Feasibility Study for Detection and Quantification of Corrosion in Bridge Barrier Rails

Technical challenges exist with infrastructure that can be addressed by nondestructive evaluation (NDE) methods, such as detecting corrosion damage to reinforcing steel that anchor concrete bridge railings to bridge road decks. Moisture and chloride ions reach the anchors along the cold joint between the rails and deck, causing corrosion that weakens the anchors and ultimately the barriers. The Center for Nondestructive Evaluation at Iowa State University has experience in development of measurement techniques and new sensors using a variety of interrogating energies. This research evaluated feasibility of three technologies—x-ray radiation, ground-penetrating radar (GPR), and magnetic flux leakage (MFL)—for detection and quantification of corrosion of embedded reinforcing steel. Controlled samples containing pristine reinforcing steel with and without epoxy and reinforcing steel with 25 percent and 50 percent section reduction were embedded in concrete at 2.5 in. deep for laboratory evaluation. Two of the techniques, GPR and MFL, were used in a limited field test on the Iowa Highway 210 Bridge over Interstate 35 in Story County. The methods provide useful and complementary information. GPR provides a rapid approach to identify reinforcing steel that has anomalous responses. MFL provides similar detection responses but could be optimized to provide more quantitative correlation to actual condition. Full implementation could use either GPR or MFL methods to identify areas of concern, followed by radiography to give a visual image of the actual condition, providing the final guidance for maintenance actions.

[1]  M. Baucus.  Transportation Research Board , 1982 .

[2]  Clay Naito,et al.  Nondestructive Inspection of Strand Corrosion in Prestressed Concrete Box Beam Members , 2010 .

[3]  Joseph N. Gray,et al.  Human body radiography simulations: development of a virtual radiography environment , 1998, Medical Imaging.

[4]  B. W. James,et al.  Evaluation of NDE techniques for detecting grout defects in cable stays , 1994 .

[5]  Joaquim Figueiras,et al.  GAMMA-RAY INSPECTION OF POST TENSIONING CABLES IN A CONCRETE BRIDGE , 2010 .

[6]  Teresita Frigerio,et al.  Gamma-ray imaging for void and corrosion assessment in PT girders , 2008 .

[7]  A T Ciolko,et al.  AN IMMEDIATE PAYOFF FROM FHWA'S NDE INITIATIVE , 1999 .

[8]  Jack Blitz,et al.  Electrical and Magnetic Methods of Nondestructive Testing , 2020 .

[9]  Robert L. Lytton,et al.  A Plan for Developing High-Speed, Nondestructive Testing Procedures for Both Design Evaluation and Construction Inspection , 2009 .

[10]  Kevin L. Rens,et al.  Review of nondestructive evaluation techniques of civil infrastructure , 1999 .

[11]  Habib Tabatabai,et al.  NONDESTRUCTIVE METHODS FOR CONDITION EVALUATION OF PRESTRESSING STEEL STRANDS IN CONCRETE BRIDGES. FINAL REPORT PHASE I: TECHNOLOGY REVIEW , 1999 .

[12]  B. Hillemeier,et al.  Capacity of the remanent magnetism method to detect fractures of steel in tendons embedded in prestressed concrete , 1997 .

[13]  Imad L. Al-Qadi,et al.  Ground-Penetrating Radar Calibration at the Virginia Smart Road and Signal Analysis to Improve Prediction of Flexible Pavement Layer Thicknesses , 2005 .

[14]  Joseph Callerame.  X-ray backscatter imaging: Photography through barriers , 2005 .

[15]  Al Ghorbanpoor,et al.  MAGNETIC-BASED NDE OF PRESTRESSED AND POST-TENSIONED CONCRETE MEMBERS -- THE MFL SYSTEM , 2000 .

[16]  B. Hillemeier,et al.  Magnetic detection of prestressing steel fractures in prestressed concrete , 1998 .

[17]  H Thomas Yu.  Use of Magnetic Tomography Technology to Evaluate Dowel Bar Placement , 2005 .

[18]  D. Thompson,et al.  Review of Progress in Quantitative Nondestructive Evaluation , 1982 .

[19]  Benjamin A. Graybeal,et al.  Highway Bridge Inspection: State-of-the-Practice Survey , 2001 .

[20]  Phil C Sirles.  Use of Geophysics for Transportation Projects , 2006 .

[21]  Esam M.A. Hussein,et al.  A compton scattering method for inspecting concrete structures , 1989 .

[22]  Gottfried Sawade,et al.  Inspection of Prestressed Concrete Members using the Magnetic Leakage Flux Measurement Method — Estimation of Detection Limit , 2007 .

[23]  Christophe Aubagnac,et al.  Comparison of NDT techniques on a post-tensioned beam before its autopsy , 2002 .

[24]  Vijay Devabhaktuni,et al.  A New Magnetic Sensor Concept for Nondestructive Evaluation of Deteriorated Prestressing Strand , 2012 .

[25]  D. O. Thompson,et al.  Review of Progress in Quantitative Nondestructive Evaluation , 1985 .

[26]  G P Roberson,et al.  COMPUTERIZED TOMOGRAPHY ANALYSIS OF REINFORCED CONCRETE , 1993 .

[27]  Steven B. Chase,et al.  NONDESTRUCTIVE EVALUATION FOR BRIDGE MANAGEMENT IN THE NEXT CENTURY , 1997 .

[28]  Alan M. Jacobs,et al.  Detection of defects in foam thermal insulation using lateral migration backscatter x-ray radiography , 2004, SPIE Optics + Photonics.

[29]  Vijay Devabhaktuni,et al.  Magnetic Sensor for Nondestructive Evaluation of Deteriorated Prestressing Strand--Phase II , 2011 .

[30]  W Podolny,et al.  PERFORMANCE OF CONCRETE SEGMENTAL AND CABLE-STAYED BRIDGES IN EUROPE , 2001 .

[31]  Roger DeBaun Owen.  Portable linear accelerators for X-ray and electron-beam applications in civil engineering , 1998 .

[32]  G G Clemena,et al.  EVALUATION OF NONDESTRUCTIVE EVALUATION METHODS FOR APPLICATION IN EARLY DETECTION OF DETERIORATION IN CONCRETE PAVEMENTS , 2000 .

[33]  Atorod Azizinamini,et al.  Nondestructive Method to Detect Corrosion of Steel Elements in Concrete , 2009 .

[34]  Adrian T. Ciolko,et al.  TOLEDO'S NEW SIGNATURE STRUCTURE , 2002 .

[35]  Ian C. Hodgson,et al.  Inspection methods & techniques to determine non-visible corrosion of prestressing strands in concrete bridge components : task 2, assessment of candidate NDT methods. , 2010 .

[36]  M. Leeming,et al.  Radiographic inspection of post-tensioned concrete bridges , 1994 .