A comparison of fresh and used aircraft oil for the identification of toxic substances linked to aerotoxic syndrome.

Fresh and used aircraft engine lubricants (Mobil Jet Oil II) were analysed using a Fourier Transform Ion Cyclotron Resonance Mass Spectrometer (FTICRMS) and comprehensive two dimensional gas chromatography with high resolution time of flight mass spectrometry (GCxGC-HRTOFMS). The composition of the fresh oil was established, with special focus to its tricresyl phosphate (TCP) content as this has formed the focus for most investigations into aerotoxic syndrome. The results showed that only four TCP isomers were present at detectable levels in the fresh oil: mmm-TCP, mmp-TCP, ppm-TCP and ppp-TCP. The results indicate that the formulation of Mobile Jet Oil II does not contain the more toxic ortho substituted TCP isomers at concentrations above 0.0005%. The temperatures of jet engines during operation are greater than 200 °C which creates the potential to alter the composition of the original oil and create other toxic compounds. The results show there may be a significant risk from alkylated cresyl phosphates, which were identified in the used oils at concentrations calculated in the range of 0.13-0.69%. w/w. Several xylenyl and ethylphenyl phosphates have been shown to exhibit a similar toxicity to ortho substituted TCP isomers which makes there discovery in used oil significant. These compounds should be included in future aircraft air quality studies and when assessing the risks and causes of aerotoxic syndrome.

[1]  P. Lein,et al.  A review of experimental evidence linking neurotoxic organophosphorus compounds and inflammation. , 2012, Neurotoxicology.

[2]  B. Li,et al.  Exposure to tri-o-cresyl phosphate detected in jet airplane passengers. , 2011, Toxicology and applied pharmacology.

[3]  C. Mackerer,et al.  Comparison of neurotoxic effects and potential risks from oral administration or ingestion of tricresyl phosphate and jet engine oil containing tricresyl phosphate. , 1999, Journal of toxicology and environmental health. Part A.

[4]  M. Abou‐Donia,et al.  Autoantibodies to Nervous System-Specific Proteins Are Elevated in Sera of Flight Crew Members: Biomarkers for Nervous System Injury , 2013, Journal of toxicology and environmental health. Part A.

[5]  J. Ramsden.  On the proportion of ortho isomers in the tricresyl phosphates contained in jet oil , 2013 .

[6]  E. J. Field,et al.  A Study on the Acute Toxicity of the Tri-aryl Phosphates Used as Plasticizers , 1960, British journal of industrial medicine.

[7]  M. Shehadi,et al.  Characterization of the frequency and nature of bleed air contamination events in commercial aircraft. , 2016, Indoor air.

[8]  A G Marshall,et al.  Kendrick mass defect spectrum: a compact visual analysis for ultrahigh-resolution broadband mass spectra. , 2001, Analytical chemistry.

[9]  Jacob de Boer,et al.  Tricresyl phosphate and the aerotoxic syndrome of flight crew members--current gaps in knowledge. , 2015, Chemosphere.

[10]  J. J. Ramsden.  The future of healthcare , 2014 .

[11]  M. Abou‐Donia,et al.  Autoantibody markers of neural degeneration are associated with post-mortem histopathological alterations of a neurologically injured pilot , 2014 .

[12]  N. Gnep,et al.  Cresol isomerization on HZSM-5 , 1997 .

[13]  Judith Murawski,et al.  An Attempt to Characterize the Frequency, Health Impact, and Operational Costs of Oil in the Cabin and Flight Deck Supply Air on U.S. Commercial Aircraft , 2008 .

[14]  P H Craig,et al.  Evaluation of the hazards of industrial exposure to tricresyl phosphate: a review and interpretation of the literature. , 1999, Journal of toxicology and environmental health. Part B, Critical reviews.

[15]  B. Jortner,et al.  Subchronic delayed neurotoxicity evaluation of jet engine lubricants containing phosphorus additives. , 1996, Fundamental and applied toxicology : official journal of the Society of Toxicology.

[16]  E. Kendrick.  A Mass Scale Based on CH2 = 14.0000 for High Resolution Mass Spectrometry of Organic Compounds. , 1963 .

[17]  Chris Winder,et al.  The toxicity of commercial jet oils. , 2002, Environmental research.

[18]  S. M. Ross,et al.  An emerging concern: Toxic fumes in airplane cabins , 2016, Cortex.

[19]  W. Mazurek,et al.  Determination of tricresyl phosphate air contamination in aircraft. , 2011, The Annals of occupational hygiene.

[20]  R. Flammang,et al.  Differentiation of the pyridine radical cation from its distonic isomers by ion–molecule reactions with dioxygen , 2009 .

[21]  Peder Wolkoff,et al.  Pollutant exposures and health symptoms in aircrew and office workers: Is there a link? , 2016, Environment international.

[22]  T. Brüning,et al.  Occupational exposure of air crews to tricresyl phosphate isomers and organophosphate flame retardants after fume events , 2013, Archives of Toxicology.

[23]  C. Mackerer,et al.  Subchronic Neurotoxicity of Oil Formulations Containing Either Tricresyl Phosphate or Tri-Orthocresyl Phosphate , 1993 .

[24]  Martin van den Berg,et al.  Health risk assessment of exposure to TriCresyl Phosphates (TCPs) in aircraft: a commentary. , 2014, Neurotoxicology.

[25]  Paul T.C. Harrison,et al.  Aircraft Cabin Air Sampling Study; Part 2 of the Final Report , 2011 .