Study of the distribution of the absorbed solar radiation on the performance of a CPC-type ICS water heater

An Integrated Collector Storage (ICS) solar water heater was designed, constructed and studied with an emphasis on its optical and thermal performance. The ICS system consists of one cylindrical horizontal tank properly mounted in a stationary symmetrical Compound Parabolic Concentrating (CPC) reflector trough. The main objective was the design and the construction of a low cost solar system with improved thermal performance based on the exploitation of the non-uniform distribution of the absorbed solar radiation on the cylindrical storage tank surface. A ray-tracing model was developed to gauge the distribution of the incoming solar radiation on the absorber surface and the results were compared with those from a theoretical optical model based on the average number of reflections. The variation of the optical efficiency as function of the incident angle of the incoming solar radiation along with its dependence on the month during annual operation of ICS system is presented. The ICS device was experimentally tested outdoors during a whole year in order to correlate the observed temperature rise and stratification of the stored water with the non-uniform distribution of the absorbed solar radiation. The results show that the upper part of the tank surface collects the larger fraction of the total absorbed solar radiation for all incident angles throughout the year. This is found to have a significant effect on the overall thermal performance of the ICS unit. In addition, the presented results can be considered important for the design and the operation of ICS systems consisting of cylindrical tank and CPC reflectors.

[1]  A. Rabl,et al.  The average distribution of solar radiation-correlations between diffuse and hemispherical and between daily and hourly insolation values , 1979 .

[2]  Yiannis Tripanagnostopoulos,et al.  ICS solar systems with horizontal cylindrical storage tank and reflector of CPC or involute geometry , 2004 .

[3]  Soteris A. Kalogirou,et al.  Performance enhancement of an integrated collector storage hot water system , 1999 .

[4]  A. Goetzberger,et al.  Single-tube integrated collector storage systems with transparent insulation and involute reflector , 1990 .

[5]  Yiannis Tripanagnostopoulos,et al.  ICS solar systems with horizontal (E–W) and vertical (N–S) cylindrical water storage tank , 2004 .

[6]  P. Bendt,et al.  Optical Analysis and Optimization of Line Focus Solar Collectors , 1979 .

[7]  Mervyn Smyth,et al.  Integrated collector storage solar water heaters , 2006 .

[8]  Mervyn Smyth,et al.  A comparative performance rating for an integrated solar collector/storage vessel with inner sleeves to increase heat retention , 1999 .

[9]  I. Kaptan,et al.  A theoretical and experimental investigation of a novel built-in-storage solar water heater , 1996 .

[10]  Gordon H. Spencer,et al.  General ray-tracing procedure , 1962 .

[11]  Yiannis Tripanagnostopoulos,et al.  Integrated collector storage solar systems with asymmetric CPC reflectors , 2004 .

[12]  P. Yianoulis,et al.  CPC solar collectors with multichannel absorber , 1996 .

[13]  Ari Rabl,et al.  Radiation transfer through specular passages—a simple approximation , 1977 .

[14]  Roland Winston,et al.  High Collection Nonimaging Optics , 1989, Other Conferences.

[15]  Jane H. Davidson,et al.  Measured Performance and Modeling of an Evacuated-Tube, Integral-Collector-Storage Solar Water Heater , 1995 .

[16]  Yiannis Tripanagnostopoulos,et al.  CPC type integrated collector storage systems , 2002 .

[17]  Yiannis Tripanagnostopoulos,et al.  Solar ICS systems with two cylindrical storage tanks , 1999 .

[18]  Philip C. Eames,et al.  Validated, unified model for optics and heat transfer in line-axis concentrating solar energy collectors , 1993 .

[19]  Yiannis Tripanagnostopoulos,et al.  Experimental study of CPC type ICS solar systems , 2004 .

[20]  P. Yianoulis,et al.  Integrated collector-storage systems with suppressed thermal losses , 1992 .

[21]  Jeffrey M. Gordon,et al.  Asymmetric CPC solar collectors with tubular receiver: Geometric characteristics and optimal configurations , 1986 .

[22]  Jeffrey M. Gordon,et al.  Truncation of CPC solar collectors and its effect on energy collection , 1985 .

[23]  Roland Winston,et al.  Design and test of non-evacuated solar collectors with compound parabolic concentrators , 1979 .

[24]  U. Ortabasi,et al.  An internal cusp reflector for an evacuated tubular heat pipe solar thermal collector , 1977 .

[25]  S. D. Probert,et al.  Optics of parabolic-trough, solar-energy collectors, possessing small concentration ratios , 1987 .