Etched fiber bragg gratings sensors for water-ethanol mixtures: a comparative study

In this work is evaluated the performance of etched fiber Bragg gratings, assembled in different configurations to operate as a refractometric sensor, in the analysis of water-ethanol mixtures. Two fiber Bragg gratings operating close to 1300 nm and 1500 nm were wet-etched and employed in the sensor design. Four configurations for the refractometric sensor were studied, in dual-wavelength and single-wavelength operation modes, and at two sample temperatures. Calibration curves were determined for the range between 0.0 and 100.0 % v/v of water in ethanol, and the sensor performance for each configuration was analyzed by comparing its sensitivity, conformity, repeatability and combined uncertainty. The best results showed that the sensor can be used to measure the ethanol-water concentration with combined uncertainty of 2.8 % v/v for the range up to 80.0 % v/v of ethanol concentration and 7.0 % v/v of uncertainty for the range above 80.0 % v/v of ethanol concentration for the single-wavelength operation mode at two temperatures.

[1]  J. Mielenz,et al.  Ethanol production from biomass: technology and commercialization status. , 2001, Current opinion in microbiology.

[2]  F. Ouellette,et al.  Novel writing technique of long and highly reflective in-fibre gratings , 1994 .

[3]  H. Ahlfeldt,et al.  Fiber optical Bragg grating refractometer , 1998 .

[4]  Orlando Frazão,et al.  Fiber Bragg grating sensing system for simultaneous measurement of salinity and temperature , 2004 .

[5]  Ilda Abe,et al.  Determination of thermo-optic coefficient in liquids with fiber Bragg grating refractometer , 2008 .

[6]  Marcia Muller,et al.  Application of a long-period fibre grating-based transducer in the fuel industry , 2009 .

[7]  Toshiyuki Takamuku,et al.  Hydrogen-Bonded Cluster Formation and Hydrophobic Solute Association in Aqueous Solutions of Ethanol , 1995 .

[8]  Alan D. Kersey,et al.  Chemical sensor based on long-period fiber grating response to index of refraction , 1997, CLEO '97., Summaries of Papers Presented at the Conference on Lasers and Electro-Optics.

[9]  A. Othonos.  Fiber Bragg gratings , 1999 .

[10]  V. Bhatia.  Applications of long-period gratings to single and multi-parameter sensing. , 1999, Optics express.

[11]  M. Dagenais,et al.  High sensitivity evanescent field fiber Bragg grating sensor , 2005, IEEE Photonics Technology Letters.

[12]  Hypolito José Kalinowski,et al.  Fiber optic sensors for hydrocarbon detection , 2005 .

[13]  Giancarlo Cravotto,et al.  Ultrasonic detection of hydrophobic interactions: a quantitative approach , 2008 .

[14]  E. Lewis,et al.  Fibre-optic evanescent-wave field fluid concentration sensor , 2009, 2009 6th International Multi-Conference on Systems, Signals and Devices.