Measurement of neutral gas temperature in inductively coupled Ar and Ar/O2 plasmas

In low-temperature inductively coupled radio frequency (rf) plasmas, electrons and ions that gain energy from the electric field can transfer a portion of energy to neutral particles. The resulting radial variation of the neutral gas temperature [Formula: see text] can significantly influence the radial distributions of reaction rates and radical densities on the substrate, thus affecting the etching/film deposition uniformity. In this work, we perform an experimental study on the dependence of the neutral gas temperature [Formula: see text] on external parameters (i.e., rf power, pressure, and gas component) in inductively coupled Ar and Ar/O2 plasmas by using a fiber Bragg grating sensor. To analyze the correlation between [Formula: see text] and the plasma characteristics, a Langmuir probe is used to measure the electron density [Formula: see text], effective electron temperature [Formula: see text], and ion density [Formula: see text] under the same discharge conditions. It is found that in both Ar and Ar/O2 plasmas, neutral gas heating is sensitive to plasma density. As the plasma density increases with the pressure/power, the collisions of ions and electrons with neutral particles are enhanced so that [Formula: see text] increases monotonically. With the increase of O2 content, [Formula: see text] and [Formula: see text] are observed to decrease due to enhanced dissociation and excitation of O2, leading to a decrease in [Formula: see text]. The radial profile of [Formula: see text] exhibits a parabolic distribution in pure Ar discharges, whereas it evolves through a center-flat shape into a saddle shape with the increase of O2 content. The variation of [Formula: see text] with rf power during the E-to-H mode transition is also presented and discussed.

[1]  J. Huang 黄,et al.  Numerical investigation of radio-frequency negative hydrogen ion sources by a three-dimensional fluid model , 2021, Chinese Physics B.

[2]  You-nian Wang,et al.  Measurement of electronegativity during the E to H mode transition in a radio frequency inductively coupled Ar/O2 plasma* , 2021, Chinese Physics B.

[3]  U. Czarnetzki,et al.  Foundations of capacitive and inductive radio-frequency discharges , 2020 .

[4]  V. M. Donnelly,et al.  Effects of O2 addition on in-plasma photo-assisted etching of Si with chlorine , 2020, Journal of Vacuum Science and Technology.

[5]  Sun Xiao-Yan,et al.  Effect of radio frequency bias on plasma characteristics of inductively coupled argon discharge based on fluid simulations , 2020 .

[6]  V. M. Donnelly,et al.  Evidence for anti-synergism between ion-assisted etching and in-plasma photoassisted etching of silicon in a high-density chlorine plasma , 2020 .

[7]  You-nian Wang,et al.  Complex transients of input power and electron density in pulsed inductively coupled discharges , 2019, Journal of Applied Physics.

[8]  You-nian Wang,et al.  Ion energy and angular distributions in planar Ar/O2 inductively coupled plasmas: hybrid simulation and experimental validation , 2019, Journal of Physics D: Applied Physics.

[9]  You-nian Wang,et al.  Fluid simulation of the plasma uniformity in pulsed dual frequency inductively coupled plasma , 2019, Physics of Plasmas.

[10]  Hong-young Chang,et al.  Study on SiN and SiCN film production using PE-ALD process with high-density multi-ICP source at low temperature , 2018, Current Applied Physics.

[11]  Ang Li,et al.  Observation of the standing wave effect in large-area, very-high-frequency capacitively coupled plasmas by using a fiber Bragg grating sensor , 2018, Journal of Applied Physics.

[12]  You-nian Wang,et al.  Phase shift effects of radio-frequency bias on ion energy distribution in continuous wave and pulse modulated inductively coupled plasmas , 2018 .

[13]  A. Fruchtman.  Neutral gas depletion in low temperature plasma , 2017 .

[14]  Fei Gao,et al.  Experimental and numerical investigations on time-resolved characteristics of pulsed inductively coupled O2/Ar plasmas , 2017 .

[15]  Wei Peng,et al.  Fiber Bragg grating-based temperature sensor for neutral gas in capacitively coupled plasmas , 2017, SPIE/COS Photonics Asia.

[16]  W. Peng,et al.  Determination of neutral temperature using fiber Bragg grating sensor in capacitively coupled argon plasmas , 2016 .

[17]  U. Czarnetzki,et al.  Influence of a phase-locked RF substrate bias on the E- to H-mode transition in an inductively coupled plasma , 2015 .

[18]  O. Chin,et al.  Measurement of neutral gas temperature in a 13.56 MHz inductively coupled plasma , 2015 .

[19]  Fei Gao,et al.  Characterization of O2/Ar inductively coupled plasma studied by using a Langmuir probe and global model , 2015 .

[20]  D. J. Economou.  Pulsed plasma etching for semiconductor manufacturing , 2014 .

[21]  X. Dai,et al.  A fast response temperature sensor based on fiber Bragg grating , 2014 .

