Operational and Environmental Evaluation of Diesel Engines Burning Oxygen-Enriched Intake Air or Oxygen-Enriched Fuels: A Review

A method to curtail emissions of smoke and other pollutants from diesel engines is to enhance the oxygen supply to their combustion chamber. This can be accomplished by enriching either the intake air stream or the fuel stream with oxygen. Experimental studies concerning the oxygen-enrichment of intake air, have revealed large decrease of ignition delay, drastic decrease of soot emissions as well as reduction of CO and HC emissions while, brake specific fuel consumption (BSFC) remained unaffected and increasing of power output is feasible. However, this technique was accompanied by considerable increase of NO x emissions. Experimental and theoretical studies with oxygenated fuels have demonstrated large decrease of soot emissions, which correlated well with the fuel oxygen content. Reduction of CO and HC emissions with oxygenated fuels was also obtained. However, penalties in both BSFC and NO x emissions have been observed with oxygenation of diesel fuels. In both cases one has to weigh the tradeoffs in fuel economy, in power output and in the emissions of various pollutants. Moreover, fuel cost, availability and supply infrastructure, as well as equipment and operational costs, are among concerns that apply to these techniques. This manuscript presents a comparative evaluation of the two techniques regarding engine performance characteristics, environmental repercussions and economy of operation. The primary objective is to contrast the benefits and the drawbacks of the two techniques in view of economic, operational and environmental parameters. Results have shown that the overall economy of operation of the two techniques may be comparable, if the price of oxygenated fuel blends is similar to that of diesel fuel. Their impact on pollutant emissions may also be comparable, if the oxygen enrichment of either technique is limited to a low level (<23% by mass in the cylinder mixture). However, there are possibilities of increasing the power density of engines with oxygen enrichment of the intake air.

[1]  Robert W. Dibble,et al.  Emissions Performance of Oxygenate-in-Diesel Blends and Fischer-Tropsch Diesel in a Compression Ignition Engine , 1999 .

[2]  Mitsuharu Oguma,et al.  NO Emission Characteristics of a CI Engine Fueled with Neat Dimethyl Ether , 1999 .

[3]  Charles J. Mueller,et al.  Investigation of the Relationship Between DI Diesel Combustion Processes and Engine-Out Soot Using an Oxygenated Fuel , 2004 .

[4]  Hisaharu Takeuchi,et al.  A Study of Dimethyl Ether(DME) Flow in Diesel Nozzle , 2004 .

[5]  Charles J. Mueller,et al.  Glow Plug Assisted Ignition and Combustion of Methanol in an Optical DI Diesel Engine , 2001 .

[6]  D. Montalvo,et al.  The Effect of Oxygenated Fuels on Emissions from a Modern Heavy-Duty Diesel Engine , 1993 .

[7]  Hideyuki Tsunemoto,et al.  The Role of Oxygen in Intake and Exhaust on NO Emission, Smoke and BMEP of a Diesel Engine with EGR System , 1980 .

[8]  Andrea Bertola,et al.  Oxygenated Fuels for Particulate Emissions Reduction in Heavy-Duty DI-Diesel Engines with Common-Rail Fuel Injection , 2000 .

[9]  Takayuki Ito,et al.  Effects of Flame Lift-Off and Flame Temperature on Soot Formation in Oxygenated Fuel Sprays , 2003 .

[10]  Raj Sekar,et al.  Oxygen-Enriched Diesel Engine Experiments with a Low-Grade Fuel , 1993 .

[11]  N Ladommatos,et al.  The effect of aromatic hydrocarbons and oxygenates on diesel engine emissions , 2000 .

[12]  J. Jancirani,et al.  Combustion and Performance of a Diesel Engine with Oxygenated Diesel Blend , 2004 .

[13]  J. Garbak,et al.  Oxygenates for Advanced Petroleum-Based Diesel Fuels: Part 1. Screening and Selection Methodology for the Oxygenates , 2001 .

[14]  R. R. Sekar,et al.  Oxygen-Enriched Diesel Engine Performance: A Comparison of Analytical and Experimental Results , 1990 .

[15]  William J. Pitz,et al.  A WIDE RANGE MODELING STUDY OF DIMETHYL ETHER OXIDATION , 1997 .

[16]  Dimitrios T. Hountalas,et al.  Experimental Investigation to Determine the Effect of Fuel Aromatic Content on Gaseous and Particulate Emissions of IDI Diesel Engines , 2000 .

[17]  G. J. Suppes,et al.  Performance of Fischer-Tropsch Liquids with Oxygenates in a VW 1.9L TDI , 2001 .

[18]  Thomas A. Litzinger,et al.  A chemical kinetic modelling study of the mechanism of soot reduction by oxygenated additives in diesel engines , 2001 .

