论文信息 - Cross-Interaction Between Au/Sn and Cu/Sn Interfacial Reactions

Cross-Interaction Between Au/Sn and Cu/Sn Interfacial Reactions

The cross-interaction between Sn/Cu and Sn/Au interfacial reactions in an Au/Sn/Cu sandwich structure was studied. Field-emission electron probe microanalysis (FE-EPMA) revealed that the Cu content in the three Au-Sn phases (AuSn, AuSn2, and AuSn4) was very low, less than 1 at.%. This means␣that Cu from the opposite Cu foil did not participate in the interfacial reaction at the Sn/Au interface. On the opposite Sn/Cu side, Au-substituted (Cu,Au)6Sn5 formed within the initial 1 min of reflow. With prolonged reflow, the Au content in the Au-substituted (Cu,Au)6Sn5 increased and it transformed into a Cu-substituted (Au,Cu)Sn phase with 25 at.% Cu after 1 min of reflow at 250°C. The x-ray diffraction (XRD) pattern confirmed the phase transformation of Au-substituted (Cu,Au)6Sn5 to Cu-substituted (Au,Cu)Sn phase. In addition, there was greater Au consumption in the Au/Sn/Cu sandwich joint structure than in the single Au/Sn reaction case, due to some of the Au participating in the opposite Sn/Cu interfacial reaction.

[1] Stephan J. Meschter,et al. Wetting in the Au–Sn System , 2004 .

[2] Y. Yen,et al. Study of interfacial reactions between Sn–Ag–Cu alloys and Au substrate , 2007 .

[3] C. Kao,et al. Cross-interaction between Au and Cu in Au/Sn/Cu ternary diffusion couples , 2006 .

[4] Da-Yuan Shih,et al. Studies of the mechanical and electrical properties of lead-free solder joints , 2002 .

[5] Chien-Chung Jao,et al. Investigation of the Phase Equilibria of Sn-Cu-Au Ternary and Ag-Sn-Cu-Au Quaternary Systems and Interfacial Reactions in Sn-Cu/Au Couples , 2007 .

[6] C. Kao,et al. Cross-interaction of under-bump metallurgy and surface finish in flip-chip solder joints , 2004 .

[7] D. Baldwin,et al. Flip chip interconnect systems using copper wire stud bump and lead free solder , 2001 .

[8] S. Wang,et al. An effective Cu-Sn barrier layer for Au bump used in optoelectronic devices , 2004 .

[9] S. Wang,et al. Study of interaction between Cu-Sn and Ni-Sn interfacial reactions by Ni-Sn3.5Ag-Cu sandwich structure , 2003 .

[10] Michael R. Krames,et al. High-power AlGaInN flip-chip light-emitting diodes , 2001 .

[11] Chih Chen,et al. Cross interactions on interfacial compound formation of solder bumps and metallization layers during reflow , 2004 .

[12] King-Ning Tu,et al. Fast dissolution and soldering reactions on Au foils , 1998 .

[13] K. Houk,et al. The ternary system Au-Cu-Sn , 1992 .