Demulsification techniques of water-in-oil and oil-in-water emulsions in petroleum industry

The difficulties associated with transportation and refining of crude oil emulsions and produced water discharge limitations are among the conspicuous clues that have led the oilfield researchers to probe into practical demulsification methods for many decades. Inconsistent research outcomes observed in the literature for a particular demulsification method of a typical emulsion (i.e., water-in-oil or oil-in-water) arise not only from the varied influential parameters associated (such as salinity, temperature, pH, dispersed phase content, emulsifier/demulsifier concentration, and droplet size) but also from the diverse types of emulsion constituents (namely oil, surfactant, salt, alkali, polymer, fine solids, and/or other chemicals/impurities). Being the main component in formation of stabilizing interfacial film surrounding the dispersed phase droplets, surfactant is the most predominant contributor to emulsion stability, extent of which depends on its nature (being ionic or nonionic, and its degree of hydrophilicity/lipophilicity), concentration, and interaction with other surface-active agents in the emulsion as well as on the salinity, temperature, and pH of the system. In this paper, it is endeavored to overview some of the most commonly exploited demulsification techniques (i.e., chemical, biological, membrane, electrical, and microwave irradiation) of both oilfield and synthetic emulsions, taking into account the emulsion-stabilizing and -destabilizing effects with regard to the dominant parameters plus the emulsion composition. Further, the variations occurring in interfacial properties of emulsions by demulsification process are discussed. Finally, the mechanism(s) involved in emulsions resolution achieved by each method is elucidated. Clearly, the most efficient demulsification approach is the one able to attain desirable separation efficiency while complying with the environmental regulations and imposing the least economic burden on the petroleum industry.

[1]  K. B. Gross,et al.  Bio-inspired onboard membrane separation of water from engine oil , 2011 .

[2]  Alireza Badiei,et al.  Tweens demulsification effects on heavy crude oil/water emulsion , 2016 .

[3]  Lixin Xia,et al.  Stability and demulsification of emulsions stabilized by asphaltenes or resins. , 2004, Journal of colloid and interface science.

[4]  Xiangfeng Huang,et al.  Relationship between surface physicochemical properties and its demulsifying ability of an alkaliphilic strain of Alcaligenes sp. S-XJ-1 , 2011 .

[5]  C. Fang,et al.  Microwave Heating and Separation of Water-in-Oil Emulsions , 1995 .

[6]  Seung-Man Yang,et al.  Microwave-assisted self-organization of colloidal particles in confining aqueous droplets. , 2006, Journal of the American Chemical Society.

[7]  J. Salager,et al.  Formulation Concepts for the Emulsion Maker , 2002 .

[8]  Alexandre F. Santos,et al.  Effect of Salinity, Temperature, Water Content, and pH on the Microwave Demulsification of Crude Oil Emulsions† , 2007 .

[9]  M. N. El-Din,et al.  Synthesis and evaluation of some new demulsifiers based on bisphenols for treating water-in-crude oil emulsions , 2011 .

[10]  Darsh T. Wasan,et al.  Effect of demulsifier partitioning on the destabilization of water-in-oil emulsions , 1996 .

[11]  Chon-lin Lee,et al.  Treatment of a Cutting Oil Emulsion by Microwave Irradiation , 2009 .

[12]  Dongsheng Wang,et al.  Central treatment of different emulsion wastewaters by an integrated process of physicochemically enhanced ultrafiltration and anaerobic-aerobic biofilm reactor. , 2014, Bioresource technology.

[13]  T. Ichikawa,et al.  Electrical demulsification of oil-in-water emulsion , 2007 .

[14]  M. Hlavacek.  Break-up of oil-in-water emulsions induced by permeation through a microfiltration membrane , 1995 .

[15]  S. Armes,et al.  Effects of pH and salt concentration on oil-in-water emulsions stabilized solely by nanocomposite microgel particles. , 2006, Langmuir : the ACS journal of surfaces and colloids.

[16]  Minghua Wang,et al.  Treatment of waste filature oil/water emulsion by combined demulsification and reverse osmosis , 2008 .

[17]  E. Lester,et al.  Investigation into the mechanisms by which microwave heating enhances separation of water-in-oil emulsions , 2014 .

[18]  Xiangfeng Huang,et al.  Separation and characterization of effective demulsifying substances from surface of Alcaligenes sp. S-XJ-1 and its application in water-in-kerosene emulsion. , 2013, Bioresource technology.

[19]  Chon-lin Lee,et al.  Treatment of oil/water emulsions using seawater-assisted microwave irradiation , 2010 .

