-layered graphene oxide nanosheets as superior sorbents for heavy metal ion pollution management. , 2011, Environmental science & technology.

[8]  Qingrong Qian,et al.  Effect of ZnO loading to activated carbon on Pb(II) adsorption from aqueous solution , 2006 .

[9]  Y. Huang,et al.  Fabrication and characterization of mesoporous activated carbon from Lemna minor using one-step H3PO4 activation for Pb(II) removal , 2014 .

[10]  Rui A.R. Boaventura,et al.  Influence of pH, ionic strength and temperature on lead biosorption by Gelidium and agar extraction algal waste , 2005 .

[11]  G. Mckay,et al.  Intraparticle diffusion processes during acid dye adsorption onto chitosan. , 2007, Bioresource technology.

[12]  Xianzhong Sun,et al.  High-performance supercapacitors based on a graphene–activated carbon composite prepared by chemical activation , 2012 .

[13]  Z. Koren,et al.  Production, characterization and methane storage potential of KOH-activated carbon from sugarcane molasses , 2013 .

[14]  Wei Lv,et al.  Adsorption of lead(II) ions from aqueous solution on low-temperature exfoliated graphene nanosheets. , 2011, Langmuir : the ACS journal of surfaces and colloids.

[15]  S. Nguyen,et al.  Graphene oxide, highly reduced graphene oxide, and graphene: versatile building blocks for carbon-based materials. , 2010, Small.

[16]  Abdullah Al-Mamun,et al.  Kinetic adsorption of application of carbon nanotubes for Pb(II) removal from aqueous solution. , 2009, Journal of environmental sciences.

[17]  Dongxing Yuan,et al.  The study of lead removal from aqueous solution using an electrochemical method with a stainless steel net electrode coated with single wall carbon nanotubes , 2013 .

[18]  Feng-Chin Wu,et al.  Comparisons of porous and adsorption properties of carbons activated by steam and KOH. , 2005, Journal of colloid and interface science.

[19]  Activated carbon/graphene composites with high-rate performance as electrode materials for electrochemical capacitors , 2013, Journal of Solid State Electrochemistry.

[20]  O. Gulnaz,et al.  A Study: Removal of Cu(II), Cd(II), and Pb(II) Ions from Real Industrial Water and Contaminated Water Using Activated Sludge Biomass , 2012 .

[21]  E. Akiba,et al.  Synthesis of KOH-activated porous carbon materials and study of hydrogen adsorption , 2013 .

[22]  Xiangke Wang,et al.  Removal of Pb(II) from aqueous solution by oxidized multiwalled carbon nanotubes. , 2008, Journal of hazardous materials.

[23]  N. A. Oladoja,et al.  Competitive modeling for the biosorptive removal of copper and lead ions from aqueous solution by Mansonia wood sawdust. , 2010, Bioresource technology.

[24]  Jiaxing Li,et al.  Removal of Pb(II) ions from aqueous solutions on few-layered graphene oxide nanosheets. , 2011, Dalton transactions.

[25]  M. Tadé,et al.  Adsorption of Cu(II), Pb(II) and humic acid on natural zeolite tuff in single and binary systems , 2008 .

[26]  H. Demiral,et al.  Preparation of high-surface area activated carbons from Paulownia wood by ZnCl2 activation , 2009 .

[27]  Chaohe Xu,et al.  Synthesis of novel hierarchical graphene/polypyrrole nanosheet composites and their superior electrochemical performance , 2011 .

[28]  Thomas W. Weber,et al.  Pore and solid diffusion models for fixed-bed adsorbers , 1974 .

[29]  K. C. Kemp,et al.  Synthesis of nano zerovalent iron nanoparticles--graphene composite for the treatment of lead contaminated water. , 2013, Journal of environmental management.

[30]  F. A. Al-Rub,et al.  Adsorption of Lead Ions from Aqueous Solution onto Activated Carbon and Chemically-Modified Activated Carbon Prepared from Date Pits , 2004 .

[31]  François Béguin,et al.  KOH and NaOH activation mechanisms of multiwalled carbon nanotubes with different structural organisation , 2005 .

[32]  H. A. Aziz,et al.  Heavy metals (Cd, Pb, Zn, Ni, Cu and Cr(III)) removal from water in Malaysia: post treatment by high quality limestone. , 2008, Bioresource technology.

[33]  H. Tao,et al.  Biomass based activated carbon obtained from sludge and sugarcane bagasse for removing lead ion from wastewater. , 2015, Bioresource technology.

