The effect of displacement rate on imbibition relative permeability and residual saturation

A dynamic network model for imbibition based on a physically realistic description of the complex dynamics of film flow, film swelling and snap-off is described. The model shows that film swelling is a capillary driven nonlinear diffusive process and that the competition between snap-off and frontal displacements is rate dependent resulting in rate dependent relative permeability curves and residual saturations. In contrast to existing quasi-static network models where snap-off is suppressed by contact angle alone, the dynamic model introduces displacement rate as an additional snap-off inhibiting mechanism. The network model is used to analyse the complex interaction between displacement rate, contact angle, aspect ratio and pore and throat shapes on relative permeability. Computed relative permeabilities and residual saturations are compared with laboratory measured data for strongly water-wet Berea sandstone. It is concluded that the magnitude of the rate effect on relative permeability for a particular rock and wetting state depends largely on the aspect ratio. Higher aspect ratios produce larger rate effects than smaller aspect ratios.

[1]  M. Blunt.  Physically-based network modeling of multiphase flow in intermediate-wet porous media , 1998 .

[2]  Tadeusz W Patzek.  Verification of a Complete Pore Network Simulator of Drainage and Imbibition , 2000 .

[3]  Stig Bakke,et al.  Extending Predictive Capabilities to Network Models , 1998 .

[4]  D. Ogbe,et al.  Correcting Oil/Water Relative Permeability Data for Capillary End Effect in Displacement Experiments , 1988 .

[5]  F. Dullien.  Porous Media: Fluid Transport and Pore Structure , 1979 .

[6]  Ioannis Chatzis,et al.  The Imbibition and Flow of a Wetting Liquid along the Corners of a Square Capillary Tube , 1995 .

[7]  Alain Labastie,et al.  Effect Of Flow Rate And Wettability On Water-Oil Relative Permeabilities And Capillary Pressure , 1980 .

[8]  N. Morrow,et al.  Correlation of capillary number relationships for sandstone , 1984 .

[9]  Matthew D. Jackson,et al.  Prediction of wettability variation and its impact on flow using pore- to reservoir-scale simulations , 2003 .

[10]  Steven Robert McDougall,et al.  Anchoring methodologies for pore-scale network models: Application to relative permeability and capillary pressure prediction , 2002 .

[11]  O. Vizika,et al.  On the Role of the Viscosity Ratio during Low-Capillary-Number Forced Imbibition in Porous Media , 1994 .

[12]  T. Ertekin,et al.  The effect of the capillary number and its constituents on two-phase relative permeability curves , 1983 .

[13]  Stig Bakke,et al.  Reconstruction of Berea sandstone and pore-scale modelling of wettability effects , 2003 .

[14]  M. Blunt,et al.  Pore Scale Modeling of Rate Effects in Imbibition , 2000 .

[15]  Scher,et al.  Pore-level modeling of wetting. , 1995, Physical review. E, Statistical physics, plasmas, fluids, and related interdisciplinary topics.

[16]  K. Mohanty,et al.  Factors Influencing Unsteady Relative Permeability of a Mixed-Wet Reservoir Rock , 1991 .

[17]  J. Wang.  WETTABILITY AND RATE EFFECTS ON END-POINT RELATIVE PERMEABILITY TO WATER , 1999 .

[18]  Ioannis Chatzis,et al.  Magnitude and Detailed Structure of Residual Oil Saturation , 1983 .

[19]  K. G. Arthur,et al.  Relative Permeability Measurements: An Inter-Laboratory Comparison , 1994 .

[20]  Martin J. Blunt,et al.  Network modeling of multiphase flow in fractures , 2001 .

[21]  J. Kamath,et al.  Understanding Waterflood Residual Oil Saturation of Four Carbonate Rock Types , 2001 .

[22]  Svein M. Skjaeveland,et al.  Implementation of Multirate Technique to Measure Relative Permeabilities Accounting for Capillary Effects , 1998 .

[23]  Jairam Kamath,et al.  Water/Oil Relative Permeability Endpoints of Intermediate-Wet, Low-Permeability Rocks , 1995 .

[24]  Kristian Mogensen,et al.  A Dynamic Two-Phase Pore-Scale Model of Imbibition , 1998 .

[25]  Talukdar,et al.  Hysteresis Effects in Capillary Pressure, Relative Permeability and Resistivity Index of North Sea Chalk : SCA 2001-65, International Symposium of the Society of Core Analysts, Edinburgh, 17-19 September 2001 , 2001 .

[26]  A. S. Odeh,et al.  A Method for Reducing the Rate Effect on Oil and Water Relative Permeabilities Calculated From Dynamic Displacement Data , 1985 .

[27]  Kenneth Stuart Sorbie,et al.  Use of Geology in the Interpretation of Core-Scale Relative Permeability Data , 1996 .

[28]  S. Bakke,et al.  3-D Pore-Scale Modelling of Sandstones and Flow Simulations in the Pore Networks , 1997 .

[29]  W. J. Leas,et al.  Properties of Linear Waterfloods , 1953 .

[30]  Roland Lenormand,et al.  Role Of Roughness And Edges During Imbibition In Square Capillaries , 1984 .

[31]  Stig Bakke,et al.  A Predictive Network Model for Three-Phase Flow in Porous Media , 2000 .

[32]  Matthew D. Jackson,et al.  Detailed physics, predictive capabilities and macroscopic consequences for pore-network models of multiphase flow. , 2002 .

[33]  L. E. Scriven,et al.  Physics of Oil Entrapment in Water-Wet Rock , 1987 .

[34]  R. Lenormand,et al.  Mechanisms of the displacement of one fluid by another in a network of capillary ducts , 1983, Journal of Fluid Mechanics.

[35]  C. Brown,et al.  Relative Permeability for Intermediate Wettability Reservoirs , 1987 .

[36]  M. J. Oak,et al.  Three-Phase Relative Permeability of Water-Wet Berea , 1990 .

[37]  Martin J. Blunt,et al.  Predictive Pore-Scale Network Modeling , 2003 .

[38]  Shouxiang Ma,et al.  Effect of contact angle on drainage and imbibition in regular polygonal tubes , 1996 .

[39]  S. Akin,et al.  Effect of Flow Rate on Imbibition Three-Phase Relative Permeabilities and Capillary Pressures , 1997 .

[40]  Martin J. Blunt,et al.  Predictive pore‐scale modeling of two‐phase flow in mixed wet media , 2004 .

[41]  A. L. Chen,et al.  RATE EFFECTS ON WATER-OIL RELATIVE PERMEABILITY , 2001 .

[42]  Alkiviades C. Payatakes,et al.  Effects of Precursor Wetting Films in Immiscible Displacement Through Porous Media , 2000 .

[43]  M. Blunt.  Pore Level Modeling of the Effects of Wettability , 1997 .

[44]  Clayton J. Radke,et al.  Laminar flow of a wetting liquid along the corners of a predominantly gas-occupied noncircular pore , 1988 .