The Effect of Higher Sludge Recycling Rate on Anaerobic Treatment of Palm Oil Mill Effluent in a Semi-Commercial Closed Digester for Renewable Energy

Problem statement: A 500 m3 semi-commercial closed anaerobic digester was constructed for Palm Oil Mill Effluent (POME) treatment and methane gas capture for renewable energy. During the start-up operation period, the Volatile Fatty Acids (VFA) accumulation could not be controlled and caused instability on the system. Approach: A settling tank was installed and sludge was recycled as to provide a balanced microorganisms population for the treatment of POME and methane gas production. The effect of sludge recycling rate was studied by applying Organic Loading Rates (OLR) (between 1.0 and 10.0 kgCOD m-3 day-1) at different sludge recycling rates (6, 12 and 18 m3 day-1). Results: At sludge recycling rate of 18 m3 day-1, the maximum OLR was 10.0 kgCOD m-3 day-1 with biogas and methane productivity of 1.5 and 0.9 m3 m-3 day-1, respectively. By increasing the sludge recycling rate the VFA concentration was controlled below its inhibitory limit (1000 mg L-1) and the COD removal efficiency recorded was above 95% which indicated good treatment performance for the digester. Two methanogens species (Methanosarcina sp. and Methanosaeta concilii) had been identified from sludge samples obtained from the digester and recycled stream. Conclusion: By increasing the sludge recycling rate upon higher application of OLR, the treatment process was kept stable with high COD removal efficiency. The biogas and methane productivity were initially improved but reduced once OLR and recycling rate were increased to 10.0 kg COD m3 day-1 and 18 m3 day-1 respectively.

[1]  J. Barford,et al.  Mesophilic semi-continuous anaerobic digestion of palm oil mill effluent , 1985 .

[2]  A. Mohamed,et al.  High-rate anaerobic digestion of palm oil mill effluent in an upflow anaerobic sludge-fixed film bioreactor , 2006 .

[3]  D A Stahl,et al.  Fluorescent-oligonucleotide probing of whole cells for determinative, phylogenetic, and environmental studies in microbiology , 1990, Journal of bacteriology.

[4]  H. H. Lo,et al.  Treatment of Palm Oil Wastewaters , 2005 .

[5]  L. Björnsson,et al.  An update and optimisation of oligonucleotide probes targeting methanogenic Archaea for use in fluorescence in situ hybridisation (FISH). , 2006, Journal of microbiological methods.

[6]  Rafael Borja,et al.  Anaerobic digestion of palm oil mill effluent using an up-flow anaerobic sludge blanket reactor , 1994 .

[7]  F. Mosey.  Mathematical Modelling of the Anaerobic Digestion Process: Regulatory Mechanisms for the Formation of Short-Chain Volatile Acids from Glucose , 1983 .

[8]  J. M. Owens,et al.  Renewable methane from anaerobic digestion of biomass , 1997 .

[9]  Moktar Hamdi,et al.  Bioreactor performance in anaerobic digestion of fruit and vegetable wastes , 2005 .

[10]  W. Owen,et al.  Fundamentals of Anaerobic Digestion of Wastewater Sludges , 1986 .

[11]  Hajime Unno,et al.  Kinetic analysis of palm oil mill wastewater treatment by a modified anaerobic baffled reactor , 2001 .

[12]  Y. Shirai,et al.  Fluorescent in situ hybridization analysis of open lactic acid fermentation of kitchen refuse using rRNA-targeted oligonucleotide probes. , 2004, Journal of bioscience and bioengineering.

[13]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[14]  R. Amann.  In situ identification of micro-organisms by whole cell hybridization with rRNA-targeted nucleic acid probes , 1995 .

[15]  Tjandra Setiadi,et al.  Palm oil mill effluent treatment by anaerobic baffled reactors: recycle effects and biokinetic parameters , 1996 .

[16]  B. Ahring,et al.  Threshold Acetate Concentrations for Acetate Catabolism by Aceticlastic Methanogenic Bacteria , 1989, Applied and environmental microbiology.