Preparation of Activated and Non-Activated Carbon from Conocarpus Pruning Waste as Low-Cost Adsorbent for Removal of Heavy Metal Ions from Aqueous Solution

Conocarpus pruning waste, an agricultural byproduct, was converted into low-cost activated and non-activated carbons and used for the remediation of Cd2+, Cu2+, and Pb2+ from aqueous solutions. The carbonization was carried out at 400 °C, while the activation was carried out in the presence of KOH and ZnCl2. Batch single-solute and multi-solute equilibrium and kinetic experiments were carried out to determine the adsorption capacities of the prepared activated and non-activated carbons, and these were further compared with commercially available activated carbon. The results showed that KOH-activated carbon (CK) outperformed the other activated and non-activated carbons in terms of adsorption efficiency. CK removed >50% of the applied Cd2+ and Cu2+ and 100% of Pb2+ at the initial concentration of 40 mg L-1. Interestingly, the performance of Conocarpus-derived non-activated carbon was better than that of the commercial activated carbon, as observed from the Langmuir maximum adsorption capacities of 65.61, 66.12, and 223.05 µmol g-1 for Cd2+, Cu2+, and Pb2+, respectively. The Pb2+ was the metal most easily removed from aqueous solution because of its large ionic radius. The kinetic dynamics were well described by the pseudo-second order and Elovich models.

[1]  M. A. González,et al.  Cu(II), Pb(II) and Cd(II) sorption on different layered double hydroxides. A kinetic and thermodynamic study and competing factors , 2015 .

[2]  R. Gambari,et al.  Preparation and characterization of bio-safe activated charcoal derived from coffee waste residue and its application for removal of lead and copper ions , 2014 .

[3]  Tamer M. Alslaibi,et al.  Preparation of Activated Carbon From Olive Stone Waste: Optimization Study on the Removal of Cu2+, Cd2+, Ni2+, Pb2+, Fe2+, and Zn2+ from Aqueous Solution Using Response Surface Methodology , 2014 .

[4]  N. Bolan,et al.  Biochar as a sorbent for contaminant management in soil and water: a review. , 2014, Chemosphere.

[5]  M. Hashim,et al.  Hexavalent Chromium Adsorption by a Novel Activated Carbon Prepared by Microwave Activation , 2014 .

[6]  A. Johari,et al.  Removal of Heavy Metals onto KOH-activated Ash-rich Sludge Adsorbent , 2014 .

[7]  A. Al-Omran,et al.  Pyrolysis temperature induced changes in characteristics and chemical composition of biochar produced from conocarpus wastes. , 2013, Bioresource technology.

[8]  Biao Huang,et al.  PREPARATION OF PHOSPHORIC ACID ACTIVATED CARBON FROM SUGARCANE BAGASSE BY MECHANOCHEMICAL PROCESSING , 2012 .

[9]  E. Maurer,et al.  Low-Tech Coconut Shell Activated Charcoal Production , 2012 .

[10]  S. M. Zain,et al.  Batch and fixed bed adsorption studies of lead (II) cations from aqueous solutions onto granular activated carbon derived from Mangostana garcinia shell , 2012, BioResources.

[11]  C. Saka.  BET, TG–DTG, FT-IR, SEM, iodine number analysis and preparation of activated carbon from acorn shell by chemical activation with ZnCl2 , 2012 .

[12]  Zaira Zaman Chowdhury,et al.  Preparation and characterizations of activated carbon from kenaf fiber for equilibrium adsorption studies of copper from wastewater , 2012, Korean Journal of Chemical Engineering.

[13]  Sung-Chul Kim,et al.  Eggshell and coral wastes as low cost sorbents for the removal of Pb2+, Cd2+ and Cu2+ from aqueous solutions , 2012 .

[14]  M. Asaithambi,et al.  Physico-chemical and adsorption studies of activated carbon from Agricultural wastes , 2012 .

[15]  Maria Pesavento,et al.  Beyond the synthesis of novel solid phases: Review on modelling of sorption phenomena , 2012 .

[16]  M. Haris,et al.  The sorption of cadmium(II) ions on mercerized rice husk and activated carbon , 2011 .

[17]  A. Al-Jasser.  Saudi wastewater reuse standards for agricultural irrigation: Riyadh treatment plants effluent compliance , 2011 .

[18]  Horsfall M. Jnr.  Preparation and Characterization of Activated Carbon derived from Fluted Pumpkin Stem Waste (Telfairia occidentalis Hook F) , 2011 .

[19]  E. B. Naidoo,et al.  Biosorption of copper(II) and lead(II) onto potassium hydroxide treated pine cone powder. , 2010, Journal of environmental management.

[20]  E. B. Naidoo,et al.  Dynamic studies and pseudo-second order modeling of copper(II) biosorption onto pine cone powder , 2010 .

[21]  Anita Plazinska,et al.  Theoretical models of sorption kinetics including a surface reaction mechanism: a review. , 2009, Advances in colloid and interface science.

[22]  R. Subha,et al.  Zinc chloride activated coir pith carbon as low cost adsorbent for removal of 2,4-dichlorophenol: Equilibrium and kinetic studies , 2009 .

[23]  J. Tontrakoon,et al.  Adsorption of Lead(II) and Cadmium(II) Ions from Aqueous Solutions by Adsorption on Activated Carbon Prepared from Cashew Nut Shells , 2009 .

[24]  Dandan Zhou,et al.  Transitional adsorption and partition of nonpolar and polar aromatic contaminants by biochars of pine needles with different pyrolytic temperatures. , 2008, Environmental science & technology.

[25]  A. Usman.  The relative adsorption selectivities of Pb, Cu, Zn, Cd and Ni by soils developed on shale in New Valley, Egypt , 2008 .

[26]  K. Kumar,et al.  Comparison of various error functions in predicting the optimum isotherm by linear and non-linear regression analysis for the sorption of basic red 9 by activated carbon. , 2008, Journal of hazardous materials.

[27]  Manuel Sánchez-Polo,et al.  Waste materials for activated carbon preparation and its use in aqueous-phase treatment: a review. , 2007, Journal of environmental management.

[28]  M. Soleimani,et al.  Agricultural Waste Conversion to Activated Carbon by Chemical Activation with Phosphoric Acid , 2007 .

[29]  F. Pagnanelli,et al.  Biosorption of protons and heavy metals onto olive pomace: modelling of competition effects. , 2005, Water research.

[30]  D. Cazorla-Amorós,et al.  About reactions occurring during chemical activation with hydroxides , 2004 .

[31]  W. Marshall,et al.  Activated carbon from pecan shell: process description and economic analysis , 2003 .

[32]  Tonni Agustiono Kurniawan,et al.  Low-cost adsorbents for heavy metals uptake from contaminated water: a review. , 2003, Journal of hazardous materials.

[33]  J. F. Porter,et al.  Equilibrium Isotherm Studies for the Sorption of Divalent Metal Ions onto Peat: Copper, Nickel and Lead Single Component Systems , 2002 .

[34]  Lei Li,et al.  Effects of activated carbon surface chemistry and pore structure on the adsorption of organic contaminants from aqueous solution , 2002 .

[35]  A. Site.  Factors Affecting Sorption of Organic Compounds in Natural Sorbent/Water Systems and Sorption Coefficients for Selected Pollutants. A Review , 2001 .

[36]  Walid A. Abderrahman,et al.  Urban Water Management in Developing Arid Countries , 2000 .

[37]  R. West.  Tidal salt marsh and mangal formations of Middle and South America , 1977 .