[34]  W. Weber,et al.  Kinetics of Adsorption on Carbon from Solution , 1963 .

[35]  Fan Zhang,et al.  Preparation of highly developed mesoporous activated carbon fiber from liquefied wood using wood charcoal as additive and its adsorption of methylene blue from solution. , 2014, Bioresource technology.

[36]  Bin Du,et al.  EDTA functionalized magnetic graphene oxide for removal of Pb(II), Hg(II) and Cu(II) in water treatment: Adsorption mechanism and separation property , 2015 .

[37]  Antonio Macías-García,et al.  Preparation of activated carbon from cherry stones by chemical activation with ZnCl2 , 2006 .

[38]  Chungsying Lu,et al.  Sorption of divalent metal ions from aqueous solution by carbon nanotubes: A review , 2007 .

[39]  E. Fuente,et al.  KOH activated carbon from conventional and microwave heating system of a macroalgae waste from the Agar–Agar industry , 2014 .

[40]  Bingqing Wei,et al.  Competitive adsorption of Pb2+, Cu2+ and Cd2+ ions from aqueous solutions by multiwalled carbon nanotubes , 2003 .

[41]  D. Angın.  Production and characterization of activated carbon from sour cherry stones by zinc chloride , 2014 .

[42]  P. Brown,et al.  Evaluation of the adsorptive capacity of peanut hull pellets for heavy metals in solution , 2000 .

[43]  Lichun Zhang,et al.  SiO2/graphene composite for highly selective adsorption of Pb(II) ion. , 2012, Journal of colloid and interface science.

[44]  Jianhua Chen,et al.  Adsorption of Pb(II) on mesoporous activated carbons fabricated from water hyacinth using H3PO4 activation: Adsorption capacity, kinetic and isotherm studies , 2014 .

[45]  Arti Malviya,et al.  Studies on the adsorption kinetics and isotherms for the removal and recovery of Methyl Orange from wastewaters using waste materials. , 2007, Journal of hazardous materials.

[46]  G. Walker,et al.  Adsorption of Methylene Blue onto activated carbon produced from steam activated bituminous coal: A study of equilibrium adsorption isotherm , 2006 .

[47]  S. Luo,et al.  Amino siloxane oligomer-linked graphene oxide as an efficient adsorbent for removal of Pb(II) from wastewater. , 2014, Journal of hazardous materials.

[48]  Y. Uchida,et al.  Adsorption of indole on KOH-activated mesoporous carbon , 2013 .

[49]  S. Souza,et al.  Study of lead (II) adsorption onto activated carbon originating from cow bone , 2014 .

[50]  D. Musmarra,et al.  Mercury adsorption on granular activated carbon in aqueous solutions containing nitrates and chlorides. , 2011, Journal of hazardous materials.

[51]  M. Imamoglu,et al.  Removal of copper (II) and lead (II) ions from aqueous solutions by adsorption on activated carbon from a new precursor hazelnut husks , 2008 .

[52]  Xufeng Zhou,et al.  Synthesis of porous graphene/activated carbon composite with high packing density and large specific surface area for supercapacitor electrode material , 2014 .

[53]  W. Daud,et al.  Real-time determination of kinetics of adsorption of lead(II) onto palm shell-based activated carbon using ion selective electrode. , 2008, Bioresource technology.

[54]  J. Ngila,et al.  Adsorption studies of aqueous Pb(II) onto a sugarcane bagasse/multi-walled carbon nanotube composite , 2013 .

[55]  R. Tseng,et al.  Pore structure and adsorption performance of the KOH-activated carbons prepared from corncob. , 2005, Journal of colloid and interface science.

[56]  Jian Zhang,et al.  Adsorption of Pb(II) on activated carbon prepared from Polygonum orientale Linn.: kinetics, isotherms, pH, and ionic strength studies. , 2010, Bioresource technology.

[57]  Hongwei Li,et al.  The adsorption properties of Pb(II) and Cd(II) on functionalized graphene prepared by electrolysis method. , 2010, Journal of hazardous materials.

[58]  I. Langmuir.  THE ADSORPTION OF GASES ON PLANE SURFACES OF GLASS, MICA AND PLATINUM. , 1918 .

[59]  Hao Yu,et al.  Adsorption characteristic of acidified carbon nanotubes for heavy metal Pb(II) in aqueous solution , 2007 .

[60]  W. E. Marshall,et al.  Agricultural by-products as granular activated carbons for adsorbing dissolved metals and organics , 1998 .