[19]  Kashmir S. Virk,et al.  Effects of Oxygen-Enriched Air on Diesel Engine Exhaust Emissions and Engine Performance , 1993 .

[20]  K. T. Rhee,et al.  Engine Performance and Exhaust Characteristics of Direct-injection Diesel Engine Operated with DME , 1997 .

[21]  Harry C. Watson,et al.  A New Look at Oxygen Enrichment 1) The Diesel Engine , 1990 .

[22]  Noboru Miyamoto,et al.  Nature of Fundamental Parameters Related to Engine Combustion for a Wide Range of Oxygenated Fuels , 2002 .

[23]  A. Pungs,et al.  THE INFLUENCE OF DIESEL FUEL COMPOSITION ON THE GASEOUS AND PARTICULATE EMISSIONS UNDER STEADY STATE AND TRANSIENT ENGINE OPERATION CONDITIONS , 2000 .

[24]  Jiang De-ming,et al.  Study of Performance and Combustion Characteristics of a DME-Fueled Light-Duty Direct-Injection Diesel Engine , 1999 .

[25]  Zuohua Huang,et al.  Combustion characteristics and heat release analysis of a direct injection compression ignition engine fuelled with diesel—dimethyl carbonate blends , 2003 .

[26]  Mitsuharu Oguma,et al.  A study of low-comression-ratio dimethyl ether diesel engines , 2002 .

[27]  Claudio Bertoli,et al.  In-cylinder Soot Evolution Analysis in a Transparent Research DI Diesel Engine Fed by Oxygenated Fuels , 2002 .

[28]  S. Y. No,et al.  SPRAY CHARACTERISTICS OF DME IN CONDITIONS OF COMMON RAIL INJECTION SYSTEM(II) , 2003 .

[29]  Jay O. Keller,et al.  Update on Engine Combustion Research at Sandia National Laboratories , 2001 .

[30]  S. M. Shahed,et al.  Effects of Injection Timing and Exhaust Gas Recirculation on Emissions from a D.I. Diesel Engine , 1981 .

[31]  Yukio Akasaka,et al.  A Comparison of Emissions from Clean Diesel Fuels , 1999 .

[32]  John E. Dec,et al.  Effects of Fuel Parameters and Diffusion Flame Lift-Off on Soot Formation in a Heavy-Duty DI Diesel Engine , 2002 .

[33]  Juhun Song,et al.  Effect of Oxygenated Fuel on Combustion and Emissions in a Light-Duty Turbo Diesel Engine , 2002 .

[34]  Thomas A. Litzinger,et al.  Effects of oxygenated additives on aromatic species in fuel-rich, premixed ethane combustion: a modeling study , 2003 .

[35]  N. Kapilan,et al.  Effect of Diethyl Ether on the Performance and Emission of a 4 - S Di Diesel Engine , 2003 .

[36]  K. W. Ragland,et al.  Test and evaluation of polymeric membranes for oxygen enrichment of air , 1989 .

[37]  Yuji Kawaguchi,et al.  Numerical and Experimental Analyses of the Injection Characteristics of Dimethyl Ether with a D. I. Diesel Injection System , 1999 .

[38]  Robert W. Dibble,et al.  Methylal and Methylal-Diesel Blended Fuels for Use in Compression-Ignition Engines , 1999 .

[39]  Robert L. McCormick,et al.  Combustion of fat and vegetable oil derived fuels in diesel engines , 1998 .

[40]  W. J. Wartinbee.  EMISSIONS STUDY OF OXYGEN ENRICHED AIR , 1971 .

[41]  James J. Eberhardt,et al.  Diethyl Ether (DEE) as a Renewable Diesel Fuel , 1997 .

[42]  Murray J. Thomson,et al.  The chemical structures of opposed flow diffusion flames of C3 oxygenated hydrocarbons (isopropanol, dimethoxy methane, and dimethyl carbonate) and their mixtures , 2004 .

[43]  Takayuki Ito,et al.  Detailed Chemical Kinetic Modeling of Diesel Spray Combustion with Oxygenated Fuels , 2001 .

[44]  N. Marinov,et al.  A detailed chemical kinetic model for high temperature ethanol oxidation , 1999 .

[45]  John B. Heywood,et al.  Effects of Oxygenated Fuels on DI Diesel Combustion and Emissions , 2001 .

[46]  Noboru Miyamoto,et al.  Chemical-Kinetic Analysis on PAH Formation Mechanisms of Oxygenated Fuels , 2002 .

[47]  C. Westbrook,et al.  Diesel combustion: an integrated view combining laser diagnostics, chemical kinetics, and empirical validation , 1999 .

[48]  Raj Sekar,et al.  Effects of oxygen enrichment and fuel emulsification on diesel engine performance and emissions , 1991 .

