Condensation of vapor in the presence of non-condensable gas in condensers

Abstract This paper presents a set of differential and algebraic equations that model heat and mass transfer in condensers in which a mixture of water vapor and non-condensable gas is cooled. The model has been used to predict the condensation rate, the bulk temperatures of the coolant and the gas–vapor mixture, and the surface temperatures of the condenser wall. The predicted results for counter flow tube condensers are compared with three sets of published experimental data for system in which air is the non-condensable gas. It is found that the predicted condensation rates and coolant bulk temperatures agree very well with all the three sets of experimental data, the predicted wall temperatures agree reasonably well with the experimental results, and the agreement between the predictions and the experimental results on the bulk temperature of the air–vapor mixture is excellent for one set of the experimental data, reasonable for the second set of experimental data, but poor for the third set of experimental data. It is suggested that the poor agreement between the predicted and measured bulk temperatures of the mixture for the third set of experimental data arises from the experimental errors. The results from this study show that when modeling vapor condensation in the presence of a non-condensable gas, a simple model for the mixture channel alone may not be sufficient since neither the temperature nor the heat flux at the wall can be assumed to be constant. The results also show that the wall temperature in the coolant channel can be quite high, and careful modeling of the heat transfer in the coolant channel is needed in order to achieve good agreement between the model predictions and the experimental results.

[1]  Ali Tanrikut,et al.  Experimental Research on In-Tube Condensation under Steady-State and Transient Conditions , 2005 .

[2]  Scott J. Ormiston,et al.  Numerical solution of film condensation from turbulent flow of vapor–gas mixtures in vertical tubes , 2007 .

[3]  A. Dehbi,et al.  A model for the performance of a vertical tube condenser in the presence of noncondensable gases , 1997 .

[4]  Ephraim M Sparrow,et al.  Forced convection condensation in the presence of noncondensables and interfacial resistance , 1967 .

[5]  A. Colburn,et al.  Design of Cooler Condensers for Mixtures of Vapors with Noncondensing Gases , 1934 .

[6]  Ephraim M Sparrow,et al.  Condensation Heat Transfer in the Presence of a Noncondensable Gas , 1964 .

[7]  Nicola Forgione,et al.  Prediction of transpiration effects on heat and mass transfer by different turbulence models , 2008 .

[8]  J. Whitelaw,et al.  Convective heat and mass transfer , 1966 .

[9]  S. Haaland.  Simple and Explicit Formulas for the Friction Factor in Turbulent Pipe Flow , 1983 .

[10]  Arthur E. Bergles,et al.  Augmentation of convective heat and mass transfer , 1970 .

[11]  Chuan-Jing Tu,et al.  Effects of non-condensable gas on laminar film condensation in a vertical tube , 1988 .

[12]  Shripad T. Revankar,et al.  Experimental and theoretical investigation of film condensation with noncondensable gas , 2006 .

[13]  Condensation Correlation for a Vertical Passive Condenser System , 2010 .

[14]  Ephraim M Sparrow,et al.  Condensation heat transfer in the presence of noncondensables, interfacial resistance, superheating, variable properties, and diffusion , 1966 .

[15]  Gumersindo Verdú,et al.  Turbulent vapor condensation with noncondensable gases in vertical tubes , 1996 .

[16]  Donald M. McEligot,et al.  Thermal Entry for Low Reynolds Number Turbulent Flow , 1969 .

[17]  D. Che,et al.  Heat and mass transfer characteristics of simulated high moisture flue gases , 2004 .

[18]  P. Lebedev,et al.  Aerodynamics, heat and mass transfer in vapour condensation from humid air on a flat plate in a longitudinal flow in asymmetrically cooled slot , 1969 .

[19]  V. Murali Krishna,et al.  Convective condensation of vapor in the presence of a non-condensable gas of high concentration in laminar flow in a vertical pipe , 2008 .

[20]  M. Siddique,et al.  The effects of noncondensable gases on steam condensation under forced convection conditions , 1992 .

[21]  J. Muñoz-Cobo,et al.  Non-iterative model for condensation heat transfer in presence of non-condensable gases inside passive containment cooling vertical tubes , 2008 .

[22]  L. A. Bromley.  Effect of Heat Capacity of Condensate , 1952 .

[23]  Y. Çengel,et al.  Thermodynamics : An Engineering Approach , 1989 .

[24]  M. Ahmadinejad,et al.  Experimental comparison of film-wise and drop-wise condensations of steam on vertical flat plates with the presence of air , 2004 .

[25]  W. Rohsenow,et al.  Handbook of Heat Transfer , 1998 .

[26]  Hee Cheon No,et al.  Non-Iterative Condensation Model for Steam Condensation with Noncondensable Gas in a Vertical Tubes , 2002 .

[27]  S. Churchill.  A comprehensive correlating equation for laminar, assisting, forced and free convection , 1977 .