Solid-state 3D imaging using a 1nJ/100ps laser diode transmitter and a single photon receiver matrix.

A 3D imaging concept based on pulsed time-of-flight focal plane imaging is presented which can be tailored flexibly in terms of performance parameters such as range, image update rate, field-of-view, 2D resolution, depth accuracy, etc. according to the needs of different applications. The transmitter is based on a laser diode operating in enhanced gain-switching mode with a simple MOS/CMOS-switch current driver and capable of producing short (~100ps FWHM) high energy (up to nJ) pulses at a high pulsing rate. The receiver consists of 2D SPAD and TDC arrays placed on the same die, but in separate arrays. Paraxial optics can be used to illuminate the target field-of-view with the receiver placed at the focal plane of the receiver lens. To validate the concept, a prototype system is presented with a bulk laser diode/MOS driver operating at a wavelength of 870nm with a pulsing rate of 100kHz as the transmitter and a single-chip 9x9 SPAD array with 10-channel TDC as the receiver. The possibility of using this method as a solid-state solution to the task of 3D imaging is discussed in the light of the results derived from this prototype.

[1]  E. H. Bottcher,et al.  Gain modulation of unbiased semiconductor lasers: ultrashort light-pulse generation in the 0.8 μm-1.3 μm wavelength range , 1986 .

[2]  K. Lau.  Gain switching of semiconductor injection lasers , 1988 .

[3]  R. Popovic,et al.  Low-noise silicon avalanche photodiodes fabricated in conventional CMOS technologies , 2002 .

[4]  Franco Zappa,et al.  Evolution and prospects for single-photon avalanche diodes and quenching circuits , 2004 .

[5]  P.-A. Besse,et al.  Design and characterization of a CMOS 3-D image sensor based on single photon avalanche diodes , 2005, IEEE Journal of Solid-State Circuits.

[6]  J. Kostamovaara,et al.  A CMOS time-to-digital converter with better than 10 ps single-shot precision , 2006, IEEE Journal of Solid-State Circuits.

[7]  G. Buller,et al.  Ranging and Three-Dimensional Imaging Using Time-Correlated Single-Photon Counting and Point-by-Point Acquisition , 2007, IEEE Journal of Selected Topics in Quantum Electronics.

[8]  J. Kostamovaara,et al.  Asymmetric-Waveguide Laser Diode for High-Power Optical Pulse Generation by Gain Switching , 2009, Journal of Lightwave Technology.

[9]  Juha Kostamovaara,et al.  Synchronization in a Multilevel CMOS Time-to-Digital Converter , 2009, IEEE Transactions on Circuits and Systems I: Regular Papers.

[10]  G. Buller,et al.  Resolving range ambiguity in a photon counting depth imager operating at kilometer distances. , 2010, Optics express.

[11]  Brent Schwarz,et al.  LIDAR: Mapping the world in 3D , 2010 .

[12]  J A Richardson,et al.  Scaleable Single-Photon Avalanche Diode Structures in Nanometer CMOS Technology , 2011, IEEE Transactions on Electron Devices.

[13]  Juha Kostamovaara,et al.  Quantum well laser with an extremely large active layer width to optical confinement factor ratio for high-energy single picosecond pulse generation by gain switching , 2011 .

[15]  J. Kostamovaara,et al.  Performance improvement by a saturable absorber in gain-switched asymmetric-waveguide laser diodes. , 2013, Optics express.

[16]  G. Erbert,et al.  Generation of sub-100 ps pulses with a peak power of 65 W by gain switching, pulse shortening, and pulse amplification using a semiconductor-based master oscillator-power amplifier system. , 2013, Applied optics.

[17]  E. Charbon,et al.  Architecture and applications of a high resolution gated SPAD image sensor. , 2014, Optics express.

[18]  Valerie C. Coffey.  Imaging in 3-D: Killer Apps Coming Soon to a Device Near You! , 2014 .

[19]  W. Brockherde,et al.  CMOS Imager With 1024 SPADs and TDCs for Single-Photon Timing and 3-D Time-of-Flight , 2014, IEEE Journal of Selected Topics in Quantum Electronics.

[20]  Vivek K. Goyal,et al.  Photon-Efficient Computational 3-D and Reflectivity Imaging With Single-Photon Detectors , 2014, IEEE Transactions on Computational Imaging.

[21]  J. Kostamovaara,et al.  On Laser Ranging Based on High-Speed/Energy Laser Diode Pulses and Single-Photon Detection Techniques , 2015, IEEE Photonics Journal.

[22]  J. Kostamovaara,et al.  High-Energy Picosecond Pulse Generation by Gain Switching in Asymmetric Waveguide Structure Multiple Quantum Well Lasers , 2015, IEEE Journal of Selected Topics in Quantum Electronics.

[23]  Alberto Tosi,et al.  Automotive Three-Dimensional Vision Through a Single-Photon Counting SPAD Camera , 2016, IEEE Transactions on Intelligent Transportation Systems.

[24]  Matteo Perenzoni,et al.  Compact SPAD-Based Pixel Architectures for Time-Resolved Image Sensors , 2016, Sensors.