Low cost speed controller for small AC motors

The article introduces simple and low cost PWM speed controller for the fractional power AC motors (less than 500 W). Variable speed settings are normally required to match the load requirement, reduce acoustical noise, and energy savings in blenders, air blower etc. In the proposed circuit, one transistor and a diode bridge are configured to vary the AC supply across the motor. Switching the transistor ON and OFF at a fast rate results in variable AC voltage. By using the proposed circuit. the PWM modulated AC supply has high frequency harmonic of which the first harmonic is dependent on the operating switching frequency. This in turn makes filtering the harmonics a simple task. Comparison between the phase controls circuits normally adopted for speed control with the proposed controller was investigated using PSpice models.

[1]  D. A. Deib,et al.  Optimal harmonic reduction in AC/AC chopper converters , 1993, Proceedings of IEEE Power Electronics Specialist Conference - PESC '93.

[2]  Nabil A. Ahmed,et al.  AC chopper voltage controller-fed single-phase induction motor employing symmetrical PWM control technique , 2000 .

[3]  G. Joos,et al.  A practical PWM AC controller topology , 1992, Conference Record of the 1992 IEEE Industry Applications Society Annual Meeting.

[4]  Derek A. Paice.  Induction Motor Speed Control by Stator Voltage Control , 1968 .

[5]  Alan K. Wallace,et al.  An improved PWM technique for AC choppers , 1989 .

[6]  M.S.J. Asghar.  Smooth speed control of single-phase induction motors by integral-cycle switching , 1999 .

[7]  M.S.J. Asghar.  Fine power control by discontinuous phase-controlled switching , 1999 .

[8]  K. Sundareswaran.  An improved energy-saving scheme for capacitor-run induction motor , 2001, IEEE Trans. Ind. Electron..

[9]  Giri Venkataramanan,et al.  Comparative evaluation of PWM AC-AC converters , 1995, Proceedings of PESC '95 - Power Electronics Specialist Conference.

[10]  A. F. Bakan,et al.  Universal motor speed control with current controlled PWM AC chopper by using a microcontroller , 2000, Proceedings of IEEE International Conference on Industrial Technology 2000 (IEEE Cat. No.00TH8482).

[11]  E.R. Collins.  Torque and slip behavior of single-phase induction motors driven from variable frequency supplies , 1990, Conference Record of the 1990 IEEE Industry Applications Society Annual Meeting.