[20]  Jingyi Yang,et al.  Effect of the carboxymethyl chitosan on removal of nickel and vanadium from crude oil in the presenc , 2011 .

[21]  Qi Zhou,et al.  Characterization and phylogenetic analysis of biodemulsifier-producing bacteria. , 2010, Bioresource technology.

[22]  P. M. Spiecker,et al.  Effects of petroleum resins on asphaltene aggregation and water-in-oil emulsion formation , 2003 .

[23]  Taolei Sun,et al.  Influence of demulsifiers of different structures on interfacial dilational properties of an oil-water interface containing surface-active fractions from crude oil. , 2002, Journal of colloid and interface science.

[24]  A. Al-sabagh,et al.  Investigation of the Demulsification Efficiency of Some Ethoxylated Polyalkylphenol Formaldehydes Based on Locally Obtained Materials to Resolve Water-in-Oil Emulsions , 2009 .

[25]  Darsh T. Wasan,et al.  A study of dynamic interfacial mechanisms for demulsification of water-in-oil emulsions , 1995 .

[26]  Li Chen,et al.  Modified Resin Coalescer for Oil-in-Water Emulsion Treatment: Effect of Operating Conditions on Oil Removal Performance , 2009 .

[27]  Xinru Xu,et al.  Study on the Compatibility of High-Paraffin Crude Oil with Electric Desalting Demulsifiers , 2003 .

[28]  Xianhua Feng,et al.  Influence of Structural Variations of Demulsifiers on their Performance , 2013 .

[29]  D. Wasan,et al.  A possible mechanism of stabilization of emulsions by solid particles , 1992 .

[30]  M. V. van Loosdrecht,et al.  Electrophoretic mobility and hydrophobicity as a measured to predict the initial steps of bacterial adhesion , 1987, Applied and environmental microbiology.

[31]  K. Yeung,et al.  Preparation and application of zeolite/ceramic microfiltration membranes for treatment of oil contaminated water , 2008 .

[32]  C. Fang,et al.  Oil recovery and waste reduction by microwave radiation , 1989 .

[33]  Brendan F. Graham,et al.  Emulsion Inhibiting Components in Crude Oils , 2008 .

[34]  P. Luckham,et al.  Dewatering of crude oil emulsions 3. Emulsion resolution by chemical means , 1994 .

[35]  A. Bera,et al.  Synergistic Effect of Surfactant and Salt Mixture on Interfacial Tension Reduction between Crude Oil and Water in Enhanced Oil Recovery , 2014 .

[36]  Mojtaba Ghadiri,et al.  Drop–drop coalescence in an electric field: the effects of applied electric field and electrode geometry , 2003 .

[37]  Yu Sun,et al.  Basic ionic liquids with imidazole anion: New reagents to remove naphthenic acids from crude oil with high total acid number , 2012 .

[38]  C. Hendricks,et al.  Quiescent distortion and resonant oscillations of a liquid drop in an electric field , 1970 .

[39]  Qi Zhou,et al.  Comparison between waste frying oil and paraffin as carbon source in the production of biodemulsifier by Dietzia sp. S-JS-1. , 2009, Bioresource technology.

[40]  Alexandre Goldszal,et al.  Demulsification of Crude Oil Emulsions: Correlation to Microemulsion Phase Behavior , 2000 .

[41]  Adel O. Sharif,et al.  Electrostatic enhancement of coalescence of water droplets in oil: a review of the current understanding , 2001 .

[42]  Wanli Kang,et al.  Influence of demulsifier on interfacial film between oil and water , 2006 .

[43]  Alexandre F. Santos,et al.  Demulsification of Water-in-Crude Oil Emulsions Using Ionic Liquids and Microwave Irradiation , 2010 .

[44]  T. Basak,et al.  Efficient microwave processing of oil–water emulsion cylinders with lateral and radial irradiations , 2009 .

[45]  W. C. Griffin.  Classification of surface-active agents by "HLB" , 1946 .

[46]  A. Hezave,et al.  Investigating the effect of ionic liquid (1-dodecyl-3-methylimidazolium chloride ([C12mim] [Cl])) on the water/oil interfacial tension as a novel surfactant , 2013 .

[47]  J. Teixeira,et al.  Interactions between bacterial surfaces and milk proteins, impact on food emulsions stability , 2008 .

[48]  P. A. Winsor,et al.  Solvent properties of amphiphilic compounds , 1954 .

[49]  Qi Zhou,et al.  Optimization of biodemulsifier production from Alcaligenes sp. S-XJ-1 and its application in breaking crude oil emulsion. , 2010, Journal of hazardous materials.

