Which Photodiode to Use: A Comparison of CMOS-Compatible Structures

While great advances have been made in optimizing fabrication process technologies for solid state image sensors, the need remains to be able to fabricate high quality photosensors in standard CMOS processes. The quality metrics depend on both the pixel architecture and the photosensitive structure. This paper presents a comparison of three photodiode structures in terms of spectral sensitivity, noise and dark current. The three structures are n+/p-sub, n-well/p-sub and p+/n-well/p-sub. All structures were fabricated in a 0.5 mum 3-metal, 2-poly, n-well process and shared the same pixel and readout architectures. Two pixel structures were fabricated-the standard three transistor active pixel sensor, where the output depends on the photodiode capacitance, and one incorporating an in-pixel capacitive transimpedance amplifier where the output is dependent only on a designed feedback capacitor. The n-well /p-sub diode performed best in terms of sensitivity (an improvement of 3.5 times and 1.6 times over the n+/p-sub and p+/n-well/p-sub diodes, respectively) and signal-to-noise ratio (1. 5times and 1.2 times improvement over the n+/p-sub and p+/n-well/p-sub diodes, respectively) while the p+/n-well/p-sub diode had the minimum (33% compared to other two structures) dark current for a given sensitivity.

[1]  Xiaofeng Fan,et al.  Small pixel development for novel CMOS image sensors , 2008, SPIE Photonics Europe.

[2]  Gert Cauwenberghs,et al.  CMOS Camera With In-Pixel Temporal Change Detection and ADC , 2007, IEEE Journal of Solid-State Circuits.

[3]  R. Etienne-Cummings,et al.  A 128 x128 33mW 30frames/s single-chip stereo imager , 2006, 2006 IEEE International Solid State Circuits Conference - Digest of Technical Papers.

[4]  James T. Andrews,et al.  CMOS minimal array , 2006, SPIE Optics + Photonics.

[5]  Boyd Fowler,et al.  Reset noise reduction in capacitive sensors , 2006, IEEE Transactions on Circuits and Systems I: Regular Papers.

[6]  Joaquim Salvi,et al.  Review of CMOS image sensors , 2006, Microelectron. J..

[7]  A. Basu,et al.  Test results of various CMOS image sensor pixels , 2005, Canadian Conference on Electrical and Computer Engineering, 2005..

[8]  F. Odiot,et al.  Test structures for quantum efficiency characterization for silicon image sensors , 2003, International Conference on Microelectronic Test Structures, 2003..

[9]  F. Beyette,et al.  Implementation of CMOS photodetectors in optoelectronic circuits , 2002, The 15th Annual Meeting of the IEEE Lasers and Electro-Optics Society.

[10]  Xinqiao Liu,et al.  A 10000 frames/s CMOS digital pixel sensor , 2001, IEEE J. Solid State Circuits.

[11]  Abbas El Gamal,et al.  Active pixel sensors fabricated in a standard 0.18-μm CMOS technology , 2001, IS&T/SPIE Electronic Imaging.

[12]  Boyd Fowler,et al.  Low-FPN high-gain capacitive transimpedance amplifier for low-noise CMOS image sensors , 2001, IS&T/SPIE Electronic Imaging.

[13]  Lester J. Kozlowski,et al.  Theoretical basis and experimental confirmation: why a CMOS imager is superior to a CCD , 1999, Defense, Security, and Sensing.

[14]  Abbas El Gamal,et al.  Analysis of temporal noise in CMOS APS , 1999, Electronic Imaging.

[15]  R. Jacob Baker,et al.  CMOS Circuit Design, Layout, and Simulation , 1997 .

[16]  Eric R. Fossum,et al.  Active pixel sensors: are CCDs dinosaurs? , 1993, Electronic Imaging.

[17]  B. Dierickx,et al.  Pixel structure with logarithmic response for intelligent and flexible imager architectures , 1992, ESSDERC '92: 22nd European Solid State Device Research conference.

[18]  R. Ginosar,et al.  A random access photodiode array for intelligent image capture , 1991, 17th Convention of Electrical and Electronics Engineers in Israel.

[19]  N. Saks,et al.  A technique for suppressing dark current generated by interface states in buried channel CCD imagers , 1980, IEEE Electron Device Letters.

[20]  H. Grubin.  The physics of semiconductor devices , 1979, IEEE Journal of Quantum Electronics.

[21]  P. Noble,et al.  Self-scanned silicon image detector arrays , 1968 .

[22]  G. P. Weckler,et al.  Operation of p-n Junction Photodetectors in a Photon Flux Integrating Mode , 1967 .

[23]  T. Lee,et al.  An Active Pixel Sensor Fabricated Using CMOS / CCD Process Technology , 1995 .

[24]  J. P. Lavine,et al.  The pinned photodiode for an interline-transfer CCD image sensor , 1984, 1984 International Electron Devices Meeting.

[25]  B. Streetman.  Solid state electronic devices , 1972 .