Huge differences between low- and high-angle twist grain boundaries: The case of ultrathin (001) Si films bonded to (001) Si wafers

Ultrathin (001) Si films bonded onto (001) Si wafers, inducing grain boundaries with twist angles varying from 0.5° to 12°, were studied by transmission electron microscopy. A great structural difference between low (ψ 6°) twist angles was observed. In low twist angle grain boundaries, “twist interfacial dislocations” are dissociated and produce rough interfaces with no oxide precipitates. It is the opposite in high-angle grain boundaries: there is no dissociation, the interfaces are smoother but contain oxide precipitates. These differences are not attributed to the thin thickness of one grain, but to the large atomic differences between high- and low-angle twist grain boundaries, which is not the case for tilt grain boundaries.

[1]  J. Eymery,et al.  Ultra thin silicon films directly bonded onto silicon wafers , 2000 .

[2]  J. Eymery,et al.  X-ray reflectivity of ultrathin twist-bonded silicon wafers , 1999 .

[3]  K. Scheerschmidt,et al.  Dissociation of screw dislocations in (001) low-angle twist boundaries: A source of the 30 o partial dislocations in silicon , 1999 .

[4]  P. Petroff,et al.  LATERAL ORDERING OF QUANTUM DOTS BY PERIODIC SUBSURFACE STRESSORS , 1999 .

[5]  Gilles Patriarche,et al.  Structure of the GaAs/InP interface obtained by direct wafer bonding optimised for surface emitting optical devices , 1997 .

[6]  U. Gösele,et al.  Twist wafer bonded “fixed-film” versus “compliant” substrates: correlated misfit dislocation generation and contaminant gettering , 1997 .

[7]  A. Claverie,et al.  Structural and electrical investigations of silicon wafer bonding interfaces , 1996 .

[8]  M. Bruel.  Silicon on insulator material technology , 1995 .

[9]  Robert W. Cahn,et al.  Electronic Structure and Properties of Semiconductors , 1991 .

[10]  T. Tan,et al.  Growth, shrinkage, and stability of interfacial oxide layers between directly bonded silicon wafers , 1990 .

[11]  A. Bourret,et al.  The low-angle [011] tilt boundary in germanium II. Theoretical analysis of observed configurations and stability , 1979 .

[12]  H. Foll,et al.  TEM observations on grain boundaries in sintered silicon, part 1 , 1978 .

[13]  W. Bollmann.  Crystal Defects and Crystalline Interfaces , 1970 .