[50]  T. Dąbroś,et al.  Effect of Demulsifier Properties on Destabilization of Water-in-Oil Emulsion , 2003 .

[51]  Owen P. Ward,et al.  De-emulsification of petroleum oil emulsion by a mixed bacterial culture , 2002 .

[52]  J. Zasadzinski,et al.  Phase behavior and structures of mixtures of anionic and cationic surfactants , 1992 .

[53]  Qi Zhou,et al.  Application of waste frying oils in the biosynthesis of biodemulsifier by a demulsifying strain Alcaligenes sp. S-XJ-1. , 2011, Journal of environmental sciences.

[54]  M. Hashim,et al.  Emulsion stabilization using ionic liquid [BMIM]+[NTf2]- and performance evaluation on the extraction of chromium. , 2011, Journal of hazardous materials.

[55]  Peter K. Kilpatrick,et al.  The Effects of Inorganic Solid Particles on Water and Crude Oil Emulsion Stability , 2002 .

[56]  A. Graciaa,et al.  Partitioning of ethoxylated octylphenol surfactants in microemulsion-oil-water systems: influence of temperature and relation between partitioning coefficient and physicochemical formulation , 2000 .

[57]  J. P. Wagner,et al.  Power consumption measurements for ac and pulsed dc for electrostatic coalescence of water-in-oil emulsions , 2001 .

[58]  C. Fortulan,et al.  Manufacture of ceramic membranes for application in demulsification process for cross-flow microfiltration , 2009 .

[59]  Bozhong Mu,et al.  Isolation and characterization of a biosurfactant producing strain, Brevibacilis brevis HOB1 , 2008, Journal of Industrial Microbiology & Biotechnology.

[60]  C. E. Perles,et al.  Study of the Cation and Salinity Effect on Electrocoalescence of Water/Crude Oil Emulsions , 2012 .

[61]  A. Mounteer,et al.  Isolation and characterization of biosurfactant/bioemulsifier-producing bacteria from petroleum contaminated sites. , 2006, Bioresource technology.

[62]  N. E. Maysour,et al.  SUGAR-BASED ETHOXYLATED AMINE SURFACTANTS AS DEMULSIFIERS FOR CRUDE OIL EMULSIONS: 2- DEMULSIFICATION OF DIFFERENT TYPES OF CRUDES , 2010 .

[63]  N. Ahmed,et al.  Stability and rheology of heavy crude oil-in-water emulsion stabilized by an anionic- nonionic surfactant mixture , 1999 .

[64]  E. Cockbain,et al.  The stability of elementary emulsion drops and emulsions , 1953 .

[65]  J. Salager,et al.  SORFACTANT-OIL-WATER SYSTEMS NEAR THE AFFINITY INVERSION Part III: THE TWO KINDS OF EMULSION INVERSION , 1983 .

[66]  K. Shinoda,et al.  The solubilization of hydrocarbons in aqueous solutions of nonionic surfactants , 1967 .

[67]  Soo-Bok Lee,et al.  Concentration polarization, membrane fouling and cleaning in ultrafiltration of soluble oil , 1984 .

[68]  Gang Yu,et al.  Effects of alkaline/surfactant/polymer on stability of oil droplets in produced water from ASP flooding , 2002 .

[69]  Effective biodemulsifier components secreted by Bacillus mojavensis XH-1 and analysis of the demulsification process , 2014, Biodegradation.

[70]  R. Martínez-Palou,et al.  Ionic Liquids as Demulsifiers of Water-in-Crude Oil Emulsions: Study of the Microwave Effect , 2010 .

[71]  Mohammad Hassan Shahavi,et al.  Electrostatic Enhancement of Coalescence of Oil Droplets(in Nanometer Scale) in Water Emulsion , 2012 .

[72]  L. Chu,et al.  Fouling-resistant Composite Membranes for Separation of Oil-in-water Microemulsions , 2006 .

[73]  D. Cooper,et al.  Surface-Active Lipids from Nocardia erythropolis Grown on Hydrocarbons , 1981, Applied and environmental microbiology.

[74]  J. Sjöblom,et al.  Enhanced Sedimentation and Coalescence by Chemicals on Real Crude Oil Systems , 2011 .

[75]  Isabelle Pezron,et al.  Destabilisation of Water-in-Crude Oil Emulsions by Silicone Copolymer Demulsifiers , 2008 .

[76]  A. H. Nour,et al.  Demulsification of Water-in-Oil Emulsions by Microwave Heating Technology , 2010 .

[77]  H. Davis.  Factors determining emulsion type: Hydrophile—lipophile balance and beyond , 1994 .

