LDMOS Channel Thermometer Based on a Thermal Resistance Sensor for Balancing Temperature in Monolithic Power ICs

This paper presents a method of thermal balancing for monolithic power integrated circuits (ICs). An on-chip temperature monitoring sensor that consists of a poly resistor strip in each of multiple parallel MOSFET banks is developed. A temperature-to-frequency converter (TFC) is proposed to quantize on-chip temperature. A pulse-width-modulation (PWM) methodology is developed to balance the channel temperature based on the quantization. The modulated PWM pulses control the hottest of metal-oxide-semiconductor field-effect transistor (MOSFET) bank to reduce its power dissipation and heat generation. A test chip with eight parallel MOSFET banks is fabricated in TSMC 0.25 μm HV BCD processes, and total area is 900 × 914 μm2. The maximal temperature variation among the eight banks can reduce to 2.8 °C by the proposed thermal balancing system from 9.5 °C with 1.5 W dissipation. As a result, our proposed system improves the lifetime of a power MOSFET by 20%.

[1]  Paul Ampadu,et al.  Temperature Effects in Semiconductors , 2012 .

[2]  Bantval J. Baliga,et al.  The future of power semiconductor device technology , 2001, Proc. IEEE.

[3]  Yi Lin,et al.  All-Digital Time-Domain CMOS Smart Temperature Sensor with On-Chip Linearity Enhancement , 2016, Sensors.

[4]  M. Stecher,et al.  Accurate Temperature Measurements of DMOS Power Transistors up to Thermal Runaway by Small Embedded Sensors , 2012, IEEE Transactions on Semiconductor Manufacturing.

[5]  Chenming Hu,et al.  Hot-Electron-Induced MOSFET Degradation - Model, Monitor, and Improvement , 1985, IEEE Journal of Solid-State Circuits.

[6]  Martin Pfost,et al.  Small embedded sensors for accurate temperature measurements in DMOS power transistors , 2010, 2010 International Conference on Microelectronic Test Structures (ICMTS).

[7]  Carlos Gómez Osuna,et al.  A Self-Timed Multipurpose Delay Sensor for Field Programmable Gate Arrays (FPGAs) , 2014, Sensors.

[8]  Hamid Hadim,et al.  Thermal Modeling Technique for Multiple Transistors Within Silicon Chip , 2011 .

[9]  Atila Alvandpour,et al.  Reliability challenges in avionics due to silicon aging , 2012, 2012 IEEE 15th International Symposium on Design and Diagnostics of Electronic Circuits & Systems (DDECS).

[10]  R. Viswanath.  Thermal Performance Challenges from Silicon to Systems , 2000 .

[11]  Juan Carlos Torres,et al.  Temperature-Frequency Converter Using a Liquid Crystal Cell as a Sensing Element , 2012, Sensors.

[12]  Yuan Gao,et al.  A 16–28-W 92.8%-Efficiency Monolithic Quasi-Resonant LED Driver With Constant-Duty-Ratio Frequency Regulator , 2015, IEEE Transactions on Circuits and Systems II: Express Briefs.

[13]  Minkyu Je,et al.  Temperature Sensor Front End in SOI CMOS Operating up to 250 $^{\circ}\hbox{C}$ , 2014, IEEE Transactions on Circuits and Systems II: Express Briefs.

[14]  Chun-Chi Chen,et al.  Accurate Behavioral Simulator of All-Digital Time-Domain Smart Temperature Sensors by Using SIMULINK , 2016, Sensors.

[15]  Chun-Chi Chen,et al.  A Linearization Time-Domain CMOS Smart Temperature Sensor Using a Curvature Compensation Oscillator , 2013, Sensors.

[16]  M. Stecher,et al.  Electrothermal Simulation of Self-Heating in DMOS Transistors up to Thermal Runaway , 2013, IEEE Transactions on Electron Devices.

[17]  V. Parthasarathy,et al.  Detection and optimization of temperature distribution across large-area power MOSFETs to improve energy capability , 2004, IEEE Transactions on Electron Devices.

[18]  Poki Chen,et al.  All-Digital Time-Domain Smart Temperature Sensor With an Inter-Batch Inaccuracy of $-{\hbox {0.7}} ~^{\circ}{\hbox {C}}-+{\hbox {0.6}}~^{\circ}{\hbox {C}}$ After One-Point Calibration , 2011, IEEE Transactions on Circuits and Systems I: Regular Papers.

[19]  A. Hajimiri,et al.  Integrated Self-Healing for mm-Wave Power Amplifiers , 2013, IEEE Transactions on Microwave Theory and Techniques.

[20]  M. Tack,et al.  Safe Operating Area Considerations for Integrated Trench-Based Power Devices , 2009, IEEE Transactions on Device and Materials Reliability.

[21]  Julio Molleda,et al.  Infrared Thermography for Temperature Measurement and Non-Destructive Testing , 2014, Sensors.

[22]  Luigi Fortuna,et al.  Lumped Parameter Modeling for Thermal Characterization of High-Power Modules , 2014, IEEE Transactions on Components, Packaging and Manufacturing Technology.

[23]  José Luis González,et al.  Efficiency determination of RF linear power amplifiers by steady-state temperature monitoring using built-in sensors , 2013 .

[24]  T. Biondi,et al.  Distributed Modeling of Layout Parasitics in Large-Area High-Speed Silicon Power Devices , 2007, IEEE Transactions on Power Electronics.

[25]  Bantval J. Baliga,et al.  An overview of smart power technology , 1991 .

[26]  J.L. Ayala,et al.  A Nanowatt Smart Temperature Sensor for Dynamic Thermal Management , 2008, IEEE Sensors Journal.