Biological hydrogen production in suspended and attached growth anaerobic reactor systems

Abstract Biological production of hydrogen gas has received increasing interest from the international community during the last decade. Most studies on biological fermentative hydrogen production from carbohydrates using mixed cultures have been conducted in conventional continuous stirred tank reactors (CSTR) under mesophilic conditions. Investigations on hydrogen production in reactor systems with attached microbial growth have recently come up as well as investigations on hydrogen production in the thermophilic temperature range. The present study examines and compares the biological fermentative production of hydrogen from glucose in a continuous stirred tank type bioreactor (CSTR) and an upflow anaerobic sludge blanket bioreactor (UASB) at various hydraulic retention times (2–12 h HRT) under mesophilic conditions (35 °C). Also the biohydrogen production from glucose in the CSTR at mesophilic and thermophilic (55 °C) temperature range was studied and compared. From the CSTR experiments it was found that thermophilic conditions combine high hydrogen production rate with low production of microbial mass, thus giving a specific hydrogen production rate as high as 104 mmole H 2 / h / l / g VSS at 6 h retention time compared to a specific hydrogen production rate of 12 mmole H 2 / h / l / g VSS under mesophilic conditions. On the other hand, the UASB reactor configuration is more stable than the CSTR regarding hydrogen production, pH, glucose consumption and microbial by-products (e.g. volatile fatty acids, alcohols etc.) at the HRTs tested. Moreover, the hydrogen production rate in the UASB reactor was significantly higher compared to that of the CSTR at low retention times (19.05 and 8.42 mmole H 2 / h / l , respectively at 2 h HRT) while hydrogen yield (mmole H 2 / mmole glucose consumed) was higher in the CSTR reactor at all HRT tested. This implies that there is a trade-off between technical efficiency (based on hydrogen yield) and economic efficiency (based on hydrogen production rate) when the attached (UASB) and suspended (CSTR) growth configurations are compared.

[1]  Debabrata Das,et al.  Continuous hydrogen production by immobilized Enterobacter cloacae IIT-BT 08 using lignocellulosic materials as solid matrices. , 2001 .

[2]  Richard Sparling,et al.  Hydrogen production from inhibited anaerobic composters , 1997 .

[3]  D. L. Hawkes,et al.  Enhancement of hydrogen production from glucose by nitrogen gas sparging. , 2000 .

[4]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[5]  Debabrata Das,et al.  Improvement of fermentative hydrogen production: various approaches , 2004, Applied Microbiology and Biotechnology.

[6]  Bruno Fabiano,et al.  Process development of continuous hydrogen production by Enterobacter aerogenes in a packed column reactor , 2000 .

[7]  Chiu-Yue Lin,et al.  Hydrogen production during the anaerobic acidogenic conversion of glucose , 1999 .

[8]  Tatsuya Noike,et al.  Characteristics of hydrogen production from bean curd manufacturing waste by anaerobic microflora , 2000 .

[9]  J. Benemann,et al.  Hydrogen biotechnology: Progress and prospects , 1996, Nature Biotechnology.

[10]  Samir Kumar Khanal,et al.  Biological hydrogen production: effects of pH and intermediate products , 2003 .

[11]  T. Noike,et al.  Hydrogen fermentation of organic municipal wastes , 2000 .

[12]  C-C. Chen,et al.  Kinetics of hydrogen production with continuous anaerobic cultures utilizing sucrose as the limiting substrate , 2001, Applied Microbiology and Biotechnology.

[13]  Hang-sik Shin,et al.  Comparative performance between temperaturephased and conventional mesophilic two-phased processes in terms of anaerobically produced bioenergy from food waste , 2005, Waste management & research : the journal of the International Solid Wastes and Public Cleansing Association, ISWA.

[14]  D. L. Hawkes,et al.  Sustainable fermentative hydrogen production: challenges for process optimisation , 2002 .

[15]  H. H. Fang,et al.  Hydrogen production from wastewater by acidogenic granular sludge. , 2003, Water science and technology : a journal of the International Association on Water Pollution Research.

[16]  James D. McMillan,et al.  Pretreatment of lignocellulosic biomass , 1994 .

[17]  Jo-Shu Chang,et al.  H2 production with anaerobic sludge using activated-carbon supported packed-bed bioreactors , 2004, Biotechnology Letters.

[18]  Jo-Shu Chang,et al.  Biohydrogen production with fixed-bed bioreactors , 2002 .

[19]  Han-Qing Yu,et al.  Hydrogen production from rice winery wastewater in an upflow anaerobic reactor by using mixed anaerobic cultures , 2002 .

[20]  T. Noike,et al.  Biological hydrogen potential of materials characteristic of the organic fraction of municipal solid wastes. , 2000, Water science and technology : a journal of the International Association on Water Pollution Research.

[21]  R. Ramachandran,et al.  An overview of industrial uses of hydrogen , 1998 .

[22]  J. Lay,et al.  Feasibility of biological hydrogen production from organic fraction of municipal solid waste , 1999 .

[23]  J. Lay,et al.  Biohydrogen production as a function of pH and substrate concentration. , 2001, Environmental science & technology.

[24]  T. Schäfer,et al.  Metabolism of hyperthermophiles , 1995, World journal of microbiology & biotechnology.

[25]  R. Nandi,et al.  Microbial production of hydrogen: an overview. , 1998, Critical reviews in microbiology.

[26]  R. Wolfe,et al.  FORMATION OF METHANE BY BACTERIAL EXTRACTS. , 1963, The Journal of biological chemistry.

[27]  Chiu-Yue Lin,et al.  Biohydrogen production using an up-flow anaerobic sludge blanket reactor , 2004 .

[28]  Tong Zhang,et al.  Characterization of a hydrogen-producing granular sludge. , 2002, Biotechnology and bioengineering.

[29]  Michael E. Himmel,et al.  Enzymatic conversion of biomass for fuels production. , 1994 .

[30]  Hariklia N Gavala,et al.  Anaerobic granular sludge and biofilm reactors. , 2003, Advances in biochemical engineering/biotechnology.

[31]  A. Stams,et al.  Substrate and product inhibition of hydrogen production by the extreme thermophile, Caldicellulosiruptor saccharolyticus. , 2003, Biotechnology and bioengineering.

[32]  Hang-Sik Shin,et al.  Hydrogen production from food waste in anaerobic mesophilic and thermophilic acidogenesis , 2004 .

[33]  C. Gregoire-Padró.  Hydrogen, the Once and Future Fuel , 1998 .

[34]  Jo-Shu Chang,et al.  Microbial Hydrogen Production with Immobilized Sewage Sludge , 2002, Biotechnology progress.

[35]  Hong Liu,et al.  Effect of pH on hydrogen production from glucose by a mixed culture. , 2002, Bioresource technology.