[78]  Qi Zhou,et al.  Analysis of biological demulsification process of water-in-oil emulsion by Alcaligenes sp. S-XJ-1. , 2010, Bioresource technology.

[79]  M. Abdel-raouf,et al.  Propylene oxide-ethylene oxide block copolymers as demulsifiers for water-in-oil emulsions, II. Effects of temperature, salinity,pH-value, and solvents on the demulsification efficiency , 1996 .

[80]  L. Lundgaard,et al.  Dehydration efficiency of AC electrical fields on water-in-model-oil emulsions , 2009 .

[81]  Dezhi Sun,et al.  Demulsification of water-in-oil emulsion by using porous glass membrane , 1998 .

[82]  D. Sabatini,et al.  Microemulsion phase behavior of anionic-cationic surfactant mixtures: Effect of tail branching , 2006 .

[83]  Jean-Louis Salager,et al.  A correlation for phase behavior of nonionic surfactants , 1980 .

[84]  Cuiqin Li,et al.  Synthesis of dendritic polyether surfactants for demulsification , 2010 .

[85]  H. Bach,et al.  Chapter 9 Potential applications of bioemulsifiers in the oil industry , 2004 .

[86]  M. Das.  Characterization of de-emulsification capabilities of a Micrococcus species. , 2001, Bioresource technology.

[87]  D. Nguyen,et al.  Chemical Interactions and Demulsifier Characteristics for Enhanced Oil Recovery Applications , 2012 .

[88]  Jingyi Yang,et al.  Effect of the cationic starch on removal of Ni and V from crude oils under microwave irradiation , 2011 .

[89]  A. Ghoshal,et al.  Cross-flow ultrafiltration of stable oil-in-water emulsion using polysulfone membranes. , 2010 .

[90]  Alexandre F. Santos,et al.  Microwave demulsification of heavy crude oil emulsions: Analysis of acid species recovered in the aqueous phase , 2014 .

[91]  Spencer E. Taylor.  Investigations into the electrical and coalescence behaviour of water-in-crude oil emulsions in high voltage gradients , 1988 .

[92]  S. Huzurbazar,et al.  Effect of Salinity on Water-in-Crude Oil Emulsion: Evaluation through Drop-Size Distribution Proxy , 2011 .

[93]  Mojtaba Ghadiri,et al.  Electrostatic enhancement of coalescence of water droplets in oil: a review of the technology , 2002 .

[94]  T. Basak,et al.  Efficient processing of oil-water emulsions confined within 2D cylinders with various microwave irradiations: Role of metallic annulus , 2010 .

[95]  Meiqin Lin,et al.  The influence of NaOH on the stability of paraffinic crude oil emulsion , 2005 .

[96]  N. Abdurahman,et al.  Pipeline transportation of viscous crudes as concentrated oil-in-water emulsions , 2012 .

[97]  T. J. Jones,et al.  Water-In-Crude Oil Emulsion Stability And Emulsion Destabilization By Chemical Demulsifiers , 1978 .

[98]  G. Mohebali,et al.  Efficient breaking of water/oil emulsions by a newly isolated de-emulsifying bacterium, Ochrobactrum anthropi strain RIPI5-1. , 2012, Colloids and surfaces. B, Biointerfaces.

[99]  Ki‐Young Lee,et al.  Emulsification using environmental compatible emulsifiers and de-emulsification using D.C. field and immobilized Nocardia amarae , 2000, Biotechnology Letters.

[100]  A. Fakhru’l-Razi,et al.  Review of technologies for oil and gas produced water treatment. , 2009, Journal of hazardous materials.

[101]  D. Thompson,et al.  Emulsification and demulsification related to crude oil production , 1985 .

[102]  J. Rämö,et al.  Performance of a commercial industrial-scale UF-based process for treatment of oily wastewaters. , 2013, Journal of environmental management.

[103]  J. Salager.  The fundamental basis for the action of a chemical dehydrant. Influence of the physical and chemical formulation on the stability of an emulsion , 1990 .

[104]  T. Ogawa,et al.  The solubilization of water in nonaqueous solutions of nonionic surfactants , 1967 .

[105]  Clarence A. Miller,et al.  Chemically Induced Destabilization of Water-in-Crude Oil Emulsions , 2005 .

[106]  Qiang Liu,et al.  Enhanced heavy oil recovery through interfacial instability: A study of chemical flooding for Brintnell heavy oil , 2009 .

[107]  C. Flores,et al.  Anion and cation effects of ionic liquids and ammonium salts evaluated as dehydrating agents for super-heavy crude oil: Experimental and theoretical points of view , 2014 .

