A concept of combined cooling, heating and power system utilising solar power and based on reversible solid oxide fuel cell and metal hydrides

Abstract In energy systems, multi-generation including co-generation and tri-generation has gained tremendous interest in the recent years as an effective way of waste heat recovery. Solid oxide fuel cells are efficient power plants that not only generate electricity with high energy efficiency but also produce high quality waste heat that can be further used for hot and chilled water production. In this work, we present a concept of combined cooling, heating and power (CCHP) energy system which uses solar power as a primary energy source and utilizes a reversible solid oxide fuel cell (R-SOFC) for producing hydrogen and generating electricity in the electrolyser (SOEC) and fuel cell (SOFC) modes, respectively. The system uses “high temperature” metal hydride (MH) for storage of both hydrogen and heat, as well as “low temperature” MH's for the additional heat management, including hot water supply, residential heating during winter time, or cooling/air conditioning during summer time. The work presents evaluation of energy balances of the system components, as well as heat-and-mass transfer modelling of MH beds in metal hydride hydrogen and heat storage system (MHHS; MgH2), MH hydrogen compressor (MHHC; AB5; A = La + Mm, B Ni + Co + Al + Mn) and MH heat pump (MHHP; AB2; A = Ti + Zr, B Mn + Cr + Ni + Fe). A case study of a 3 kWe R-SOFC is analysed and discussed. The results showed that the energy efficiencies are 69.4 and 72.4% in electrolyser and fuel cell modes, respectively. The round-trip COP's of metal hydride heat management system (MHHC + MHHP) are close to 40% for both heating and cooling outputs. Moreover, the tri-generation leads to an improvement of 36% in round-trip energy efficiency as compared to that of a stand-alone R-SOFC.

[1]  T. Klassen,et al.  Critical assessment and thermodynamic modeling of the Mg–H system , 1999 .

[2]  Yixiang Shi,et al.  A micro tri-generation system based on direct flame fuel cells for residential applications , 2014 .

[3]  Houcheng Zhang,et al.  Performance Analysis and Multi-Objective Optimization of an Irreversible Solid Oxide Fuel Cell-Stirling Heat Engine Hybrid System , 2013, International Journal of Electrochemical Science.

[4]  Jack Brouwer,et al.  Solid oxide fuel cell short stack performance testing - Part A: Experimental analysis and μ-combined heat and power unit comparison , 2017 .

[5]  Yingru Zhao,et al.  A new analytical approach to model and evaluate the performance of a class of irreversible fuel cells , 2008 .

[6]  Kai Choong Leong,et al.  Numerical study of an internal-reforming solid oxide fuel cell and adsorption chiller co-generation system , 2006 .

[7]  Rahman Saidur,et al.  Performance analysis of a co-generation system using solar energy and SOFC technology , 2014 .

[8]  K. F. Fong,et al.  Investigation on zero grid-electricity design strategies of solid oxide fuel cell trigeneration system for high-rise building in hot and humid climate , 2014 .

[9]  P. Marty,et al.  Hydrogen storage systems based on magnesium hydride: from laboratory tests to fuel cell integration , 2016 .

[10]  Khosrow Jafarpur,et al.  Exergoeconomic comparison of three novel trigeneration systems using SOFC, biomass and solar energies , 2016 .

[11]  Kent S. Udell,et al.  Metal hydrides based high energy density thermal battery , 2015 .

[12]  E. Baniasadi,et al.  Fuel cell energy generation and recovery cycle analysis for residential application , 2010 .

[13]  Farouk Fardoun,et al.  4-E based optimal management of a SOFC-CCHP system model for residential applications , 2017 .

[14]  Umberto Desideri,et al.  Potential of Reversible Solid Oxide Cells as Electricity Storage System , 2016 .

[15]  P. Rodgers,et al.  Energy, exergy and economic analysis of an integrated solid oxide fuel cell – gas turbine – organic Rankine power generation system , 2016 .

[16]  Robert J. Braun,et al.  Evaluation of system configurations for solid oxide fuel cell-based micro-combined heat and power generators in residential applications , 2006 .

[17]  L. Barelli,et al.  Study of SOFC-SOE transition on a RSOFC stack , 2017 .

[18]  Xiangyu Meng,et al.  Theoretical study of a novel solar trigeneration system based on metal hydrides , 2010 .

[19]  Atsushi Tsutsumi,et al.  Energy recuperation in solid oxide fuel cell (SOFC) and gas turbine (GT) combined system , 2003 .

[20]  Isabel Malico,et al.  Design of a trigeneration system using a high‐temperature fuel cell , 2009 .

[21]  Yixin Lu,et al.  A solid oxide fuel cell system for buildings , 2007 .

[22]  J. Kupecki.  Off-design analysis of a micro-CHP unit with solid oxide fuel cells fed by DME , 2015 .

[23]  Torben R. Jensen,et al.  Review of magnesium hydride-based materials: development and optimisation , 2016 .

