Monitoring trough visits of growing-finishing pigs with UHF-RFID

Abstract Automatic monitoring of animal feeding behaviour in commercial farms is desirable as it is an important indicator for the well-being and health of animals. Low-frequency and high-frequency radio frequency identification (RFID) systems have been tested for the detection of feeding visits of growing-finishing pigs, but the suitability of ultra-high frequency (UHF) RFID for this application has not yet been shown. Therefore, the objective of this study was the validation of a UHF-RFID system, consisting of a reader, antennas and passive transponder ear tags, for the monitoring of visits of growing-finishing pigs at a short trough for liquid feeding. Consequently, (1) two antenna variants (free-form and patch antennas) were tested at different levels of antenna output power, (2) two methods to determine a bout criterion for the creation of trough visits from the RFID registrations were compared, and (3) a comparison of the RFID data with reference data from video observation was carried out. The analysis showed that the reading area exceeded the trough especially in the variants with high output power. Thus, the evaluation of the first and second rate of change of the total daily number and total daily duration of visits led to higher values for the bout criterion (50 s for both antenna variants) than the evaluation of the mean absolute deviation between video and RFID data (20 s for the free-form antenna and 30 s for the patch antennas). The trough visits observed were detected best with the patch antennas at 25 dBm output power and a bout criterion of 30 s with regard to average precision (61.1%), and correlation between the video data and RFID visits (R 2  = 0.87 for total number and 0.80 for total duration of visits). The average sensitivity of this variant was 49.7%, specificity 99.0% and accuracy 97.9%. The highest average sensitivity (79.7%) and a good correlation between video data and RFID visits (R 2  = 0.78 for total number, 0.56 for total duration of visits with a bout criterion of 50 s) were measured with the free-form antenna at 26 dBm. In conclusion, UHF-RFID can be suitable for the monitoring of trough visits of growing-finishing pigs, but the effect of ear tissue on the performance of the UHF-RFID ear tags should be reduced by further development. In addition, further research should be carried out to evaluate the potential of this technology completely for animal behaviour monitoring.

[1]  Daniel Berckmans.  Preface: Precision livestock farming (PLF) , 2008 .

[2]  D. Weary,et al.  Technical note: validation of a system for monitoring individual feeding and drinking behavior and intake in group-housed cattle. , 2007, Journal of dairy science.

[3]  Kyohei Fujimoto,et al.  Modern Small Antennas , 2014 .

[4]  Felix Adrion,et al.  Aufbau, Funktion und Test eines statischen Prüfstandes für UHF-RFID-Ohrmarken , 2015 .

[5]  L. Ruiz-Garcia,et al.  The role of RFID in agriculture: Applications, limitations and challenges , 2011 .

[6]  Thomas Jungbluth,et al.  Sektorlokalisation von Mastschweinen mit UHF-RFID , 2016, GIL Jahrestagung.

[7]  P.V. Nikitin,et al.  Performance limitations of passive UHF RFID systems , 2006, 2006 IEEE Antennas and Propagation Society International Symposium.

[8]  B. Kippelen,et al.  RF Tag Antenna Performance on Various Materials Using Radio Link Budgets , 2006, IEEE Antennas and Wireless Propagation Letters.

[9]  Steffen Hoy,et al.  Investigations on feed intake and social behaviour of fattening pigs fed at an electronic feeding station , 2012 .

[10]  Roger A. Eigenberg,et al.  Determination of Minimum Meal Interval and Analysis of Feeding Behavior in Shaded and Open-Lot Feedlot Heifers , 2015 .

[11]  J. Svendsen,et al.  Degree of competition at feeding differentially affects behavior and performance of group-housed growing-finishing pigs of different relative weights. , 2002, Journal of animal science.

[12]  Thomas Jungbluth,et al.  Einsatz eines UHF-Transponders zur Simultanerfassung von Mastschweinen , 2011 .