[108]  Qi Zhou,et al.  Evaluation of screening methods for demulsifying bacteria and characterization of lipopeptide bio-demulsifier produced by Alcaligenes sp. , 2009, Bioresource technology.

[109]  Tadeusz Dabros,et al.  Effect of EO and PO positions in nonionic surfactants on surfactant properties and demulsification performance , 2005 .

[110]  M. Rondón,et al.  Breaking of Water-in-Crude-Oil Emulsions. 3. Influence of Salinity and Water−Oil Ratio on Demulsifier Action , 2009 .

[111]  Björn Sivik,et al.  Concentration polarization and fouling , 1980 .

[112]  A. Tremblay,et al.  Flux dependent oil permeation in the ultrafiltration of highly concentrated and unstable oil-in-wate , 2011 .

[113]  J. Salager,et al.  Breaking of Water-in-Crude Oil Emulsions. 5. Effect of Acid-Alkaline Additives on the Performance of Chemical Demulsifiers , 2014 .

[114]  Ibrahim M. Banat,et al.  Biosurfactants production and possible uses in microbial enhanced oil recovery and oil pollution remediation: a review , 1995 .

[115]  C. Ghotbi,et al.  Effective factors in the treatment of kerosene-water emulsion by using UF membranes. , 2009, Journal of hazardous materials.

[116]  Samuel C. Marsh,et al.  Inorganic Solid Content Governs Water-in-Crude Oil Emulsion Stability Predictions† , 2009 .

[117]  S. Lang,et al.  Structure and Properties of Biosurfactants , 2017 .

[118]  D. Cooper,et al.  Characterization of Nocardia amarae as a Potent Biological Coalescing Agent of Water-Oil Emulsions , 1982, Applied and environmental microbiology.

[119]  T. Wärnheim,et al.  Surface rheology of PEO-PPO-PEO triblock copolymers at the air-water interface: comparison of spread and adsorbed layers. , 2005, Langmuir.

[120]  P. Luckham,et al.  The effect of demulsifiers on the interfacial rheology and emulsion stability of water-in-crude oil emulsions , 1994 .

[121]  S. Bratskaya,et al.  Enhanced flocculation of oil-in-water emulsions by hydrophobically modified chitosan derivatives , 2006 .

[122]  J. Masliyah,et al.  Demulsification of solids-stabilized oil-in-water emulsions , 1996 .

[123]  C. Syldatk,et al.  Production of Biosurfactants , 2017 .

[124]  S. Ingebrigtsen,et al.  Investigation of the role of viscosity on electrocoalescence of water droplets in oil , 2006 .

[125]  J. Aburto,et al.  Demulsification of heavy crude oil-in-water emulsions: A comparative study between microwave and thermal heating , 2013 .

[126]  A. Bresciani,et al.  Modeling of Kinetics of Water Droplets Coalescence in Crude Oil Emulsion Subjected to an Electrical Field. , 2009 .

[127]  Xuan Hu,et al.  Oil recovery from refinery oily sludge via ultrasound and freeze/thaw. , 2012, Journal of hazardous materials.

[128]  E. Lucas,et al.  Aging of water-in-crude oil emulsions: Effect on water content, droplet size distribution, dynamic viscosity and stability , 2012 .

[129]  N. Kosaric,et al.  Bacteria-induced de-emulsification of water-in-oil petroleum emulsions , 1983, Biotechnology Letters.

[130]  T. A. Hatton,et al.  Surface Activity of Poly(ethylene oxide)-block-Poly(propylene oxide)-block-Poly(ethylene oxide) Copolymers , 1994 .

[131]  Xiuyu Wang,et al.  Probing Interfacial Water-in-Crude Oil Emulsion Stability Controls Using Electrorheology , 2010 .

[132]  Clarence A. Miller,et al.  Interfacial Phenomena: Equilibrium and Dynamic Effects , 1985 .

[133]  H. Lee,et al.  Demulsification of oil-in-water emulsions by aerial spores of a Streptomyces sp. , 2000, Biotechnology Letters.

[134]  A. Singh,et al.  Evaluation of a mixed bacterial culture for de-emulsification of water-in-petroleum oil emulsions , 2002 .

[135]  Wim Soetaert,et al.  Microbial production and application of sophorolipids , 2007, Applied Microbiology and Biotechnology.

[136]  N. Kosaric.  Biosurfactants in industry , 1992 .

[137]  Yonghong Liu,et al.  Application of variable frequency technique on electrical dehydration of water-in-oil emulsion , 2011 .

