论文信息 - Preparation of B-Si films by chemical vapor deposition

Preparation of B-Si films by chemical vapor deposition

B-Si films were prepared by chemical vapor deposition (CVD) using high-frequency induction heating. Mixed gases of silane and diborane were used as source materials. The deposits were prepared on a graphite substrates at the substrate temperature between 1188 and 1616 K under the total pressure in the CVD chamber of 2.7 kPa. The molar ratio of B/Si in the source gas was 6 to 60. At lower B/Si Ratio in the source gas, SiB/sub 4/ was formed. SiB/sub 6/ and SiB/sub n/ could be also formed at the higher ratios of B/Si. And, the deposit was dependent on the substrate temperature. The deposit with higher B concentration was obtained with increasing the substrate temperature. The electrical properties such as Seebeck coefficient and electrical conductivity of the films were measured.

[1] D. Emin,et al. Electronic transport properties of hot-pressed B6Si , 1987 .

[2] J. Dusseau,et al. Conductibilité thermique de borures de silicium , 1980 .

[3] T. Hirai,et al. Phase Diagram and Thermoelectric Property of Si-B System Ceramics , 1994 .

[4] H. Pierson,et al. The chemical vapor deposition of TiB2 from diborane , 1980 .

[5] D. Emin,et al. Anomalous Seebeck coefficient in boron carbides , 1987 .

[6] G. Abbaschian,et al. The B−Si (Boron-Silicon) system , 1984 .

[7] T. Hirai,et al. THERMOELECTRICAL PROPERTIES OF Si-Ti-B IN SITU COMPOSITE PLATES PREPARED BY CHEMICAL VAPOR DEPOSITION , 1992 .

[8] T. Hirai,et al. Chemical Vapor Deposition of Silicon Borides , 1989 .

[9] H. F. Rizzo,et al. Refractory Compositions Based on Silicon‐Boron Oxygen Reactions , 1960 .

[10] D. Emin,et al. Conduction mechanism in boron carbide , 1984 .

[11] J. Robert,et al. Fabrication and study of electrical properties of boron-silicon compounds with high boron concentration , 1976 .