Isopropanol Dehydration on Amorphous Silica-Alumina: Synergy of Brønsted and Lewis Acidities at Pseudo-Bridging Silanols.

The mechanism of isopropanol dehydration on amorphous silica-alumina (ASA) was unraveled by a combination of experimental kinetic measurements and periodic density functional theory (DFT) calculations. We show that pseudo-bridging silanols (PBS-Al) are the most likely active sites owing to the synergy between the Brønsted and Lewis acidic properties of these sites, which facilitates the activation of alcohol hydroxy groups as leaving groups. Isopropanol dehydration was used to specifically investigate these PBS-Al sites, whose density was estimated to be about 10-1  site nm-2 on the silica-doped alumina surface under investigation, by combining information from experiments and theoretical calculations.

[1]  Stefan Grimme,et al.  Semiempirical GGA‐type density functional constructed with a long‐range dispersion correction , 2006, J. Comput. Chem..

[2]  Hafner,et al.  Ab initio molecular-dynamics simulation of the liquid-metal-amorphous-semiconductor transition in germanium. , 1994, Physical review. B, Condensed matter.

[3]  G. Henkelman,et al.  Improved tangent estimate in the nudged elastic band method for finding minimum energy paths and saddle points , 2000 .

[4]  T. Azaïs,et al.  Direct aerosol synthesis of large-pore amorphous mesostructured aluminosilicates with superior acid-catalytic properties. , 2009, Angewandte Chemie.

[5]  J. Stebbins,et al.  NMR evidence for excess non-bridging oxygen in an aluminosilicate glass , 1997, Nature.

[6]  Céline Chizallet,et al.  Influence of Coadsorbed Water and Alcohol Molecules on Isopropyl Alcohol Dehydration on γ-Alumina: Multiscale Modeling of Experimental Kinetic Profiles , 2016 .

[7]  J. Hafner,et al.  A periodic DFT study of intramolecular isomerization reactions of toluene and xylenes catalyzed by acidic mordenite. , 2001, Journal of the American Chemical Society.

[8]  J. Bokhoven,et al.  The variety of Brønsted acid sites in amorphous aluminosilicates and zeolites , 2014 .

[9]  E. Hensen,et al.  Acidity characterization of amorphous silica-alumina , 2012 .

[10]  G. Busca.  Acid catalysts in industrial hydrocarbon chemistry. , 2007, Chemical reviews.

[11]  Céline Chizallet,et al.  Mechanistic Investigation of Isopropanol Conversion on Alumina Catalysts: Location of Active Sites for Alkene/Ether Production , 2015 .

[12]  M. Che,et al.  Comparing Al-SBA-15 Support and Pt/Al-SBA-15 Catalyst: Changes in Al Speciation and Acidic Properties Induced by the Introduction of Pt via Aqueous Medium , 2009 .

[13]  Céline Chizallet,et al.  Pseudo-bridging silanols as versatile Brønsted acid sites of amorphous aluminosilicate surfaces. , 2009, Angewandte Chemie.

[14]  D. Vlachos,et al.  Computational Insights into the Role of Metal and Acid Sites in Bifunctional Metal/Zeolite Catalysts: A Case Study of Acetone Hydrogenation to 2-Propanol and Subsequent Dehydration to Propene , 2016 .

[15]  Guy Marin,et al.  Reaction path analysis for 1-butanol dehydration in H-ZSM-5 zeolite: Ab initio and microkinetic modeling , 2015 .

[16]  Avelino Corma,et al.  Inorganic Solid Acids and Their Use in Acid-Catalyzed Hydrocarbon Reactions , 1995 .

[17]  C. Amatore,et al.  Mechanistic and kinetic studies of palladium catalytic systems , 1999 .

[18]  T. Sodesawa,et al.  Catalytic and acidic properties of silica-alumina prepared by chemical vapour deposition , 1990 .

[19]  G. C. Bailey,et al.  Acidity Studies of Silica-Alumina Catalysts , 1959 .

[20]  D. Costa,et al.  Revisiting carbenium chemistry on amorphous silica-alumina: Unraveling their milder acidity as compared to zeolites , 2015 .

[21]  A. Vimont,et al.  Nature, structure and strength of the acidic sites of amorphous silica alumina: an IR and NMR study. , 2006, The journal of physical chemistry. B.

[22]  H. Lauron-Pernot.  Evaluation of Surface Acido‐Basic Properties of Inorganic‐Based Solids by Model Catalytic Alcohol Reaction Networks , 2006 .

[23]  Kresse,et al.  Efficient iterative schemes for ab initio total-energy calculations using a plane-wave basis set. , 1996, Physical review. B, Condensed matter.

[24]  Karsten Pedersen,et al.  Infrared and temperature-programmed desorption study of the acidic properties of ZSM-5-type zeolites , 1981 .

[25]  Yuguang Ma,et al.  Kinetics and mechanism of hydrogenation of furfural on Cu/SiO2 catalysts , 2011 .

[26]  G. Maciel,et al.  NMR studies of pyridine on silica-alumina , 1983 .

[27]  Burke,et al.  Generalized Gradient Approximation Made Simple. , 1996, Physical review letters.

[28]  G. Huber,et al.  Renewable alkanes by aqueous-phase reforming of biomass-derived oxygenates. , 2004, Angewandte Chemie.

[29]  J. Parera,et al.  Surface acidity, catalytic activity and selectivity of some oxides supported on alumina , 1988 .

[30]  Céline Chizallet,et al.  Atomic Description of the Interface between Silica and Alumina in Aluminosilicates through Dynamic Nuclear Polarization Surface-Enhanced NMR Spectroscopy and First-Principles Calculations , 2015, Journal of the American Chemical Society.

[31]  G. Kresse,et al.  From ultrasoft pseudopotentials to the projector augmented-wave method , 1999 .

[32]  G. Henkelman,et al.  A climbing image nudged elastic band method for finding saddle points and minimum energy paths , 2000 .

[33]  G. Busca,et al.  Diethyl ether cracking and ethanol dehydration: Acid catalysis and reaction paths , 2015 .

[34]  C. Chizallet,et al.  Acidity of amorphous silica-alumina: from coordination promotion of Lewis sites to proton transfer. , 2010, Chemphyschem : a European journal of chemical physics and physical chemistry.

[35]  G. Busca,et al.  Ethanol dehydration on silica-aluminas: Active sites and ethylene/diethyl ether selectivities , 2015 .

[36]  B. Delmon,et al.  Modified Aluminas : Relationship between activity in 1-butanol dehydration and acidity measured by NH3 TPD , 1989 .

[37]  J. Lercher,et al.  Acid-base properties of silica-alumina oxides derived from NaX zeolites: Part III. Catalytic activity in dehydration of alcohols and in isomerization of but-1-ene , 1985 .