Kinetic study of the reverse water-gas shift reaction over CuO/ZnO/Al2O3 catalysts

The kinetics of the reverse water-gas shift (RWGS) reaction over CuO/ZnO/Al2O3 catalysts was studied by use of CO2H2 cycles, hydrogen chemisorption and catalytic tests performed in both differential and integral plug flow reactors. The effect of the reactant composition on the reaction rate was specifically studied by changing the PH20/PCO20 ratio between 9.0 and 0.3. It was found that different reagents become rate limiting depending upon pressure. While in a H2-rich region the rate increases strongly with CO2 partial pressure and is zero order in hydrogen, under low PH20/PCO20 ratios the reaction is less active and is strongly positive order in hydrogen and low order in carbon dioxide. The experimental data were modeled by considering that the reaction proceeds through a surface redox mechanism, copper being the active metal. A good agreement between experimental and calculated data was obtained by assuming that in the redox mechanism either the dissociative CO2 adsorption (H2-rich region) or both the CO2 dissociation and the water formation (H2-lean region) determine the rate of the overall reaction. Based on previous studies performed on copper crystal surfaces, such a change in kinetics may be explained by assuming that under H2-rich atmosphere a surface structural or phase transition occurs involving a change in reactivity with respect to CO2 dissociation.

[1]  F. Garbassi,et al.  XPS study on the low-temperature CO shift reaction catalyst: II. The effects of the addition of alumina and reaction conditions , 1984 .

[2]  R. Gupta,et al.  Infrared spectroscopy of chemisorbed carbon monoxide on copper , 1975 .

[3]  W. A. Jong,et al.  Kinetics and mechanism of the CO shift on CuZnO: 1. Kinetics of the forward and reverse CO shift reactions , 1980 .

[4]  M. Laborde,et al.  Activity and structure-sensitivity of the water-gas shift reaction over CuZnAl mixed oxide catalysts , 1995 .

[5]  J. Sass,et al.  Vibrational Signatures of the Hydrogen-Water Interactions on Cu(110) at 100 K and 300 K , 1990 .

[6]  Markus Eiswirth,et al.  Kinetic oscillations in the catalytic CO oxidation on a Pt(110) surface , 1986 .

[7]  C. Campbell,et al.  The chemisorption and coadsorption of water and oxygen on Cs-dosed Cu(110) , 1989 .

[8]  D. Newsome.  The Water-Gas Shift Reaction , 1980 .

[9]  M. S. Spencer,et al.  On the activation energies of the forward and reverse water-gas shift reaction , 1995 .

[10]  N. Clayden,et al.  In situ NMR studies of a Cu/ZnO/Al2O3 methanol synthesis catalyst , 1991 .

[11]  C. Campbell,et al.  The dissociative adsorption of H2 and D2 on Cu(110): activation barriers and dynamics , 1991 .

[12]  Rieder,et al.  Hydrogen-induced subsurface reconstruction of Cu(110). , 1986, Physical review letters.

[13]  B. Poelsema,et al.  H-induced (1 × 2) reconstruction of the Cu(110) surface: structure and deconstruction kinetics , 1990 .

[14]  Charles T. Campbell,et al.  A kinetic model of the water gas shift reaction , 1992 .

[15]  Charles T. Campbell,et al.  Kinetics of the reverse water-gas shift reaction over Cu(110) , 1992 .

[16]  C. Campbell,et al.  Kinetics and mechanism of the water-gas shift reaction catalysed by the clean and Cs-promoted Cu(110) surface: a comparison with Cu(111) , 1990 .

[17]  Shin-ichiro Fujita,et al.  Mechanism of the reverse water gas shift reaction over Cu/ZnO catalyst , 1992 .

[18]  C. Campbell,et al.  A surface science investigation of the water-gas shift reaction on Cu(111) , 1987 .

[19]  T. Salmi,et al.  Kinetic Study of the Low-Temperature Water-Gas Shift Reaction over a Cu—ZnO Catalyst , 1989 .

[20]  G. Pleizier,et al.  Methanol synthesis from CO2+H2. I: Characterization of catalysts by TPD , 1985 .

[21]  G. Chinchen,et al.  A comparison of the water-gas shift reaction on chromia-promoted magnetite and on supported copper catalysts , 1988 .

[22]  C. Campbell,et al.  Does CO2 dissociatively adsorb on Cu surfaces , 1989 .

[23]  J. I. D. Cosimo,et al.  Effect op the preparation conditions on the reducibility of Cu-Co based oxides , 1992 .

[24]  K. C. Waugh,et al.  The measurement of copper surface areas by reactive frontal chromatography , 1987 .