On the development of a multifunction millimeter-wave sensor for displacement sensing and low-velocity measurement

A new multifunction millimeter-wave sensor operating at 35.6 GHz has been developed and demonstrated for measurement of displacement and low velocity. The sensor was realized using microwave integrated circuits and monolithic microwave integrated circuits. Measured displacement results show unprecedented resolution of only 10 /spl mu/m, which is approximately equivalent to /spl lambda//sub 0//840 in terms of free-space wavelength /spl lambda//sub 0/, and maximum error of only 27 /spl mu/m. A polynomial curve-fitting method was also developed for correcting the error. Results indicate that multiple reflections dominate the displacement measurement error. The sensor was able to measure speed as low as 27.7 mm/s, corresponding to 6.6 Hz in Doppler frequency, with an estimated velocity resolution of 2.7 mm/s. A digital quadrature mixer (DQM) was configured as a phase-detecting processor, employing a quadrature sampling signal-processing technique, to overcome the nonlinear phase response problem of a conventional analog quadrature mixer. The DQM also enables low Doppler frequency to be measured with high resolution. The Doppler frequency was determined by applying linear regression on the phase sampled within only fractions of the period of the Doppler frequency. Short-term stability of the microwave signal source was also considered to predict its effect on measurement accuracy.

[1]  Riccardo Lanari,et al.  Synthetic Aperture Radar Processing , 1999 .

[2]  R.H. Rasshofer,et al.  Advanced millimeterwave speed sensing system based on low-cost active integrated antennas , 1999, 1999 IEEE MTT-S International Microwave Symposium Digest (Cat. No.99CH36282).

[3]  William L. Smith,et al.  Near-Continuous Profiling of Temperature, Moisture, and Atmospheric Stability Using the Atmospheric Emitted Radiance Interferometer (AERI) , 2003 .

[4]  W.M. Waters,et al.  Bandpass Signal Sampling and Coherent Detection , 1982, IEEE Transactions on Aerospace and Electronic Systems.

[5]  F. Žáček,et al.  Microwave measurements of complex permittivity by free space methods and their applications , 1986 .

[6]  D.W. Rice,et al.  Quadrature Sampling with High Dynamic Range , 1982, IEEE Transactions on Aerospace and Electronic Systems.

[7]  Fengchao Xiao,et al.  Application of six-port wave-correlator for very low velocity measurement using Doppler effect , 2002, Conference Digest Conference on Precision Electromagnetic Measurements.

[8]  J. Rutman.  Characterization of phase and frequency instabilities in precision frequency sources: Fifteen years of progress , 1978, Proceedings of the IEEE.

[9]  F.E. Churchill,et al.  The Correction of I and Q Errors in a Coherent Processor , 1981, IEEE Transactions on Aerospace and Electronic Systems.

[10]  V. Considine.  Digital complex sampling , 1983 .

[11]  Stephen A. Dyer,et al.  Digital signal processing , 2018, 8th International Multitopic Conference, 2004. Proceedings of INMIC 2004..

[12]  A. Yardim,et al.  Performance of an FIR filter-based spectral centroid tracker for Doppler determination , 1991, 1991., IEEE International Sympoisum on Circuits and Systems.

[13]  A. Benlarbi-Delai,et al.  Short-range two-dimension positioning by microwave cellular telemetry , 1994 .

[14]  A. A. M. Saleh,et al.  The Measurement of Noise in Microwave Transmitters , 1977 .

[15]  Cam Nguyen,et al.  A displacement measurement technique using millimeter-wave interferometry , 2003 .

[16]  M. Tobar,et al.  Microwave interferometry: application to precision measurements and noise reduction techniques , 1998, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[17]  C. Nguyen,et al.  Millimeter-wave Doppler velocimetry for low-velocity measurement , 2004, 2004 IEEE MTT-S International Microwave Symposium Digest (IEEE Cat. No.04CH37535).

[18]  Venceslav F. Kroupa,et al.  Phase Noise in Signal Sources , 1984 .

[19]  I. Gresham,et al.  A compact manufacturable 76-77-GHz radar module for commercial ACC applications , 2001 .

[20]  Peter E. Engler,et al.  A microwave interferometer as a non-contacting cardio-pulmonary monitor , 1988, Proceedings of the 1988 Fourteenth Annual Northeast Bioengineering Conference.

[21]  R.A. Monzingo,et al.  Evaluation of Image Response Signal Power Resulting from I-Q Channel Imbalance , 1987, IEEE Transactions on Aerospace and Electronic Systems.

[22]  Reza Zoughi,et al.  Microwave non-destructive testing and evaluation , 2000 .

[23]  Yves Leroy,et al.  Position, velocity profile measurement of a moving body by microwave interferometry , 1990 .

[24]  J.-F. Luy,et al.  Multifunctional radar sensor for automotive application , 1998 .

[25]  Harold P. Furth,et al.  Plasma diagnostics with microwaves , 1965 .

[26]  Steven A. Tretter,et al.  Estimating the frequency of a noisy sinusoid by linear regression , 1985, IEEE Trans. Inf. Theory.

[27]  A. Ghafoor,et al.  A new quadrature sampling and processing approach , 1989 .

[28]  A. Stelzer,et al.  A microwave position sensor with sub-millimeter accuracy , 1999, 1999 IEEE MTT-S International Microwave Symposium Digest (Cat. No.99CH36282).

[29]  I. D. Longstaff,et al.  Wideband quadrature error correction (using SVD) for stepped-frequency radar receivers , 1999 .

[30]  N. Weber,et al.  A novel signal processing approach for microwave Doppler speed sensing , 2002, 2002 IEEE MTT-S International Microwave Symposium Digest (Cat. No.02CH37278).