Delamination detection in composite laminates using low frequency guided waves: Numerical simulations

The aim of this study is to find an efficient way of finite element modelling of guided wave propagation in composite laminates to detect delaminations. A novel approach is proposed to model delaminations by locally reducing the stiffness and it is implemented in a finite element shell model. The approach is verified by comparing the results with the results of two existing approaches. Results show that the stiffness reduction approach gives reasonable accuracy for the primary wave modes and improvement in simulation time. Moreover, it is shown that new convergence criteria should be considered to simulate the guided wave propagation. Additionally, the Pearson correlation coefficient is introduced as a good criterion for delamination detection in such problems. All the conclusions are made when simulations are performed in the low frequency range and can be used to study guided wave propagation in large composite structures such as wind turbine blades.

[1]  J. Fernández-Álvarez,et al.  Floquet-Bloch Theory and Its Application to the Dispersion Curves of Nonperiodic Layered Systems , 2015 .

[2]  N. Stephen.  MINDLIN PLATE THEORY: BEST SHEAR COEFFICIENT AND HIGHER SPECTRA VALIDITY , 1997 .

[3]  J. Rodgers,et al.  Thirteen ways to look at the correlation coefficient , 1988 .

[4]  B. Mace,et al.  Modelling wave propagation in two-dimensional structures using finite element analysis , 2008 .

[5]  N. D. Boffa,et al.  Ultrasonic wave propagation in composite laminates by numerical simulation , 2015 .

[6]  C. Ramadas,et al.  Identification of delamination interface in composite laminates using scattering characteristics of lamb wave: numerical and experimental studies , 2017 .

[7]  B. Murat.  Propagation and scattering of guided waves in composite plates with defects , 2015 .

[8]  T. K. Obrien,et al.  Analysis of local delaminations and their influence on composite laminate behavior , 1985 .

[9]  Ching-Tai Ng,et al.  Mode conversion and scattering analysis of guided waves at delaminations in laminated composite beams , 2015 .

[10]  Laurence J. Jacobs,et al.  Modeling elastic wave propagation in waveguides with the finite element method , 1999 .

[11]  Ramesh Talreja,et al.  Transverse Cracking and Stiffness Reduction in Composite Laminates , 1985 .

[12]  Lin Ye,et al.  Guided Lamb waves for identification of damage in composite structures: A review , 2006 .

[13]  Stefanos Vlachoutsis,et al.  Shear correction factors for plates and shells , 1992 .

[14]  G. Jeronimidis,et al.  Bending stiffness of composite plates with delamination , 2000 .

[15]  Christian N. Della,et al.  Vibration of Delaminated Composite Laminates: A Review , 2007 .

[16]  Peter Cawley,et al.  Optimization of lamb wave inspection techniques , 1992 .

[18]  Dimitris A. Saravanos,et al.  EFFECTS OF DELAMINATIONS ON THE DAMPED DYNAMIC CHARACTERISTICS OF COMPOSITE LAMINATES: ANALYSIS AND EXPERIMENTS , 1996 .

[19]  Cara A. C. Leckey,et al.  Simulation of guided‐wave ultrasound propagation in composite laminates: Benchmark comparisons of numerical codes and experiment , 2018, Ultrasonics.

[20]  Anders E Boström,et al.  Guided wave–based approach for ice detection on wind turbine blades , 2018 .

[21]  W. Ostachowicz,et al.  Numerical and experimental investigation of free vibration of multilayer delaminated composite beams and plates , 2000 .

[22]  E. G. Henneke,et al.  Lamb-wave monitoring of axial stiffness reduction of laminated composite plates , 1989 .

[23]  Gerard C. Pardoen,et al.  Effect of delamination on the flexural stiffness of composite laminates , 1988 .

[24]  T. Vu-Khanh,et al.  Damage Extension in Carbon Fiber/PEEK Crossply Laminates under Low Velocity Impact , 1994 .

[25]  T. O'Brien.  Characterization of delamination onset and growth in a composite laminate , 1982 .

[26]  Paul Fromme,et al.  Scattering of guided waves at delaminations in composite plates. , 2016, The Journal of the Acoustical Society of America.

[27]  Christian Willberg,et al.  Simulation Methods for Guided Wave-Based Structural Health Monitoring: A Review , 2015 .

[28]  W. Chiu,et al.  Scattering of the Fundamental Anti-symmetric Lamb Wave by a Mid-plane Edge Delamination in a Fiber-composite Laminate , 2017 .

[29]  C. Schaal,et al.  An analytical study of the scattering of ultrasonic guided waves at a delamination-like discontinuity in a plate , 2017 .

[30]  Massimo Ruzzene,et al.  Computational Techniques for Structural Health Monitoring , 2011 .

[31]  J. Engblom,et al.  The effect of aminations in graphite/PEEK composite plates on modal dynamic characteristics , 1995 .