Experiments measuring film cooling performance are often performed near room temperature over small ranges of driving temperature. For such experiments, fluid properties are nearly constant within the boundary layer and radiative heat transfer is negligible. Consequently, the heat flux to the wall is a linear function of driving temperature. Therefore, the convective heat transfer coefficient and adiabatic wall temperature can be extracted from heat flux measurements at two or more driving temperatures.For large driving temperatures, like those seen in gas turbine engines, significant property variations exist within the boundary layer. In addition, radiative heat transfer becomes sufficiently large such that it can no longer be neglected. As a result, heat flux becomes a non-linear function of driving temperature. Thus, for these high temperature cases, ambient temperature methods utilizing a linear heat flux assumption cannot be employed to characterize the convective heat transfer.The present study experimentally examines the non-linearity of heat flux for large driving temperatures flowing over a flat plate. The results are first used to validate the temperature ratio method presented in a previous study to account for variable properties within a boundary layer. This validation highlighted the need to account for the radiative component of the overall heat transfer. A method is subsequently proposed to account for the effects of both variable properties and radiation simultaneously. Finally, the method is validated with the experimental data.While this methodology was developed in a flat plate rig, it is applicable to any relevant configuration in a hot environment. The method is general and independent of the overall radiative component magnitude and direction. Overall, the technique provides a means of quantifying the impact of both variable properties and the radiative flux on the conductive heat transfer to or from a surface in a single experiment.
[1]
M. Polanka,et al.
Experimental Investigation of Net Heat Flux Reduction at Combustion Temperatures
,
2015
.
[2]
M. Polanka,et al.
Effect of Variable Properties Within a Boundary Layer With Large Freestream-to-Wall Temperature Differences
,
2013
.
[3]
S. Ekkad,et al.
A Transient Infrared Thermography Method for Simultaneous Film Cooling Effectiveness and Heat Transfer Coefficient Measurements From a Single Test
,
2004
.
[4]
O. Popp,et al.
Steady and Unsteady Heat Transfer in a Transonic Film Cooled Turbine Cascade
,
1999
.
[5]
J. Zelina,et al.
Combustor stability and emissions research using a well-stirred reactor
,
1997
.
[6]
Robert J. Moffat,et al.
Describing the Uncertainties in Experimental Results
,
1988
.
[7]
M. Pinar Mengüç,et al.
Thermal Radiation Heat Transfer
,
2020
.
[8]
J. Whitelaw,et al.
Convective heat and mass transfer
,
1966
.