Characterization of HF-PECVD a-Si:H thin film solar cells by using OES studies

Abstract Hydrogenated amorphous silicon (a-Si:H) films show considerable potential for the fabrication of thin film solar cells. In this study, the a-Si:H thin films have been deposited in a parallel-plate radio frequency (RF) plasma reactor fed with pure SiH 4 . The plasma diagnostics were performed simultaneously during the a-Si:H solar cell deposition process using an optical emission spectrometer (OES) in order to study their correlations with growth rate and microstructure of the films. During the deposition, the emitting species (SiH*, Si*, H*) was analyzed. The effect of RF power on the emission intensities of excited SiH, Si and H on the film growth rate has been investigated. The OES analysis revealed a chemisorption-based deposition model of the growth mechanism. Finally, the a-Si:H thin film solar cell with an efficiency of 7.6% has been obtained.

[1]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[2]  Shuichi Miyazaki,et al.  Characterization of plasma-deposited microcrystalline silicon , 1982 .

[3]  Frank J. Kampas,et al.  An optical emission study of the glow-discharge deposition of hydrogenated amorphous silicon from argon-silane mixtures , 1983 .

[4]  L. Feitknecht,et al.  Microcrystalline n-i-p solar cells deposited at 10 Å/s by VHF-GD , 2001 .

[5]  L. Feitknecht,et al.  Plasma deposition of thin film silicon: kinetics monitored by optical emission spectroscopy , 2002 .

[6]  Xiaodang Zhang,et al.  Effect of substrate bias on the plasma enhanced chemical vapor deposition of microcrystalline silicon thin films , 2008 .

[7]  A. Matsuda.  Formation kinetics and control of microcrystallite in μc-Si:H from glow discharge plasma , 1983 .

[8]  Andrew G. Glen,et al.  APPL , 2001 .

[9]  Henry U. Lee,et al.  LIF and OES detection of radical species in SiF4 + H2 plasmas , 1984 .

[10]  P. Veis,et al.  Gas phase kinetic and optical emission spectroscopy studies in plasma-enhanced hot filament catalytic CVD production of carbon nanotubes , 2009 .

[11]  C. C. Lee,et al.  Sputter deposition of titanium monoxide and dioxide thin films with controlled properties using optical emission spectroscopy , 2008 .

[12]  Mark D. Semon,et al.  POSTUSE REVIEW: An Introduction to Error Analysis: The Study of Uncertainties in Physical Measurements , 1982 .

[13]  B. Rech,et al.  Plasma emission diagnostics for the transition from microcrystalline to amorphous silicon solar cells , 2005 .

[14]  Jhuma Gope,et al.  High-pressure condition of SiH4+Ar+H2 plasma for deposition of hydrogenated nanocrystalline silicon film , 2008 .

[15]  H. Shirai,et al.  Optical emission spectroscopy study toward high rate growth of microcrystalline silicon , 2001 .

[16]  E. R. Cohen.  An Introduction to Error Analysis: The Study of Uncertainties in Physical Measurements , 1998 .

[17]  S. Oda,et al.  Diagnostic Study of VHF Plasma and Deposition of Hydrogenated Amorphous Silicon Films , 1990 .

[18]  Yoshihiro Hamakawa,et al.  a‐SiC:H/a‐Si:H heterojunction solar cell having more than 7.1% conversion efficiency , 1981 .

[19]  B. Rech,et al.  Flexible amorphous and microcrystalline silicon tandem solar modules in the temporary superstrate concept , 2007 .