Unsteady steam condensation flow patterns inside a miniature tube

Unsteady steam condensation inside a single miniature tube has been studied. The visualization of different instantaneous and periodically two-phase flow is conducted for different experimental conditions. The two-phase flow characterization is obtained using the image processing. Annular, slug bubbly, spherical bubbly, and wavy flows are observed by varying the steam inlet pressure and cooling heat transfer. The cycle of the periodically flows are compared. It is shown that increasing the cooling heat flow rate reduces the number of the instabilities and the injected bubbles. The axial vapor velocity decreases during the waves growth. The local distribution of the condensate film thickness is analyzed. It is shown that the liquid film becomes thinner near the meniscus-like interface because of the surface tension effect. The reverse annular flow is observed at the end of each periodic flow when the bubbles leave the channel. It can be concluded from experimental results that the stratification effect is not significant during the condensation inside the miniature tube. The capillary pressure evolution is measured. The maximum values are obtained in the waves locations and near the meniscus of the annular flow.

[1]  Satish G. Kandlikar,et al.  Evolution of Microchannel Flow Passages--Thermohydraulic Performance and Fabrication Technology , 2003 .

[2]  W. Nusselt.  Die Oberflachenkondensation des Wasserdampfes , 1916 .

[3]  P. Cheng,et al.  Condensation of steam in silicon microchannels , 2005 .

[4]  Srinivas Garimella,et al.  Characterization of two-phase flow patterns in small diameter round and rectangular tubes , 1999 .

[5]  Yuwen Zhang,et al.  Capillary Blocking in Forced Convective Condensation in Horizontal Miniature Channels , 2001 .

[6]  Moo Hwan Kim,et al.  Prediction of in-tube condensation heat transfer characteristics of binary refrigerant mixtures , 2003 .

[7]  Moo Hwan Kim,et al.  An experimental study of condensation heat transfer inside a mini-channel with a new measurement technique , 2004 .

[8]  W. Schaff,et al.  Infrared ellipsometry and Raman studies of hexagonal InN films: correlation between strain and vibrational properties , 2004 .

[9]  Huiying Wu,et al.  Condensation flow patterns in silicon microchannels , 2005 .

[10]  Vincent Platel,et al.  Experimental study of flow characteristics during condensation in narrow channels: the influence of the diameter channel on structure patterns , 2004 .

[11]  S. Koyama,et al.  Condensation of Refrigerant in a Multi-Port Channel , 2003 .

[12]  A. Faghri,et al.  Condensation of Forced Convection Two-Phase Flow in a Miniature Tube , 1999 .

[13]  W. Wang,et al.  A condensation heat transfer correlation for millimeter-scale tubing with flow regime transition , 2002 .

[14]  Srinivas Garimella,et al.  Condensation Flow Mechanisms in Microchannels: Basis for Pressure Drop and Heat Transfer Models , 2004 .

[15]  H. Louahlia,et al.  Condensation en film entre deux plaques planes verticales: Comparaison des performances thermiques du R134a et du R12 , 1997 .

[16]  Victoria S. Stenkamp,et al.  Testing of a Microchannel Partial Condenser and Phase Separator in Reduced Gravity , 2003 .

[17]  A. Cavallini,et al.  Condensation heat transfer and pressure drop inside channels for AC/HP application , 2002 .

[18]  David F. Fletcher,et al.  Local condensation heat transfer rates in fine passages , 2003 .

[19]  M. Miscevic,et al.  Void fraction invariance properties of condensation flow inside a capillary glass tube , 2005 .

[20]  Akimaro Kawahara,et al.  Effects of Channel Diameter and Liquid Properties on Void Fraction in Adiabatic Two-Phase Flow Through Microchannels , 2005 .