A comprehensive mathematical model for the Fischer-Tropsch synthesis in well-mixed slurry reactors

A new product distribution quasi-steady-state model was proposed for the Fischer–Tropsch (FT) synthesis in slurry reactors, being applicable to their transient simulation. It may consider two chain propagation mechanisms or sites and the possibility of 1-olefin readsorption with secondary reactions, recovering the Anderson–Schulz–Flory (ASF) model, the two superimposed ASF model and the 1-olefin readsorption model as particular cases. The hydrocarbon compounds were lumped according to the number of carbon atoms in their molecules for the paraffin and 1-olefin families. The phases were assumed to be well mixed in the reactor and transient mass balances were performed for each component, allowing simulation of operation in constant liquid level and no liquid withdrawal conditions. A rigorous calculation of the vapor–liquid equilibrium (VLE) through cubic equations of state was used to describe the phase behavior. Rate expressions for the FT and the water gas shift reactions are taken from the literature and expressed in terms of fugacities. Simulation results showed that the inclusion of both the olefin readsorption and the two chain propagation mechanisms may explain the anomalies present in experimental hydrocarbon product distribution. Moreover, the effect of phase-equilibrium modeling on product distribution simulation was shown to be slightly important in the conditions analyzed. Compositional lumping schemes for the hydrocarbons were investigated to speed up the simulations. Results showed that lumping can speed up computations up to 250 times with negligible loss of accuracy.

[1]  K. Westerterp,et al.  Residence time distribution of the gas phase in a mechanically agitated gas-liquid reactor , 1992 .

[2]  B. Davis,et al.  Effect of Vapor−Liquid Equilibrium on Fischer−Tropsch Hydrocarbon Selectivity for a Deactivating Catalyst in a Slurry Reactor , 1996 .

[3]  G. Soave.  Equilibrium constants from a modified Redlich-Kwong equation of state , 1972 .

[4]  M. Rosen,et al.  MATHEMATICAL MODELING OF FISCHER- TROPSCH SLURRY BUBBLE COLUMN REACTORS , 1986 .

[5]  John J. Marano,et al.  General equation for correlating the thermophysical properties of n-paraffins, n-olefins, and other homologous series : 2. Asymptotic behavior correlations for PVT properties , 1997 .

[6]  A. Bell,et al.  An explanation for deviations of Fischer-Tropsch products from a Schulz-Flory distribution , 1983 .

[7]  G. V. D. Laan,et al.  Kinetics and Selectivity of the Fischer–Tropsch Synthesis: A Literature Review , 1999 .

[8]  C. Singh,et al.  Simulation of High-Temperature Water-Gas Shift Reactors , 1977 .

[9]  S. Reyes,et al.  Transport-enhanced α-olefin readsorption pathways in Ru-catalyzed hydrocarbon synthesis , 1991 .

[10]  L. Cisternas,et al.  Generalized interaction parameters in cubic equations of state for CO2—n-alkane mixtures , 1988 .

[11]  Ian C. Yates,et al.  Analysis and prediction of product distributions of the Fischer-Tropsch synthesis , 1988 .

[12]  J. Marano,et al.  Characterization of Fischer-Tropsch liquids for vapor-liquid equilibria calculations , 1997 .

[13]  Raymond C. Everson,et al.  Fischer−Tropsch Kinetic Studies with Cobalt−Manganese Oxide Catalysts , 2000 .

[14]  L. Cisternas,et al.  Binary interaction parameters in cubic equations of state for hydrogen—hydrocarbon mixtures , 1990 .

[15]  Hans Schulz,et al.  Kinetic modelling of Fischer–Tropsch product distributions , 1999 .

[16]  D. Peng,et al.  A New Two-Constant Equation of State , 1976 .

[17]  Charles N. Satterfield,et al.  Intrinsic kinetics of the Fischer-Tropsch synthesis on a reduced fused-magnetite catalyst , 1984 .

[18]  Stanley M. Walas,et al.  Phase equilibria in chemical engineering , 1985 .

[19]  R. Reid,et al.  The Properties of Gases and Liquids , 1977 .

[20]  TWO ALPHA F1SCHER-TROPSCH PRODUCT DISTRIBUTION. A ROLE FOR VAPOR-LIQUID EQUILIBRIUM? , 2000 .

[21]  Rajamani Krishna,et al.  Design and scale-up of the Fischer–Tropsch bubble column slurry reactor , 2000 .

[22]  C. Pantelides.  The consistent intialization of differential-algebraic systems , 1988 .

[23]  M. Hirata,et al.  Generalized interaction parameters for the Peng—Robinson equation of state: Carbon dioxide—n-paraffin binary systems , 1981 .

[24]  B. Sarup,et al.  Studies of the fischer‐tropsch synthesis on a cobalt catalyst i. evaluation of product distribution parameters from experimental data , 1988 .

[25]  Dragomir B. Bukur,et al.  Reaction kinetics over iron catalysts used for the fischer‐tropsch synthesis , 1990 .

[26]  Fischer-Tropsch synthesis on a precipitated iron catalyst , 1981 .

[27]  A. Anderko.  Equation-of-state methods for the modelling of phase equilibria , 1990 .

[28]  Katsuhiko Takeuchi,et al.  Generalization of the binary interaction parameter of the Peng-Robinson equation of state by component family , 1988 .

[29]  John J. Marano,et al.  A General Equation for Correlating the Thermophysical Properties of n-Paraffins, n-Olefins, and Other Homologous Series. 3. Asymptotic Behavior Correlations for Thermal and Transport Properties , 1997 .

[30]  J. Gaube,et al.  Studies on product distributions of iron and cobalt catalyzed Fischer–Tropsch synthesis , 1999 .

[31]  J. Gaube,et al.  Interpretation and kinetic modeling of product distributions of cobalt catalyzed Fischer–Tropsch synthesis , 2002 .

[32]  Wen-Ping Ma,et al.  Kinetics modelling of Fischer–Tropsch synthesis over an industrial Fe–Cu–K catalyst☆ , 2003 .

[33]  S. C. Saxena,et al.  Bubble column reactors and Fischer-Tropsch synthesis , 1995 .