[13]  H W Gonyou,et al.  Effects of eating space and availability of water in feeders on productivity and eating behavior of grower/finisher pigs. , 2000, Journal of animal science.

[14]  Cécile Cornou,et al.  Automatic detection of oestrus and health disorders using data from electronic sow feeders , 2008 .

[15]  B. Hart.  Biological basis of the behavior of sick animals , 1988, Neuroscience & Biobehavioral Reviews.

[16]  David Girbau,et al.  Read range reduction in UHF RFID due to antenna detuning and gain penalty , 2011 .

[17]  Beat Wechsler,et al.  Effects of animal/feeding-place ratio on the behaviour and performance of fattening pigs fed via sensor-controlled liquid feeding , 2006 .

[18]  G.D. Durgin,et al.  Complete Link Budgets for Backscatter-Radio and RFID Systems , 2009, IEEE Antennas and Propagation Magazine.

[19]  A. H. Ipema,et al.  The use of Ultra High Frequency (UHF) tags for fattening pig identification , 2013 .

[20]  P. Nikitin,et al.  Antenna design for UHF RFID tags: a review and a practical application , 2005, IEEE Transactions on Antennas and Propagation.

[21]  Thomas Jungbluth,et al.  Gruppenhaltung von tragenden Sauen: Indikatoren zum Verhaltens- und Gesundheitsmonitoring , 2012 .

[22]  Felix Adrion,et al.  Comparison of different ultra-high-frequency transponder ear tags for simultaneous detection of cattle and pigs , 2016 .

[23]  Thomas Jungbluth,et al.  Methodology of a dynamic test bench to test ultra-high-frequency transponder ear tags in motion , 2015, Comput. Electron. Agric..

[24]  D M Weary,et al.  Board-invited review: Using behavior to predict and identify ill health in animals. , 2009, Journal of animal science.

[25]  Kristof Mertens,et al.  Validation of a High Frequency Radio Frequency Identification (HF RFID) system for registering feeding patterns of growing-finishing pigs , 2014 .

[26]  G. Koob,et al.  Measuring meals: structure of prandial food and water intake of rats. , 2005, American journal of physiology. Regulatory, integrative and comparative physiology.

[27]  Bart De Ketelaere,et al.  Methods to construct feeding visits from RFID registrations of growing-finishing pigs at the feed trough , 2016, Comput. Electron. Agric..

[28]  J. A. DeShazer,et al.  Influence of temperature and light on feeding behaviour of pigs , 1989 .

[29]  M. Coffey,et al.  Changes in feeding behavior as possible indicators for the automatic monitoring of health disorders in dairy cows. , 2008, Journal of dairy science.

[30]  Michael C. Brumm,et al.  Impact of feeders and drinker devices on pig performance, water use, and manure volume , 2000 .

[31]  M. Chizzotti,et al.  Technical note: Validation of a system for monitoring individual feeding behavior and individual feed intake in dairy cattle. , 2015, Journal of dairy science.

[32]  T. M. Brown-Brandl,et al.  Development of a Livestock Feeding Behavior Monitoring System , 2011 .

[33]  Roger A. Eigenberg,et al.  Analysis of feeding behavior of group housed growing-finishing pigs , 2013 .

[34]  Georg Wendl,et al.  Identifizierung von Legehennen am breiten elektronischen Schlupfloch , 2010 .

[35]  Klaus Finkenzeller,et al.  RFID-Handbuch : Grundlagen und praktische Anwendungen von Transpondern, kontaktlosen Chipkarten und NFC , 2015 .

[36]  J Y Dourmad,et al.  Meta-analysis on the effects of the physical environment, animal traits, feeder and feed characteristics on the feeding behaviour and performance of growing-finishing pigs. , 2012, Animal : an international journal of animal bioscience.

[37]  Herman Van den Weghe,et al.  Application of RFID technology using passive HF transponders for the individual identification of weaned piglets at the feed trough , 2009 .