[138]  Guangming Zeng,et al.  Recent development in the treatment of oily sludge from petroleum industry: a review. , 2013, Journal of hazardous materials.

[139]  Xiangfeng Huang,et al.  Carbon source dependence of cell surface composition and demulsifying capability of Alcaligenes sp. S-XJ-1. , 2014, Environmental science & technology.

[140]  R. J. Hunter.  Foundations of Colloid Science , 1987 .

[141]  R. Antón,et al.  A CORRELATION FOR THREE-PHASE BEHAVIOR OF CATION1C SURFACTANT-OIL-WATER SYSTEMS , 1997 .

[142]  Yihe Zhang,et al.  Evaluation of calcium chloride for synergistic demulsification of super heavy oil wastewater , 2013 .

[143]  Y. Kawashima,et al.  Shear-induced phase inversion and size control of water/oil/water emulsion droplets with porous membrane , 1991 .

[144]  T. Dąbroś,et al.  Optimizing the Polyethylene Oxide and Polypropylene Oxide Contents in Diethylenetriamine-Based Surfactants for Destabilization of a Water-in-Oil Emulsion , 2005 .

[145]  P. J. Goetz,et al.  Acoustic and electroacoustic spectroscopy for characterizing concentrated dispersions and emulsions. , 2001, Advances in colloid and interface science.

[146]  Guoliang Zhang,et al.  Application of rhamnolipid as a novel biodemulsifier for destabilizing waste crude oil. , 2013, Bioresource technology.

[147]  V. L. Santos,et al.  Demulsifying properties of extracellular products and cells of Pseudomonas aeruginosa MSJ isolated from petroleum-contaminated soil. , 2013, Bioresource technology.

[148]  A. Fane,et al.  The effects of intermittent permeate flow and crossflow on membrane coalescence of oil-in-water emulsions☆ , 2002 .

[149]  Li Xia,et al.  SALT-ASSISTED MICROWAVE DEMULSIFICATION , 2004 .

[150]  Peter K. Kilpatrick,et al.  Effects of Asphaltene Solvency on Stability of Water-in-Crude-Oil Emulsions , 1997 .

[151]  H. Purohit,et al.  De-emulsification of oil-in-water emulsions by Bacillus subtilis , 1994, World journal of microbiology & biotechnology.

[152]  O. Mouraille,et al.  STABILITY OF WATER-IN-CRUDE OIL EMULSIONS: ROLE PLAYED BY THE STATE OF SOLVATION OF ASPHALTENES AND BY WAXES , 1998 .

[153]  Xiangfeng Huang,et al.  Relationship of cell-wall bound fatty acids and the demulsification efficiency of demulsifying bacteria Alcaligenes sp. S-XJ-1 cultured with vegetable oils. , 2012, Bioresource technology.

[154]  M. Wiesner,et al.  Microfiltration of oil-in-water emulsions , 1996 .

[155]  A. Fane,et al.  A fundamental study of the ultrafiltration of oil-water emulsions☆ , 1988 .

[156]  J. Pinto,et al.  Evaluation of Water-in-Crude-Oil Emulsion Stability Using Critical Electric Field: Effect of Emulsion Preparation Procedure and Crude Oil Properties , 2011 .

[157]  Nandakishore Rajagopalan,et al.  Membrane processing of oily streams. Wastewater treatment and waste reduction , 1998 .

[158]  I. N. Evdokimov,et al.  Microwave treatment of crude oil emulsions: Effects of water content , 2014 .

[159]  M. Rahimpour,et al.  Investigation of Paenibacillus alvei ARN63 ability for biodemulsifier production: medium optimization to break heavy crude oil emulsion. , 2013, Colloids and surfaces. B, Biointerfaces.

[160]  Jingxiu Zhong,et al.  Treatment of oily wastewater produced from refinery processes using flocculation and ceramic membrane filtration , 2003 .

[161]  M. Ghadiri,et al.  The effect of interfacial tension on secondary drop formation in electro-coalescence of water droplets in oil , 2011 .

[162]  W. C. Griffin.  Calculation of HLB values of non-ionic surfactants , 1954 .

[163]  Stanley Hartland,et al.  Dynamics of emulsification and demulsification of water in crude oil emulsions , 1994 .

[164]  Benjamin Chu,et al.  Light-scattering study on the association behavior of triblock polymers of ethylene oxide and propylene oxide in aqueous solution , 1988 .

[165]  J. Strassner,et al.  Effect of pH on Interfacial Films and Stability of Crude Oil-Water Emulsions , 1968 .

[166]  D. Cooper,et al.  Testing of microbial demulsifiers with heavy crude emulsions , 1985, Biotechnology Letters.