[22]  V. Linss,et al.  Gas temperature determination from rotational lines in non-equilibrium plasmas: a review , 2014 .

[23]  Efrain Altamirano-Sanchez,et al.  Formation of a Nanoscale SiO2 Capping Layer on Photoresist Lines with an Ar/SiCl4/O2 Inductively Coupled Plasma: A Modeling Investigation , 2014 .

[24]  Vincent M. Donnelly,et al.  Plasma etching: Yesterday, today, and tomorrow , 2013 .

[25]  J. M. Lopez-Higuera,et al.  Fiber Bragg grating sensors for on-line welding diagnostics , 2013, Other Conferences.

[26]  S. Rauf,et al.  Gas heating mechanisms in capacitively coupled plasmas , 2012 .

[27]  R. Cariou,et al.  Low temperature plasma deposition of silicon thin films: From amorphous to crystalline , 2012 .

[28]  U. Czarnetzki,et al.  Coupling effects in inductive discharges with radio frequency substrate biasing , 2012 .

[29]  Se Stephen Potts,et al.  Plasma-Assisted Atomic Layer Deposition: Basics, Opportunities, and Challenges , 2011 .

[30]  D. Shamiryan,et al.  Simultaneous Etching and Deposition Processes during the Etching of Silicon with a Cl2/O2/Ar Inductively Coupled Plasma , 2011 .

[31]  M. Chaker,et al.  On the validity of neutral gas temperature by N2 rovibrational spectroscopy in low-pressure inductively coupled plasmas , 2011 .

[32]  You-nian Wang,et al.  Fluid simulations of frequency effects on nonlinear harmonics in inductively coupled plasma , 2011 .

[33]  G. Fubiani,et al.  Model of an inductively coupled negative ion source: I. General model description , 2011 .

[34]  Mark J. Kushner,et al.  Plasma atomic layer etching using conventional plasma equipment , 2009 .

[35]  A. Fruchtman.  Energizing and depletion of neutrals by a collisional plasma , 2008 .

[36]  U. Czarnetzki,et al.  Neutral gas depletion mechanisms in dense low-temperature argon plasmas , 2008 .

[37]  D. J. Economou.  Fast (tens to hundreds of eV) neutral beams for materials processing , 2008 .

[38]  R. Merlino.  Understanding Langmuir probe current-voltage characteristics , 2007 .

[39]  L. Liard,et al.  Plasma transport under neutral gas depletion conditions , 2007 .

[40]  Jon Tomas Gudmundsson,et al.  Oxygen discharges diluted with argon: dissociation processes , 2007 .

[41]  Hao Zhang,et al.  Temperature-independent FBG pressure sensor with high sensitivity , 2007 .

[42]  M. Shimada,et al.  Neutral gas density depletion due to neutral gas heating and pressure balance in an inductively coupled plasma , 2007 .

[43]  David B. Graves,et al.  Comparison of model and experiment for Ar, Ar/O2 and Ar/O2/Cl2 inductively coupled plasmas , 2006 .

[44]  Jae Koo Lee,et al.  Particle-in-cell Monte Carlo and fluid simulations of argon-oxygen plasma: Comparisons with experiments and validations , 2006 .

[45]  A. Lichtenberg,et al.  Principles of Plasma Discharges and Materials Processing: Lieberman/Plasma 2e , 2005 .

[46]  B. Cruden,et al.  Determination of gas temperature and thermometric species in inductively coupled plasmas by emission and diode laser absorption , 2004 .

[47]  H. Sawin,et al.  Neutral gas temperature measurements within transformer coupled toroidal argon plasmas , 2004 .

[48]  J. Booth,et al.  Gas temperature gradients in a CF4 inductive discharge , 2002 .

[49]  D. Graves,et al.  Neutral gas temperatures measured within a high-density, inductively coupled plasma abatement device , 2002 .

[50]  M. Meyyappan,et al.  Neutral gas temperature estimate in CF4/O2/Ar inductively coupled plasmas , 2002 .

[51]  H. Uhm,et al.  Control and analysis of ion species in N2 inductively coupled plasma with inert gas mixing , 2002 .

[52]  D. Hash,et al.  Impact of Gas Heating in Inductively Coupled Plasmas , 2001 .

[53]  Daniel Poitras,et al.  Plasma deposition of optical films and coatings: A review , 2000 .

[54]  M. V. Malyshev,et al.  Diagnostics of inductively coupled chlorine plasmas : Measurements of the neutral gas temperature , 2000 .

[55]  G. Hebner.  METASTABLE CHLORINE ION TEMPERATURE AND DRIFT VELOCITY IN AN INDUCTIVELY COUPLED PLASMA , 1996 .

[56]  G. Kroesen,et al.  Measurement of the gas temperature in fluorocarbon radio frequency discharges using infrared absorption spectroscopy , 1996 .