[24]  Javad Hosseinpour,et al.  Effect of recycling on the thermodynamic and thermoeconomic performances of SOFC based on trigeneration systems; A comparative study , 2017 .

[25]  Kalyanmoy Deb,et al.  A fast and elitist multiobjective genetic algorithm: NSGA-II , 2002, IEEE Trans. Evol. Comput..

[26]  Ye. V. Klochko,et al.  Poisoning-tolerant metal hydride materials and their application for hydrogen separation from CO2/CO containing gas mixtures , 2013 .

[27]  H. V. Storch,et al.  Techno economic design of a solid oxide electrolysis system with solar thermal steam supply and thermal energy storage for the generation of renewable hydrogen , 2017 .

[28]  Arild Vik,et al.  Regenerative Energy Storage System for Space Exploration Missions , 2017 .

[29]  P. Muthukumar,et al.  Erratum to “Metal hydride based heating and cooling systems: A review” [International Journal of Hydrogen Energy (2010) 35: 3817–3831] , 2010 .

[30]  P. Marty,et al.  Coupling and thermal integration of a solid oxide fuel cell with a magnesium hydride tank , 2013 .

[31]  Ibrahim Dincer,et al.  Energy and exergy analyses of an ethanol-fueled solid oxide fuel cell for a trigeneration system , 2015 .

[32]  Hideo Yoshida,et al.  An Analysis of a Micro Cogeneration System Composed of Solid Oxide Fuel Cell, Microturbine, and H2O/LiBr Absorption Refrigerator , 2007 .

[33]  Farouk Fardoun,et al.  Selection based on differences between cogeneration and trigeneration in various prime mover technologies , 2017 .

[34]  Bin Chen,et al.  A novel design of solid oxide electrolyser integrated with magnesium hydride bed for hydrogen generation and storage – A dynamic simulation study , 2017 .

[35]  Luisa F. Cabeza,et al.  Review on sorption materials and technologies for heat pumps and thermal energy storage , 2017 .

[36]  B. Pollet,et al.  Magnesium–carbon hydrogen storage hybrid materials produced by reactive ball milling in hydrogen , 2013 .

[37]  C. A. Infante Ferreira,et al.  Analytic modelling of steady state single-effect absorption cycles , 2008 .

[38]  F. Barbir,et al.  The use of metal hydrides in fuel cell applications , 2017 .

[39]  Pio A. Aguirre,et al.  Modeling and simulation of absorption–desorption cyclic processes for hydrogen storage-compression using metal hydrides , 2011 .

[40]  Marc A. Rosen,et al.  Energy and exergy assessments of a novel trigeneration system based on a solid oxide fuel cell , 2014 .

[41]  V. Linkov,et al.  Induction melted AB2-type metal hydrides for hydrogen storage and compression applications , 2018 .

[42]  Francesco Ghigliazza,et al.  Testing and Preliminary Modelling of a 2.5 kW Micro-CHP SOFC Unit , 2016 .

[43]  Yiping Dai,et al.  Thermodynamic analysis of a new combined cooling, heat and power system driven by solid oxide fuel cell based on ammonia–water mixture , 2011 .

[44]  Steven B. Kraines,et al.  CO2-emissions reduction potential and costs of a decentralized energy system for providing electricity, cooling and heating in an office-building in Tokyo , 2006 .

[45]  M. Li,et al.  Thermodynamic performance analysis of a fuel cell trigeneration system integrated with solar-assisted methanol reforming , 2017 .

[46]  Mehdi Mehrpooya,et al.  Optimal design and economic analysis of a hybrid solid oxide fuel cell and parabolic solar dish collector, combined cooling, heating and power (CCHP) system used for a large commercial tower , 2017 .

[47]  V. Yartys,et al.  Combustion‐type hydrogenation of nanostructured Mg‐based composites for hydrogen storage , 2009 .

[48]  S. Velumani,et al.  Proposal of a hybrid CHP system: SOFC/microturbine/absorption chiller , 2010 .

[49]  P. Muthukumar,et al.  Experiments on a metal hydride-based hydrogen storage device , 2005 .

[50]  Ricardo Martinez-Botas,et al.  Solid oxide fuel cell/gas turbine trigeneration system for marine applications , 2011 .

[51]  A. Perna,et al.  Performance Assessment of Electric Energy Storage (EES) Systems Based on Reversible Solid Oxide Cell , 2016 .

[52]  I. Dincer,et al.  Energy analysis of a trigeneration plant based on solid oxide fuel cell and organic Rankine cycle , 2010 .

[53]  Hongbin Zhao,et al.  Performance analysis of the SOFC–CCHP system based on H2O/Li–Br absorption refrigeration cycle fueled by coke oven gas , 2015 .

[54]  Marc A. Rosen,et al.  Greenhouse gas emission and exergy analyses of an integrated trigeneration system driven by a solid oxide fuel cell , 2015 .