[167]  R. Martínez-Palou,et al.  Perspectives of Ionic Liquids Applications for Clean Oilfield Technologies , 2011 .

[168]  Jing Zhang,et al.  [Effect of Membrane Wettability on Membrane Fouling and Chemical Durability of SPG Membranes]. , 2014, Huan jing ke xue= Huanjing kexue.

[169]  P. Luckham,et al.  DEWATERING OF CRUDE-OIL EMULSIONS .4. EMULSION RESOLUTION BY THE APPLICATION OF AN ELECTRIC-FIELD , 1994 .

[170]  K. Musabekov,et al.  Nonionic surfactants based on polyoxyalkylated copolymers used as demulsifying agents , 2015 .

[171]  S. Deng,et al.  Characterization and demulsification of produced liquid from weak base ASP flooding , 2006 .

[172]  D. Skala,et al.  Separation of water-in-oil emulsions by freeze/thaw method and microwave radiation , 2006 .

[173]  P. Sherman,et al.  Factors affecting emulsion stability, and the HLB concept , 1972 .

[174]  M. Malmsten,et al.  Temperature-dependent micellization in aqueous block copolymer solutions , 1992 .

[175]  M. Goto,et al.  Demulsification of water-in-oil emulsions by permeation through Shirasu-porous-glass (SPG) membranes , 2008 .

[176]  Chao Yang,et al.  Preparation and application in oil–water separation of ZrO2/α-Al2O3 MF membrane , 1998 .

[177]  James J. Sheng,et al.  Modern Chemical Enhanced Oil Recovery: Theory and Practice , 2010 .

[178]  E. Lucas,et al.  Demulsification of Water-in-Crude Oil Emulsions by Microwave Radiation: Effect of Aging, Demulsifier Addition, and Selective Heating , 2013 .

[179]  M. Rahimpour,et al.  A Novel Modeling and Experimental Study of Crude Oil Desalting using Microwave , 2014 .

[180]  S. Cerneaux,et al.  Application of ceramic microfiltration membrane modified by nano-TiO2 coating in separation of a stable oil-in-water emulsion , 2014 .

[181]  J. Salager.  Emulsion Phase Inversion Phenomena , 2005 .

[182]  B. E. Chistyakov.  6. Theory and practical application aspects of surfactants , 2001 .

[183]  F. Tavares,et al.  Phase transition of water-in-oil emulsions over influence of an external electric field , 2008 .

[184]  Ajay Singh,et al.  Surfactants in microbiology and biotechnology: Part 2. Application aspects. , 2007, Biotechnology advances.

[185]  J. Salager,et al.  Breaking of Water-in-Crude Oil Emulsions. 1. Physicochemical Phenomenology of Demulsifier Action , 2006 .

[186]  J. Chen,et al.  Janus polymer/carbon nanotube hybrid membranes for oil/water separation. , 2014, ACS applied materials & interfaces.

[187]  Enrique Luis Lima,et al.  Quantitative Evaluation of the Efficiency of Water-in-Crude-Oil Emulsion Dehydration by Electrocoalescence in Pilot-Plant and Full-Scale Units , 2012 .

[188]  T. Ichikawa,et al.  Rapid demulsification of dense oil-in-water emulsion by low external electric field. I. Experimental evidence , 2004 .

[189]  Min Yang,et al.  The effects of oil displacement agents on the stability of water produced from ASP (alkaline/surfactant/polymer) flooding , 2011 .

[190]  Chih-Chieh Chan,et al.  DEMULSIFICATION OF W/O EMULSIONS BY MICROWAVE RADIATION , 2002 .

[191]  A. Al-sabagh,et al.  Functions of Demulsifiers in the Petroleum Industry , 2011 .

[192]  Toraj Mohammadi,et al.  Modeling of membrane fouling and flux decline in reverse osmosis during separation of oil in water emulsions , 2003 .

[193]  N. Ren,et al.  Characterization of the extracellular biodemulsifier of Bacillus mojavensis XH1 and the enhancement of demulsifying efficiency by optimization of the production medium composition , 2012 .

[194]  Xiaogang Yang,et al.  Demulsification of Asphaltenes and Resins Stabilized Emulsions via the Freeze/Thaw Method , 2009 .

[195]  and Alexey Kabalnov,et al.  Macroemulsion Stability: The Oriented Wedge Theory Revisited , 1996 .

[196]  John Hera,et al.  Separation of Produced Emulsions from Surfactant Enhanced Oil Recovery Processes , 2011 .

[197]  E. Lucas,et al.  Aging of water-in-crude oil emulsions: Effect on rheological parameters , 2012 .

