LPG sensing properties of ZnO films prepared by spray pyrolysis method : Effect of molarity of precursor solution

Abstract Nanocrystalline ZnO films were deposited onto glass substrates by spray pyrolysis of zinc nitrate solutions and used as a liquid petroleum gas (LPG) sensor. The dependence of the LPG sensing properties on the molar concentration of zinc nitrate solutions was investigated. The ZnO films were oriented along (0 0 2) with the hexagonal crystal structure. The grain size and grain density increased with an increase in molar concentration of zinc nitrate solutions. The gas sensing properties for LPG of the ZnO films for LPG with different grain sizes were measured at different temperatures. The maximum sensitivity of 43% at the operation temperature of 673 K was found for the ZnO film prepared by spraying a 0.1 M solution. The ZnO thin films exhibited good sensitivity and rapid response–recovery characteristics to LPG. Further, it has been shown the gas sensitivity of the ZnO gas sensor depends upon its grain size.

[1]  K. G. Gopchandran,et al.  Optical and electrical properties of zinc oxide films prepared by spray pyrolysis , 1999 .

[2]  G. Rao,et al.  Gas sensitivity of ZnO based thick film sensor to NH3 at room temperature , 1999 .

[3]  S. Ray,et al.  Zinc oxide - a transparent, conducting IR-reflector prepared by rf-magnetron sputtering , 2003 .

[4]  Byung-Ok Park,et al.  Effects of the annealing treatment on electrical and optical properties of ZnO transparent conduction films by ultrasonic spraying pyrolysis , 2004 .

[5]  J. Peng,et al.  Preparation and gas-sensing properties of α-Fe2O3 thin films , 1995 .

[6]  Fu Honggang,et al.  Investigations on the surface modification of ZnO nanoparticle photocatalyst by depositing Pd , 2004 .

[7]  D. Gruber,et al.  A novel gas sensor design based on CH4/H2/H2O plasma etched ZnO thin films , 2003 .

[8]  B.Bhooloka Rao,et al.  Zinc oxide ceramic semi-conductor gas sensor for ethanol vapour , 2000 .

[9]  Khalil Arshak,et al.  Development of a novel gas sensor based on oxide thick films , 2005 .

[10]  S. Tao,et al.  Preparation and characterization of nanocrystalline α-Fe2O3 by a sol-gel process , 1997 .

[11]  Toshko G. Nenov,et al.  Ceramic Sensors: Technology and Applications , 1996 .

[12]  R. N. Karekar,et al.  Formulation and characterization of ZnO:Sb thick-film gas sensors , 1998 .

[13]  Min-Hsiung Hon,et al.  The effects of thickness and operation temperature on ZnO:Al thin film CO gas sensor , 2002 .

[14]  A. Ennaoui,et al.  Chemical-bath ZnO buffer layer for CuInS2 thin-film solar cells , 1998 .

[15]  Partha Mitra,et al.  ZnO thin film sensor , 1998 .

[16]  M. Miki-Yoshida,et al.  Growth, structure and optical characterization of high quality ZnO thin films obtained by spray pyrolysis , 1999 .

[17]  M. Miki-Yoshida,et al.  Influence of Al, In, Cu, Fe and Sn dopants on the response of thin film ZnO gas sensor to ethanol vapour , 2000 .

[18]  P. P. Sahay,et al.  Sprayed ZnO thin films for ethanol sensors , 2005 .

[19]  D. C. Reynolds,et al.  Optically pumped ultraviolet lasing from ZnO , 1996 .

[20]  Hui Lu,et al.  Characterization of SnO2 films deposited by d.c. gas discharge activating reaction evaporation onto amorphous and crystalline substrates , 1993 .

[21]  张哉根,et al.  Leu-M , 1991 .

[22]  H. S. Maiti,et al.  A wet-chemical process to form palladium oxide sensitiser layer on thin film zinc oxide based LPG sensor , 2004 .

[23]  C. Lokhande,et al.  Cathodic electrodeposition of RuO2 thin films from Ru(III)Cl3 solution , 2004 .

[24]  P. Patil.  Versatility of chemical spray pyrolysis technique , 1999 .

[25]  B. Rezig,et al.  Structural and electrical properties of ZnO films prepared by screen printing technique , 2001 .

[26]  H. Ohno,et al.  Making nonmagnetic semiconductors ferromagnetic , 1998, Science.

[27]  Yiying Wu,et al.  Room-Temperature Ultraviolet Nanowire Nanolasers , 2001, Science.

[28]  M. Takwale,et al.  Effect of precursor solution concentration on the structural properties of sprayed ZnO films , 1992 .

[29]  Ghenadii Korotcenkov,et al.  Peculiarities of SnO2 thin film deposition by spray pyrolysis for gas sensor application , 2001 .