On the nonlinear resonances and dynamic pull-in of electrostatically actuated resonators

We present modeling, analysis and experimental investigation for nonlinear resonances and the dynamic pull-in instability in electrostatically actuated resonators. These phenomena are induced by exciting a microstructure with nonlinear forcing composed of a dc parallel-plate electrostatic load superimposed on an ac harmonic load. Nonlinear phenomena are investigated experimentally and theoretically including primary resonance, superharmonic and subharmonic resonances, dynamic pull-in and the escape-from-potential-well phenomenon. As a case study, a capacitive sensor made up of two cantilever beams with a proof mass attached to their tips is studied. A nonlinear spring‐mass‐damper model is utilized accounting for squeeze-film damping and the parallel-plate electrostatic force. Long-time integration and a global dynamic analysis are conducted using a finite-difference method combined with the Floquet theory to capture periodic orbits and analyze their stability. The domains of attraction (basins of attraction) for data points on the frequency‐response curve are calculated numerically. Dover cliff integrity curves are calculated and the erosion of the safe basin of attraction is investigated as the frequency of excitation is swept passing primary resonance and dynamic pull-in. Conclusions are presented regarding the safety and integrity of MEMS resonators based on the simulated basin of attraction and the observed experimental data. (Some figures in this article are in colour only in the electronic version)

[1]  Miko Elwenspoek,et al.  Nonlinearity and Hysteresis of Resonant Strain Gauges , 1998 .

[2]  Hongjun Cao.  Primary resonant optimal control for homoclinic bifurcations in single-degree-of-freedom nonlinear oscillators , 2005 .

[3]  M. Younis,et al.  A Study of the Nonlinear Response of a Resonant Microbeam to an Electric Actuation , 2003 .

[4]  A. Nayfeh,et al.  Secondary resonances of electrically actuated resonant microsensors , 2003 .

[5]  N. C. MacDonald,et al.  Five parametric resonances in a microelectromechanical system , 1998, Nature.

[6]  Ali H. Nayfeh,et al.  Characterization of the mechanical behavior of an electrically actuated microbeam , 2002 .

[7]  J. Casals-Terre,et al.  Resonant Pull-In Condition in Parallel-Plate Electrostatic Actuators , 2007, Journal of Microelectromechanical Systems.

[8]  T. Veijola,et al.  Equivalent-circuit model of the squeezed gas film in a silicon accelerometer , 1995 .

[9]  M. Rieth.  Welcome to the Journal of Computational and Theoretical Nanoscience , 2004 .

[10]  Ali H. Nayfeh,et al.  Finite-Amplitude Motions of Beam Resonators and Their Stability , 2004 .

[11]  Stefano Lenci,et al.  Control of pull-in dynamics in a nonlinear thermoelastic electrically actuated microbeam , 2006 .

[12]  J. Kiihamaki,et al.  Large-displacement modelling and simulation of micromechanical electrostatically driven resonators using the harmonic balance method , 2000, 2000 IEEE MTT-S International Microwave Symposium Digest (Cat. No.00CH37017).

[13]  A. Nayfeh,et al.  Applied nonlinear dynamics : analytical, computational, and experimental methods , 1995 .

[14]  J. Thompson,et al.  Nonlinear Dynamics and Chaos , 2002 .

[15]  Stefano Euzzor,et al.  Avoiding escapes in open dynamical systems using phase control. , 2008, Physical review. E, Statistical, nonlinear, and soft matter physics.

[16]  N. C. MacDonald,et al.  Chaos in MEMS, parameter estimation and its potential application , 1998 .

[17]  S. Krylov,et al.  Stabilization of electrostatically actuated microstructures using parametric excitation , 2005 .

[18]  S.K. De,et al.  Full-Lagrangian schemes for dynamic analysis of electrostatic MEMS , 2004, Journal of Microelectromechanical Systems.

[19]  Albert C. J. Luo,et al.  Nonlinear dynamics of a micro-electro-mechanical system with time-varying capacitors , 2004 .

[20]  J. J. Blech.  On Isothermal Squeeze Films , 1983 .

[21]  N. Aluru,et al.  Complex nonlinear oscillations in electrostatically actuated microstructures , 2006, Journal of Microelectromechanical Systems.

[22]  M. Roukes,et al.  Basins of attraction of a nonlinear nanomechanical resonator. , 2007, Physical review letters.

[23]  Louis C. Chow,et al.  Design and fabrication of meso-scale variable capacitance motor for miniature heat pumps , 2003 .

[24]  Quang Su,et al.  Characterization of the performance of capacitive switches activated by mechanical shock , 2007, Journal of micromechanics and microengineering : structures, devices, and systems.

[25]  A. Zehnder,et al.  Thermomechanical transitions in doubly-clamped micro-oscillators , 2007 .

[26]  Scott Aaronson,et al.  Limitations of quantum advice and one-way communication , 2004, Proceedings. 19th IEEE Annual Conference on Computational Complexity, 2004..

[27]  Stefano Lenci,et al.  Dynamical Integrity and Control of Nonlinear Mechanical Oscillators , 2008 .

[28]  M. Dahleh,et al.  Melnikov-Based Dynamical Analysis of Microcantilevers in Scanning Probe Microscopy , 1999 .

[29]  Steven W. Shaw,et al.  Institute of Physics Publishing Journal of Micromechanics and Microengineering the Nonlinear Response of Resonant Microbeam Systems with Purely-parametric Electrostatic Actuation , 2022 .

[30]  M. Younis.  Modeling and Simulation of Microelectromechanical Systems in Multi-Physics Fields , 2004 .

[31]  Qiao Lin,et al.  Simulation studies on nonlinear dynamics and chaos in a MEMS cantilever control system , 2004 .

[32]  D. Elata,et al.  On the dynamic pull-in of electrostatic actuators with multiple degrees of freedom and multiple voltage sources , 2006, Journal of Microelectromechanical Systems.

[33]  G. Nakhaie Jazar,et al.  Nonlinear Dynamics of MicroResonators , 2006 .

[34]  Henk Nijmeijer,et al.  Modelling the dynamics of a MEMS resonator : simulations and experiments , 2008 .

[35]  Wu Zhiqiang,et al.  Nonlinear Dynamics of Microelectromechanical Systems , 2006 .

[36]  S. Krylov,et al.  Pull-in Dynamics of an Elastic Beam Actuated by Continuously Distributed Electrostatic Force , 2004 .

[37]  J. Vig,et al.  Noise in microelectromechanical system resonators , 1999, IEEE Transactions on Ultrasonics, Ferroelectrics and Frequency Control.

[38]  John A. Pelesko,et al.  Dynamics of a Canonical Electrostatic MEMS/NEMS System , 2008 .

[39]  Ali H. Nayfeh,et al.  Dynamic pull-in phenomenon in MEMS resonators , 2007 .

[40]  J. Moehlis,et al.  Chaos for a Microelectromechanical Oscillator Governed by the Nonlinear Mathieu Equation , 2007, Journal of Microelectromechanical Systems.

[41]  Ali H. Nayfeh,et al.  Dynamics of MEMS resonators under superharmonic and subharmonic excitations , 2005 .

[42]  Igor Mezic,et al.  Complex Dynamics in a Harmonically Excited Lennard-Jones Oscillator: Microcantilever-Sample Interaction in Scanning Probe Microscopes , 2000 .