Investigation of the relationship between surface thermodynamics of the chemically synthesized polypyrrole films and their gas-sensing responses to BTEX compounds

Abstract Cl − -doped polypyrrole ( PPyCl ) films as sensing materials were prepared chemically using FeCl 3 as an oxidant and were used to detect benzene, toluene, ethylbenzene, and xylene (BTEX) compounds in their vapor phases, which were found to be able to enhance the doping level of PPyCl and hence increased the conductivity of PPyCl upon exposure to them. Three isomers of xylene, i.e. ortho ( o ), meta ( m ), and para ( p ), were also investigated for comparison. The sensitivities of PPyCl sensor exposed to BTEX compounds with various concentrations were measured and found to lie in the range of 0.08 mΩ/ppm (benzene)–0.8 mΩ/ppm ( o- xylene). An adsorption model based on the Langmuir isotherm correlated well with the experimental results and was used to interpret the sensing behavior of PPyCl sensor towards BTEX vapors. The adsorption equilibrium constants, K m , were therefore able to be determine according to this model. A further study of affinity between the interested BTEX compound and the PPyCl surface was carried out by a method of inverse gas chromatography (IGC) with PPyCl -coated glass beads packed in a column as the stationary phase and the interested BTEX compound as the mobile phase. The retention volumes for these compounds were measured to be in the following order: o -xylene> m -xylene> p -xylene≅ethylbenzene>toluene. This magnitude sequence was correlated well with that of the equilibrium constants K m . The free energy of adsorption Δ G a , consisting of dispersive term Δ G a d and the term of acid–base interaction Δ G a s , was also determined according to the results obtained from IGC and was used to interpret the sensing response. The interaction forces were analyzed in details by a method of linear solvation energy relationships (LSERs), by which the surface of the PPyCl was found to exhibit a basic nature.

[1]  G. Blasquez,et al.  Behaviour of electroactive polymers in gaseous oxidizing atmospheres , 1988 .

[2]  M. Chehimi,et al.  Effect of acid-base interactions on the adsorption of PMMA on chloride-doped polypyrrole from neutral, acidic and basic solvents: an XPS study , 1994 .

[3]  S. Armes,et al.  The determination of the surface energy of conducting polymers by inverse gas chromatography at infinite dilution , 1999 .

[4]  R. A. McGill,et al.  Determination of olive oil–gas and hexadecane–gas partition coefficients, and calculation of the corresponding olive oil–water and hexadecane–water partition coefficients , 1987 .

[5]  L. Yucheng,et al.  Characterization of a chemoresistor pH sensor based on conducting polypyrrole , 1994 .

[6]  D. R. Lloyd,et al.  Inverse gas chromatography : characterization of polymers and other materials , 1989 .

[7]  D. Gray,et al.  Adsorption of n-alkanes at zero surface coverage on cellulose paper and wood fibers , 1980 .

[8]  M. Delamar,et al.  Characterization of conducting polymers by inverse gas chromatography Part II. Effect of dopant on the dispersive and specific properties of polypyrrole , 1993 .

[9]  P. Bartlett,et al.  Conducting polymer gas sensors Part III: Results for four different polymers and five different vapours , 1989 .

[10]  Paolo Bruschi,et al.  Sensing properties of polypyrrole-polytetrafluoroethylene composite thin films from granular metal-polymer precursors , 1992 .

[11]  Philip N. Bartlett,et al.  Conducting polymer gas sensors part II: response of polypyrrole to methanol vapour , 1989 .

[12]  G. Wallace,et al.  High-performance liquid chromatography on polypyrrole-modified silica , 1991 .

[13]  Norman M. Ratcliffe,et al.  Polypyrrole-based sensor for hydrazine and ammonia , 1990 .

[14]  Bing-Joe Hwang,et al.  Characteristics and sensing behavior of electrochemically codeposited polypyrrole–poly(vinyl alcohol) thin film exposed to ethanol vapors , 1999 .

[15]  A. Ivaska,et al.  A polypyrrole-based amperometric ammonia sensor. , 1996, Talanta.

[16]  Tan,et al.  X-ray photoelectron spectroscopic studies of conductive polypyrrole complexes chemically synthesized with FeCl3. , 1990, Physical review. B, Condensed matter.

[17]  E. F. Meyer.  On Thermodynamics of Adsorption Using Gas-Solid Chromatography. , 1980 .

[18]  Michael H. Abraham,et al.  Hydrogen bonding. Part 34. The factors that influence the solubility of gases and vapours in water at 298 K, and a new method for its determination , 1994 .

[19]  Jay W. Grate,et al.  Hydrogen bonding. Part 18. Gas–liquid chromatographic measurements for the design and selection of some hydrogen bond acidic phases suitable for use as coatings on piezoelectric sorption detectors , 1991 .

[20]  P. Bartlett,et al.  Conducting polymer gas sensors part I: fabrication and characterization , 1989 .

[21]  Jiri Janata,et al.  Electrochemical and ultraviolet−visible spectroelectrochemical investigation of selectivity of potentiometric gas sensors based on polypyrrole , 1987 .

[22]  P. West,et al.  IN-SITU AFM STUDY OF THE SURFACE-MORPHOLOGY OF POLYPYRROLE FILM , 1995 .

[23]  Michael H. Abraham,et al.  Linear solvation energy relationship. 46. An improved equation for correlation and prediction of octanol/water partition coefficients of organic nonelectrolytes (including strong hydrogen bond donor solutes) , 1988 .

[24]  B. Hwang,et al.  Methanol sensors based on the conductive polymer composites from polypyrrole and poly (vinyl alcohol) , 1998 .

[25]  R. Doherty,et al.  Hydrogen bonding : XV. A new characterisation of the McReynolds 77-stationary phase set , 1990 .

[26]  B. Hwang,et al.  A Microscopic Gas‐Sensing Model for Ethanol Sensors Based on Conductive Polymer Composites from Polypyrrole and Poly(ethylene oxide) , 1999 .

[27]  M. Abraham,et al.  Hydrogen bonding: XXIII. Application of the new solvation equation to log Vg values for solutes on carbonaceous adsorbents , 1992 .

[28]  G. Wallace,et al.  Use of inverse thin layer chromatography with amino acids to characterize molecular interactions on conducting polymers , 1992 .

[29]  B. Hwang,et al.  Study of the actions of BTEX compounds on polypyrrole film as a gas sensor , 2001 .

[30]  C. L. Young,et al.  Physicochemical measurement by gas chromatography , 1979 .

[31]  J. H. de Boer,et al.  The dynamical character of adsorption , 1968 .

[32]  D. T. Sawyer,et al.  Specific interactions affecting gas chromatographic retention for modified alumina columns , 1968 .

[33]  M. Chehimi,et al.  Determination of acid–base properties of solid materials by inverse gas chromatography at infinite dilution. A novel empirical method based on the dispersive contribution to the heat of vaporization of probes , 1994 .