Characteristic rheological features of PVA solutions in water-containing solvents with different hydration states

Abstract Two organic solvent systems containing equimolar ratio of water but different association strenght, 8/2 by wt mixture of dimethyl sulfoxide (DMSO) and water and 86.7/13.3 by wt mixture of N -methyl morpholine N -oxide and water (NMMO monohydrate), were chosen and the rheological properties of polyvinyl alcohol (PVA) solutions in the solvents were investigated and compared. The associated state of water in the solvent systems had a significant effect on the rheological properties of the solutions. In dilute concentration regime, NMMO monohydrate gave higher intrinsic viscosity than DMSO/water although two solvents gave similar values of the Mark–Houwink exponent. More noticeable difference was observed on the viscosity curve in high concentration regime. DMSO/water exhibited near a Bingham behavior and gave much lower power-law index than NMMO monohydrate. On the logarithmic plot of storage modulus (G′) against loss modulus (G″), both solutions exhibited slight decrease in slope with increasing concentration. Of two solvent systems DMSO/water gave lower values of slope than NMMO monohydrate. In addition, NMMO monohydrate gave tan δ greater than one at low frequency whereas DMSO/water gave tan δ much less than one over the entire frequency range examined. Further, the frequency to cause gelation was decreased with increasing concentration in the case of NMMO monohydrate. This indicates that PVA/DMSO/water system is more heterogeneous because weakly bonded water molecules produce hydrogel structure.

[1]  Antje Potthast,et al.  The chemistry of side reactions and byproduct formation in the system NMMO/cellulose (Lyocell process) , 2001 .

[2]  L. Sperling.  Introduction to physical polymer science , 1986 .

[3]  T. Masuda,et al.  Critical behavior of the intrinsic viscosity of poly(vinylalcohol) solutions near the gelation point , 1990 .

[4]  P. Godard,et al.  Bisphenol-A polycarbonate-poly(butylene terephthalate) transesterification. III. Study of model reactions , 1982 .

[5]  C. Finch.  Polyvinyl alcohol : developments , 1992 .

[6]  M. Shibayama,et al.  Analogy between Swelling of Gels and Intrinsic Viscosity of Polymer Solutions for Ion-Complexed Poly(vinyl alcohol) in Aqueous Medium , 1996 .

[7]  H. Henning Winter,et al.  Analysis of Linear Viscoelasticity of a Crosslinking Polymer at the Gel Point , 1986 .

[8]  W. Lyoo,et al.  Spontaneous Orientation of Molecules during Saponification of Poly(vinyl pivalate) , 1998 .

[9]  L. Utracki,et al.  Current topics in polymer science , 1987 .

[10]  T. Kawai,et al.  Intra‐ and intermolecular hydrogen bonds in polyvinyl alcohol solutions , 1959 .

[11]  T. Nakajima.  Advanced fiber spinning technology , 1994 .

[12]  J. Yeum,et al.  Effect of degree of saponification on the rheological properties of syndiotactic poly(vinyl alcohol)/ water solution , 2002 .

[13]  P. Luckham,et al.  The effects of hydrogen bonding upon the viscosity of aqueous poly(vinyl alcohol) solutions , 2000 .

[14]  Dong Bok Kim,et al.  Effect of Thermal History on the Phase Behavior of N-Methyl Morpholine N-Oxide Hydrates and Their Solutions of Cellulose , 2001 .

[15]  Dong Bok Kim,et al.  Phase Transition of Cellulose Solutions in N-Methyl Morpholine N-Oxide Hydrates , 2001 .

[16]  K. Wissbrun,et al.  Rheology of a thermotropic polyester in the nematic and isotropic states , 1982 .

[17]  S. Pérez,et al.  Cellulose organic solvents. I. The structures of anhydrous N‐methylmorpholine N‐oxide and N‐methylmorpholine N‐oxide monohydrate , 1981 .

[18]  W. Lyoo,et al.  Phase Behavior and Physical Gelation of High Molecular Weight Syndiotactic Poly(vinyl alcohol) Solution , 2001 .

[19]  M. Okazaki,et al.  Syndiotacticity‐rich poly(vinyl alcohol) fibers spun from N‐methylmorpholine‐N‐oxide/water mixture , 1996 .