A Comparative Study of Carbon Gasification with O2 and CO2 by Density Functional Theory Calculations

A comparative study of carbon gasification with O-2 and CO2 was conducted by using density functional theory calculations. It was found that the activation energy and the number of active sites in carbon gasification reactions are significantly affected by both the capacity and manner of gas chemisorption. O-2 has a strong adsorption capacity and the dissociative chemisorption of O-2 is thermodynamically favorable on either bare carbon surface or even isolated edge sites. As a result, a large number of semiquinone and o-quinone oxygen can be formed indicating a significant increase in the number of active sites. Moreover, the weaker o-quinone C-C bonds can also drive the reaction forward at (ca. 30%) lower activation energy. Epoxy oxygen forms under relatively high O-2 pressure, and it can only increase the number of active sites, not further reduce the activation energy. CO2 has a lower adsorption capacity. Dissociative chemisorption of CO2 can only occur on two consecutive edge sites and o-quinone oxygen formed from CO2 chemisorption is negligible, let alone epoxy oxygen. Therefore, CO2-carbon reaction needs (ca 30%) higher activation energy. Furthermore, the effective active sites are also reduced by the manner Of CO2 chemisorption. A combination of the higher activation energy and the fewer active sites leads to the much lower reaction rate Of CO2-carbon.

[1]  A. Sarofim,et al.  Spin Contamination in Hartree−Fock and Density Functional Theory Wavefunctions in Modeling of Adsorption on Graphite , 2000 .

[2]  G. Lu,et al.  A new kinetic model for the NO–carbon reaction , 1999 .

[3]  R. T. Yang,et al.  Catalyzed Carbon–NO Reaction Studied by Scanning Tunneling Microscopy and ab Initio Molecular Orbital Calculations , 1999 .

[4]  T. Kyotani,et al.  Analysis of the Reaction of Carbon with NO/N2O Using Ab Initio Molecular Orbital Theory , 1999 .

[5]  R. T. Yang,et al.  Ab Initio Molecular Orbital Study of the Unified Mechanism and Pathways for Gas-Carbon Reactions† , 1998 .

[6]  R. T. Yang,et al.  Unified Mechanism of Alkali and Alkaline Earth Catalyzed Gasification Reactions of Carbon by CO2 and H2O , 1997 .

[7]  R. T. Yang,et al.  A new surface oxygen complex on carbon: Toward a unified mechanism for carbon gasification reactions , 1993 .

[8]  R. T. Yang,et al.  The active surface species in alkali-catalyzed carbon gasification : phenolate (C-O-M) groups vs clusters (particles) , 1993 .

[9]  R. T. Yang,et al.  Strongly bonded oxygen in graphite : detection by high-temperature TPD and characterization , 1992 .

[10]  R. T. Yang,et al.  Mechanism of alkali and alkaline earth catalyzed gasification of graphite by CO2 and H2O studied by electron microscopy , 1992 .

[11]  A. Lizzio,et al.  Effect of oxygen chemisorption on char gasification reactivity profiles obtained by thermogravimetric analysis , 1988 .

[12]  T. Kyotani,et al.  TPD study on coal chars chemisorbed with oxygen-containing gases , 1988 .

[13]  D. D. Perlmutter,et al.  Effect of chemisorbed oxygen on char reactivity , 1985 .

[14]  P. Walker,et al.  Importance of carbon active sites in the gasification of coal chars , 1983 .

[15]  R. T. Yang,et al.  The mode of attack of oxygen atoms on the basal plane of graphite , 1983 .

[16]  R. T. Yang,et al.  Kinetics and mechanism of oxidation of basal plane on graphite , 1981 .

[17]  P. Walker,et al.  THE IMPORTANCE OF ACTIVE SURFACE AREA IN THE CARBON-OXYGEN REACTION1,2 , 1963 .

[18]  H. Eyring,et al.  Kinetics of Graphite Oxidation , 1957 .

[19]  E. A. Gulbransen,et al.  Reactions of Artificial Graphite-Kinetics of Oxidation of Artificial Graphite at Temperatures of 425° to 575° C. and Pressures of 0.15 to 9.8 Cm. of Mercury of Oxygen , 1952 .

[20]  R. T. Yang,et al.  Ab initio molecular orbital calculation on graphite: Selection of molecular system and model chemistry , 1998 .

[21]  R. L. Taylor,et al.  An update on the carbon-oxygen reaction , 1991 .

[22]  G. N. Richards,et al.  Chemisorption of oxygen and of nitric oxide on cellulosic chars , 1991 .

[23]  Hong Jiang,et al.  A transient kinetics study of char gasification in carbon dioxide and oxygen , 1991 .

[24]  H.-U. Foersterling.  Investigations of the adsorption of palladium on carbonaceous adsorbents modified with dimethylglyoxime—I. The adsorption of dimethylglyoxime on selected carbonaceous adsorbents , 1990 .

[25]  J. K. Floess,et al.  Intrinsic reaction kinetics of microporous carbons. 1. Noncatalyzed chars , 1988 .

[26]  S. Kelemen,et al.  O2 oxidation studies of the edge surface of graphite , 1985 .