[49]  Yukio Akasaka,et al.  Effects of oxygenated fuel and cetane improver on exhaust emission from heavy-duty DI diesel engines , 1994 .

[50]  Noboru Miyamoto,et al.  Smokeless, Low NOx, High Thermal Efficiency, and Low Noise Diesel Combustion with Oxygenated Agents as Main Fuel , 1998 .

[51]  D. J. Rickeard,et al.  Oxygenates: An Evaluation of their Effects on Diesel Emissions , 2001 .

[52]  Raj Sekar,et al.  Utilizing intake-air oxygen-enrichment technology to reduce cold- phase emissions , 1995 .

[53]  J. Garbak,et al.  Dimethoxy Methane in Diesel Fuel: Part 3. The Effect of Pilot Injection, Fuels and Engine Operating Modes on Emissions of Toxic Air Pollutants and Gas/Solid Phase PAH , 2001 .

[54]  Dennis L. Siebers,et al.  Measurements of fuel effects on liquid-phase penetration in DI sprays , 1999 .

[55]  T. J. Held,et al.  A comprehensive mechanism for methanol oxidation , 1998 .

[56]  Spencer C. Sorenson,et al.  Performance and Emissions of a 0.273 Liter Direct Injection Diesel Engine Fuelled with Neat Dimethyl Ether , 1995 .

[57]  Dimitrios T. Hountalas,et al.  Experimental Investigation to Specify the Effect of Oxygenated Additive Content and Type on DI Diesel Engine Performance and Emissions , 2004 .

[58]  Juhun Song,et al.  Comparison of the Impact of Intake Oxygen Enrichment and Fuel Oxygenation on Diesel Combustion and Emissions , 2004 .

[59]  Robert W. Dibble,et al.  The Effect of Oxygenates on Diesel Engine Particulate Matter , 2002 .

[60]  Yasunori Takei,et al.  The Effects of Fuel Properties and Oxygenates on Diesel Exhaust Emissions , 1995 .

[61]  Charles J. Mueller,et al.  Effects of Oxygenated Compounds on Combustion and Soot Evolution in a DI Diesel Engine:Broadband Natural Luminosity Imaging , 2002 .

[62]  Dimitrios T. Hountalas,et al.  DI Diesel Engine Performance and Emissions from the Oxygen Enrichment of Fuels with Various Aromatic Content , 2004 .

[63]  Raj Sekar,et al.  Technical and economic evaluation of diesel engine with oxygen enrichment and water injection , 1990 .

[64]  Claudio Bertoli,et al.  Potentiality of Oxygenated Synthetic Fuel and Reformulated Fuel on Emissions from a Modern DI Diesel Engine , 1999 .

[65]  Constantin Pana,et al.  Results Obtained by Methanol Fuelling Diesel Engine , 2001 .

[66]  André L. Boehman,et al.  Effects of oxygenated blending compounds on emissions from a turbocharged direct injection diesel engine , 2000 .

[67]  David L. Hilden,et al.  The Emissions Performance of Oxygenated Diesel Fuels in a Prototype DI Diesel Engine , 2001 .

[68]  R Poola,et al.  Membrane-Based Air Composition Control for Light-Duty Diesel Vehicles: A Benefit and Cost Assessment , 1998 .

[69]  Charles J. Mueller,et al.  Isotopic Tracing of Fuel Component Carbon in the Emissions From Diesel Engines , 2002 .

[70]  N Miyamoto,et al.  Approaches to extremely low emissions and efficient diesel combustion with oxygenated fuels , 2000 .

[71]  Nicola Del Giacomo,et al.  Influence of Future Fuel Formulations on Diesel Engine Emissions - A Joint European Study , 1997 .

[72]  Raj Sekar,et al.  Cylinder Pressure Analysis of a Diesel Engine Using Oxygen-Enriched Air and Emulsified Fuels , 1990 .

[73]  Tadashi Murayama,et al.  Simultaneous Reductions of Smoke and NOx from a DI Diesel Engine with EGR and Dimethyl Carbonate , 1995 .

[74]  Takayuki Ito,et al.  Mechanism of smokeless diesel combustion with oxygenated fuels based on the dependence of the equivalence ration and temperature on soot particle formation , 2002 .

[75]  Dennis L. Siebers,et al.  Fuel Effects on Soot Processes of Fuel Jets at DI Diesel Conditions , 2003 .

[76]  Thomas A. Litzinger,et al.  Effects of Structure and Boiling Point of Oxygenated Blending Compounds in Reducing Diesel Emissions , 1999 .

[77]  Robert L. Mason,et al.  Effects of Cetane Number, Cetane Improver, Aromatics, and Oxygenates on 1994 Heavy-Duty Diesel Engine Emissions , 1994 .