[198]  J. Sjöblom,et al.  AC field induced destabilization of water-in-oil emulsions based on North Sea acidic crude oil , 2014 .

[199]  F. Feyzi,et al.  Influence of external electric field on the polarity of water droplets in water-in-oil emulsion phase transition , 2011 .

[200]  Wen Feng Lu,et al.  Demulsification of water-in-oil emulsions via filtration through a hydrophilic polymer membrane , 2003 .

[201]  M. J. Rosen.  Surfactants and Interfacial Phenomena , 1978 .

[202]  M. Rahimpour,et al.  Effect of a Different Formulation of Demulsifiers on the Efficiency of Chemical Demulsification of Heavy Crude Oil , 2011 .

[203]  F. Wang,et al.  Demulsification by amphiphilic dendrimer copolymers. , 2005, Journal of colloid and interface science.

[204]  J. Argillier,et al.  Impact of Chemical Enhanced Oil Recovery on the Separation of Diluted Heavy Oil Emulsions , 2012 .

[205]  Xiaogang Yang,et al.  Study on Demulsification of Crude Oil Emulsions by Microwave Chemical Method , 2007 .

[206]  G. Mackay,et al.  Electrolyte and pH effect on emulsion stability of water-in-petroleum oils , 1977 .

[207]  C. Noik,et al.  Triblock copolymers as destabilizers of water-in-crude oil emulsions , 2010 .

[208]  Jean-Louis Salager,et al.  Optimum Formulation of Surfactant/Water/Oil Systems for Minimum Interfacial Tension or Phase Behavior , 1979 .

[209]  N. Zaki.  Surfactant stabilized crude oil-in-water emulsions for pipeline transportation of viscous crude oils , 1997 .

[210]  Zhe Wang,et al.  Current development and application of chemical combination flooding technique , 2013 .

[211]  C. Noik,et al.  Elastic properties of crude oil/water interface in presence of polymeric emulsion breakers , 2005 .

[212]  W. Bancroft.  The Theory of Emulsification, III , 1911 .

[213]  J. Pellegrino,et al.  Determination of osmotic pressure and fouling resistance and their effects of performance of ultrafiltration membranes , 1992 .

[214]  N. Kosaric,et al.  Deemulsification of petroleum W/O emulsions by selected bacterial and yeast cells , 2005, Biotechnology Letters.

[215]  M. Kates.  Techniques of Lipidology: Isolation, Analysis, and Identification of Lipids , 2010 .

[216]  Zhiqing Zhang,et al.  Characterization and demulsification of poly(ethylene oxide)-block-poly(propylene oxide)-block-poly(ethylene oxide) copolymers. , 2004, Journal of Colloid and Interface Science.

[217]  E. Lester,et al.  Separation of Oil/Water Emulsions in Continuous Flow Using Microwave Heating , 2013 .

[218]  Yiming Cao,et al.  Development and characterization of anti-fouling cellulose hollow fiber UF membranes for oil-water separation , 2006 .

[219]  M. Pletnev.  1. Chemistry of surfactants , 2001 .

[220]  R. Pal.  Effect of droplet size on the rheology of emulsions , 1996 .

[221]  Darsh T. Wasan,et al.  Chemical demulsification of petroleum emulsions using oil-soluble demulsifiers , 1991 .

[222]  K. Shinoda,et al.  The Correlation between Phase Inversion Temperature In Emulsion and Cloud Point in Solution of Nonionic Emulsifier , 1964 .

[223]  P. Luckham,et al.  Dewatering of crude oil emulsions 2. Interfacial properties of the asphaltic constituents of crude oil , 1993 .

[224]  Jacqueline M.R. Bélanger,et al.  Microwave applications to oil sands and petroleum: A review , 2010 .

[225]  M. Elektorowicz,et al.  Effect of electrical potential on the electro-demulsification of oily sludge. , 2006, Journal of colloid and interface science.

[226]  I. Rahimian,et al.  Influence of the crude oil resin/asphaltene ratio on the stability of oil/water emulsions , 1999 .

[227]  S. O. Lumsdon,et al.  Influence of Particle Wettability on the Type and Stability of Surfactant-Free Emulsions† , 2000 .

[228]  T. A. Hatton,et al.  Micellization of poly(ethylene oxide)-poly(propylene oxide)-poly(ethylene oxide) triblock copolymers in aqueous solutions: Thermodynamics of copolymer association , 1994 .

[229]  Y. Yang,et al.  Influence of pH on the stability of oil-in-water emulsions stabilized by a splittable surfactant , 2000 .