Enhancement of hydrogen production in a single chamber microbial electrolysis cell through anode arrangement optimization.

Reducing the inner resistances is crucial for the enhancement of hydrogen generation in microbial electrolysis cells (MECs). This study demonstrates that the optimization of the anode arrangement is an effective strategy to reduce the system resistances. By changing the normal MEC configuration into a stacking mode, namely separately placing the contacted anodes from one side to both sides of cathode in parallel, the solution, biofilm and polarization resistances of MECs were greatly reduced, which was also confirmed with electrochemical impedance spectroscopy analysis. After the anode arrangement optimization, the current and hydrogen production rate (HPR) of MEC could be enhanced by 72% and 118%, reaching 621.3±20.6 A/m3 and 5.56 m3/m3 d respectively, under 0.8 V applied voltage. A maximum current density of 1355 A/m3 with a HPR of 10.88 m3/m3 d can be achieved with 1.5 V applied voltage.

[1]  Hong Liu,et al.  Electrochemically assisted microbial production of hydrogen from acetate. , 2005, Environmental science & technology.

[2]  Hubertus V. M. Hamelers,et al.  Ion transport resistance in Microbial Electrolysis Cells with anion and cation exchange membranes , 2009 .

[3]  Hong Liu,et al.  Enhanced Coulombic efficiency and power density of air-cathode microbial fuel cells with an improved cell configuration , 2007 .

[4]  Hong Liu,et al.  Microbial electrolysis: novel technology for hydrogen production from biomass , 2010 .

[5]  Hyung-Sool Lee,et al.  Significance of biological hydrogen oxidation in a continuous single-chamber microbial electrolysis cell. , 2010, Environmental science & technology.

[6]  H. Hamelers,et al.  Performance of single chamber biocatalyzed electrolysis with different types of ion exchange membranes. , 2007, Water research.

[7]  Bruce E Logan,et al.  High hydrogen production rate of microbial electrolysis cell (MEC) with reduced electrode spacing. , 2011, Bioresource technology.

[8]  F. Aulenta,et al.  Characterization of an electro-active biocathode capable of dechlorinating trichloroethene and cis-dichloroethene to ethene. , 2010, Biosensors & bioelectronics.

[9]  Hong Liu,et al.  Hydrogen production using single-chamber membrane-free microbial electrolysis cells. , 2008, Water research.

[10]  Yongyou Hu,et al.  Electrochemical characteriztion of the bioanode during simultaneous azo dye decolorization and bioelectricity generation in an air-cathode single chambered microbial fuel cell , 2011 .

[11]  D. Lovley,et al.  Novel Mode of Microbial Energy Metabolism: Organic Carbon Oxidation Coupled to Dissimilatory Reduction of Iron or Manganese , 1988, Applied and environmental microbiology.

[12]  Boris Tartakovsky,et al.  High rate membrane-less microbial electrolysis cell for continuous hydrogen production , 2009, International Journal of Hydrogen Energy.

[13]  Bruce E. Logan,et al.  Electrolyte effects on hydrogen evolution and solution resistance in microbial electrolysis cells , 2009 .

[14]  Bruce E. Logan,et al.  The use of stainless steel and nickel alloys as low-cost cathodes in microbial electrolysis cells , 2009 .

[15]  Roland Cusick,et al.  Anode microbial communities produced by changing from microbial fuel cell to microbial electrolysis cell operation using two different wastewaters. , 2011, Bioresource technology.

[16]  Bruce E Logan,et al.  Sustainable and efficient biohydrogen production via electrohydrogenesis , 2007, Proceedings of the National Academy of Sciences.

[17]  Taiki Sugiyama,et al.  A High-Power Glucose/Oxygen Biofuel Cell Operating under Quiescent Conditions , 2009, ECS Transactions.

[18]  H. Hamelers,et al.  Principle and perspectives of hydrogen production through biocatalyzed electrolysis , 2006 .

[19]  Koji Sode,et al.  Development of a novel glucose enzyme fuel cell system employing protein engineered PQQ glucose dehydrogenase. , 2005, Biosensors & bioelectronics.

[20]  Hong Liu,et al.  Hydrogen production in single-chamber tubular microbial electrolysis cells using non-precious-metal catalysts , 2009 .

[21]  B. Logan,et al.  Performance of a pilot-scale continuous flow microbial electrolysis cell fed winery wastewater , 2011, Applied Microbiology and Biotechnology.

[22]  John A. Turner,et al.  Sustainable Hydrogen Production , 2004, Science.

[23]  Bruce E Logan,et al.  Hydrogen production in a single chamber microbial electrolysis cell lacking a membrane. , 2008, Environmental science & technology.

[24]  Bruce E Logan,et al.  High surface area stainless steel brushes as cathodes in microbial electrolysis cells. , 2009, Environmental science & technology.

[25]  S H A O A N C H E N G, † H U B E R T U,et al.  Microbial Electrolysis Cells for High Yield Hydrogen Gas Production from Organic Matter , 2008 .

[26]  R. Ramasamy,et al.  Impact of initial biofilm growth on the anode impedance of microbial fuel cells , 2008, Biotechnology and bioengineering.

[27]  Zhen He,et al.  Exploring the use of electrochemical impedance spectroscopy (EIS) in microbial fuel cell studies , 2009 .