A study on heat storage sizing and flow control for a domestic scale solar-powered organic Rankine cycle-vapour compression refrigeration system

Abstract This paper presents the off-design modelling of a domestic scale solar organic Rankine cycle (ORC) and vapour compression cycle (VCC) in a coupled operation in different operating modes by using evacuated flat plate (EFP) collectors. Thermodynamic and parametric studies of such coupled system in literature usually assume that the isentropic efficiencies of expander and compressor and the heat exchanger pinch temperature differences are constant. Moreover, studies for directly coupling the ORC-VCC system with solar collectors are somewhat rare. Transient performance of the solar ORC-VCC considering the off-design behaviour of the system components needs to be investigated. A simulation for a period of 24 hrs is conducted by considering the electricity and cooling demand of a 60 m2 office building during a typical day in July for Istanbul. The effect of heat storage capacity on meeting the demand is investigated for a given area of EFP collectors. Moreover, the water flow rate to the boiler is controlled periodically to provide the demanded electricity and cooling. The required EFP collector area and heat storage unit volume have been determined to be 80 m2 and 9.4 m3, respectively. For these design parameters, 25.6 kWh cooling and 18.76 kWh electricity can be generated during a typical day in July. Finally, a simulation is given for such design on a sunny winter day in February, 5.5 kWh electricity and 104 kWh heat can be produced.

[1]  E. Cihan,et al.  Energy and exergy analysis of a combined refrigeration and waste heat driven organic Rankine cycle system , 2017 .

[2]  A. Yilmaz,et al.  Transcritical organic Rankine vapor compression refrigeration system for intercity bus air-conditioning using engine exhaust heat , 2015 .

[3]  Licheng Sun,et al.  An evaluation of prediction methods for saturated flow boiling heat transfer in mini-channels , 2009 .

[4]  Tuncay Yilmaz,et al.  Energetic and exergetic investigation of a novel refrigeration system utilizing ejector integrated subcooling using different refrigerants , 2019, Energy.

[5]  Kiyoshi Saito,et al.  Solar-assisted single-double-effect absorption chiller for use in Asian tropical climates , 2016 .

[6]  Chris L. Ward,et al.  Performance of a combined organic Rankine cycle and vapor compression cycle for heat activated cooli , 2011 .

[7]  Soteris A. Kalogirou,et al.  A small-scale solar organic Rankine cycle combined heat and power system with integrated thermal energy storage , 2017 .

[8]  Canbing Li,et al.  Interaction between urban microclimate and electric air-conditioning energy consumption during high temperature season , 2014 .

[9]  Zhen Long,et al.  Hydrocarbon working fluids for a Rankine cycle powered vapor compression refrigeration system using low-grade thermal energy , 2013 .

[10]  Richard B. Peterson,et al.  Design study of configurations on system COP for a combined ORC (organic Rankine cycle) and VCC (vap , 2011 .

[11]  Drury B. Crawley,et al.  EnergyPlus: Energy simulation program , 2000 .

[12]  Vincent Lemort,et al.  Experimental characterization of a hermetic scroll expander for use in a micro-scale Rankine cycle , 2012 .

[13]  Andrea Lazzaretto,et al.  Design and off-design models of a hybrid geothermal-solar power plant enhanced by a thermal storage , 2017 .

[14]  Zhe Li,et al.  Domestic application of micro wind turbines in Ireland: Investigation of their economic viability , 2012 .

[15]  Antonio Giuffrida,et al.  Modelling the performance of a scroll expander for small organic Rankine cycles when changing the working fluid , 2014 .

[16]  Michalis Gr. Vrachopoulos,et al.  Energetic and exergetic investigation of a novel solar assisted mechanical compression refrigeration system , 2017 .

[17]  Vincent Lemort,et al.  Testing and modeling a scroll expander integrated into an Organic Rankine Cycle , 2009 .

[18]  V. Gnielinski.  New equations for heat and mass transfer in turbulent pipe and channel flow , 1976 .

[19]  Joaquín Navarro-Esbrí,et al.  Thermodynamic analysis of a combined organic Rankine cycle and vapor compression cycle system activated with low temperature heat sources using low GWP fluids , 2015 .

[20]  K. Gordon,et al.  Red electroluminescence from transparent PVK-dye films based on dipyrido[3,2-a:2′,3′-c]phenazine and Re(CO)3Cl-dipyrido[3,2-a:2′,3′-c]phenazine dyes , 2004 .

[21]  Horacio Perez-Blanco,et al.  Performance analysis of a combined organic Rankine cycle and vapor compression cycle for power and refrigeration cogeneration , 2015 .

[22]  B. Saleh,et al.  Parametric and working fluid analysis of a combined organic Rankine-vapor compression refrigeration system activated by low-grade thermal energy , 2016, Journal of advanced research.

[23]  Francesco Calise,et al.  Design and simulation of a prototype of a small-scale solar CHP system based on evacuated flat-plate solar collectors and Organic Rankine Cycle , 2015 .

[24]  Michel Feidt,et al.  Comparison of the working domains of some compression heat pumps and a compression-absorption heat pump , 1997 .

[25]  Li Jing,et al.  Design and analysis of a novel low-temperature solar thermal electric system with two-stage collectors and heat storage units , 2011 .

[26]  Fahad A. Al-Sulaiman,et al.  Performance assessment of a novel system using parabolic trough solar collectors for combined cooling, heating, and power production , 2012 .

[27]  Kyung Chun Kim,et al.  Working fluids selection and parametric optimization of an Organic Rankine Cycle coupled Vapor Compression Cycle (ORC-VCC) for air conditioning using low grade heat , 2016 .

[28]  B. S. Petukhov.  Heat Transfer and Friction in Turbulent Pipe Flow with Variable Physical Properties , 1970 .

[29]  Christos N. Markides,et al.  Working Fluid Selection and Electrical Performance Optimisation of a Domestic Solar-ORC Combined Heat and Power System for Year-Round Operation in the UK , 2017 .

[30]  Xiao-Ping Li,et al.  Performance analysis of a novel power/refrigerating combined-system driven by the low-grade waste heat using different refrigerants , 2014 .

[31]  Jinjia Wei,et al.  Analysis of a solar Rankine cycle powered refrigerator with zeotropic mixtures , 2018 .

[32]  S. Riffat,et al.  Off-design performance modelling of a solar organic Rankine cycle integrated with pressurized hot water storage unit for community level application , 2018, Energy Conversion and Management.

[33]  W. Beckman,et al.  Solar Engineering of Thermal Processes , 1985 .

[34]  C. Kutlu,et al.  Performance improvement potentials of low global warming potential refrigerants for intercity bus air conditioning system , 2017 .

[35]  K. A. Antonopoulos,et al.  Energetic, exergetic and financial evaluation of a solar driven absorption chiller – A dynamic approach , 2017 .