[78]  P. Gateau,et al.  The Effects of Rapeseed Oil Methyl Ester on Diesel Engine Performance, Exhaust Emissions and Long-Term Behavior - A Summary of Three Years of Experimentation , 1995 .

[79]  Takashi Akimoto,et al.  Effects of DGM and Oxidation Catalyst on Diesel Exhaust Emissions , 1999 .

[80]  Claudio Bertoli,et al.  Evaluation of Combustion Behavior and Pollutants Emission of Advanced Fuel Formulations by Single Cylinder Engine Experiments , 1998 .

[81]  Claudio Bertoli,et al.  Diesel Combustion Improvements by the Use of Oxygenated Synthetic Fuels , 1997 .

[82]  Robert W. Dibble,et al.  Isotopic tracing of fuel carbon in the emissions of a compression-ignition engine fueled with biodiesel blends , 2003 .

[83]  J. Garbak,et al.  Oxygenates screening for AdvancedPetroleum-Based Diesel Fuels: Part 2. The Effect of Oxygenate Blending Compounds on Exhaust Emissions , 2001 .

[84]  Noboru Miyamoto,et al.  Improvement of Diesel Combustion and Emissions with Addition of Various Oxygenated Agents to Diesel Fuels , 1996 .

[85]  Dennis L. Siebers,et al.  Flame Lift-Off on Direct-Injection Diesel Sprays Under Quiescent Conditions , 2001 .

[86]  John C. Hilliard,et al.  Effect of Oxygen Enrichment on the Performance and Emissions of I.D.I. Diesel Engines , 1983 .

[87]  J. H. Van Gerpen,et al.  The effect of timing and oxidation on emissions from biodiesel-fueled engines. , 2001 .

[88]  Gen Shibata,et al.  The Effects of Oxygenate and Gasoline-Diesel Fuel Blends on Diesel Engine Emissions , 2000 .

[89]  Takayuki Ito,et al.  Soot Kinetic Modeling and Empirical Validation on Smokeless Diesel Combustion with Oxygenated Fuels , 2003 .

[90]  Selim M. Senkan,et al.  Effects of oxygenate additives on polycyclic aromatic hydrocarbons(pahs) and soot formation , 2002 .

[91]  Xianghui Meng,et al.  Quasi-dimensional multizone combustion model for direct injection engines fuelled with dimethyl ether , 2004 .

[92]  Dennis L. Siebers,et al.  Effects of Oxygenates on Soot Processes in DI Diesel Engines: Experiments and Numerical Simulations , 2003 .

[93]  Pierre-Alexandre Glaude,et al.  Experimental and modeling study of the gas-phase oxidation of methyl and ethyl tertiary butyl ethers , 2000 .

[94]  David E. Foster,et al.  Effects of Oxygen Enhancement on the Emissions from a DI Diesel via Manipulation of Fuels and Combustion Chamber Gas Composition , 2000 .

[95]  William J. Pitz,et al.  DETAILED CHEMICAL KINETIC MECHANISMS FOR COMBUSTION OF OXYGENATED FUELS , 2000 .

[96]  Noboru Miyamoto,et al.  Ultra Low Emissions and High Performance Diesel Combustion with a Combination of High EGR, Three-Way Catalyst, and a Highly Oxygenated Fuel, Dimethoxy Methane (DMM) , 2000 .

[97]  Charles J. Mueller,et al.  Using Carbon-14 Isotope Tracing to Investigate Molecular Structure Effects of the Oxygenate Dibutyl Maleate on Soot Emissions from a DI Diesel Engine , 2004 .

[98]  J. Garbak,et al.  Dimethoxy Methane in Diesel Fuel: Part 2. The Effect of Fuels on Emissions of Toxic Air Pollutants and Gas/Solid Phase PAH Using a Composite Of Engine Operating Modes , 2001 .

[99]  J. Dec.  A Conceptual Model of DI Diesel Combustion Based on Laser-Sheet Imaging* , 1997 .

[100]  Dennis L. Siebers,et al.  Flame Lift-Off on Direct-Injection Diesel Fuel Jets: Oxygen Concentration Effects , 2002 .

[101]  Dimitrios T. Hountalas,et al.  Theoretical Study Concerning the Effect of Oxygenated Fuels on DI Diesel Engine Performance and Emissions , 2004 .

[102]  Robert L. McCormick,et al.  Effect of Several Oxygenates on Regulated Emissions from Heavy-Duty Diesel Engines , 1997 .

[103]  K. T. Rhee,et al.  MTBE for improved diesel combustion and emissions , 1994 .

[104]  Yukio Akasaka,et al.  Evaluation of Oxygenated Fuel by Direct Injection Diesel and Direct Fuel Injection Impingement Diffusion Combustion Diesel Engines , 1990 .

[105]  G. Takeshi Sato,et al.  Temperature and Mixing Effects on NO x and Particulate , 1988 .