High-speed maskless nanolithography with visible light based on photothermal localization

High-speed maskless nanolithography is experimentally achieved on AgInSbTe thin films. The lithography was carried out in air at room temperature, with a GaN diode laser (λ = 405 nm), and on a large sample disk of diameter 120 mm. The normal width of the written features measures 46 ± 5 nm, about 1/12 of the diffraction allowed smallest light spot, and the lithography speed reaches 6 ~ 8 m/s, tens of times faster than traditional laser writing methods. The writing resolution is instantaneously tunable by adjusting the laser power. The reason behind the significant breakthrough in terms of writing resolution and speed is found as the concentration of light induced heat. Therefore, the heat spot is far smaller than the light spot, so does the size of the written features. Such a sharp focus of heat occurs only on the selected writing material, and the phenomenon is referred as the photothermal localization response. The physics behind the effect is explained and supported with numerical simulations.

[1]  Jingsong Wei,et al.  Optical nonlinearity characteristics of crystalline InSb semiconductor thin films , 2013 .

[2]  Xing Cheng,et al.  Dual-layer thermal nanoimprint lithography without dry etching , 2012 .

[3]  A. Knoll,et al.  Thermal probe maskless lithography for 27.5 nm half-pitch Si technology. , 2013, Nano letters.

[4]  Wei-Yao Hsu,et al.  Development of the fast astigmatic auto-focus microscope system , 2009 .

[5]  C. Wagner,et al.  EUV lithography: Lithography gets extreme , 2010 .

[6]  Zhongyi Guo,et al.  Arbitrary focusing lens by holographic metasurface , 2015 .

[7]  Erez Hasman,et al.  Dielectric gradient metasurface optical elements , 2014, Science.

[8]  Katsuhisa Tanaka,et al.  Optical Microfabrication of Chalcogenide Glasses , 1995, Science.

[9]  D Courjon,et al.  Smallest lithographic marks generated by optical focusing systems. , 2007, Optics letters.

[10]  Fuxi Gan,et al.  Temperature dependence of thermal properties of Ag8In14Sb55Te23 phase-change memory materials , 2009 .

[11]  E. Riedo,et al.  Advanced scanning probe lithography. , 2014, Nature nanotechnology.

[12]  W. T. Chen,et al.  Metalenses at visible wavelengths: Diffraction-limited focusing and subwavelength resolution imaging , 2016, Science.

[13]  Selective etching characteristics of the AgInSbTe phase-change film in laser thermal lithography , 2012 .

[14]  R. Fabian Pease,et al.  Maskless lithography , 2005 .

[15]  N. Yu,et al.  Flat optics with designer metasurfaces. , 2014, Nature materials.

[16]  Saulius Juodkazis,et al.  Two-photon lithography of nanorods in SU-8 photoresist , 2005 .

[17]  S. Pleasants.  Lithography: Chalcogenide promise , 2014 .

[18]  Fuxi Gan,et al.  Nonlinear absorption of Sb-based phase change materials due to the weakening of the resonant bond , 2012 .

[19]  Jingsong Wei,et al.  Direct detection of the transient superresolution effect of nonlinear saturation absorption thin films , 2015 .

[20]  Andrea R Tao,et al.  Colloidal metasurfaces displaying near-ideal and tunable light absorbance in the infrared , 2015, Nature Communications.

[21]  Jingsong Wei,et al.  High-speed laser writing of arbitrary patterns in polar coordinate system. , 2016, The Review of scientific instruments.

[22]  Jinghua Teng,et al.  Ultrahigh-capacity non-periodic photon sieves operating in visible light , 2015, Nature Communications.

[23]  Georg von Freymann,et al.  The Materials Challenge in Diffraction‐Unlimited Direct‐Laser‐Writing Optical Lithography , 2010, Advanced materials.

[24]  Three-step lithography to the fabrication of vertically coupled micro-ring resonators in amorphous silicon-on-insulator , 2016 .

[25]  Yoshimichi Ohki,et al.  Proposal of a grating-based optical reflection switch using phase change materials. , 2009, Optics express.

[26]  Jingsong Wei,et al.  Strong nonlinear saturation absorption-induced optical pinhole channel and super-resolution effects: a multi-layer system model. , 2014, Optics letters.

[27]  N. Zheludev,et al.  From metamaterials to metadevices. , 2012, Nature materials.

[28]  J W Goodman,et al.  Laser-induced local heating of multilayers. , 1982, Applied optics.

[29]  Munazza Zulfiqar Ali,et al.  Global transmission diagrams for evanescent waves in a nonlinear hyperbolic metamaterial , 2015 .

[30]  Robert R McLeod,et al.  Two-Color Single-Photon Photoinitiation and Photoinhibition for Subdiffraction Photolithography , 2009, Science.

[31]  Matthias Wuttig,et al.  Calorimetric measurements of structural relaxation and glass transition temperatures in sputtered films of amorphous Te alloys used for phase change recording , 2007 .

[32]  E. W. Stryland,et al.  Sensitive Measurement of Optical Nonlinearities Using a Single Beam Special 30th Anniversary Feature , 1990 .

[33]  Michael T. Gale,et al.  Fabrication of continuous-relief micro-optical elements by direct laser writing in photoresists , 1994 .

[34]  L. J. Guo,et al.  Nanoimprint Lithography: Methods and Material Requirements , 2007 .

[35]  Jingsong Wei,et al.  Chalcogenide phase-change thin films used as grayscale photolithography materials. , 2014, Optics express.

[36]  Shinji Okazaki,et al.  Pushing the limits of lithography , 2000, Nature.

[37]  Matthias Wuttig,et al.  Resonant bonding in crystalline phase-change materials. , 2008, Nature materials.

[38]  M. Telford.  Cancer nanotech centers founded , 2005 .