Investigation of composition of boron carbide thin films by resonant soft x-ray reflectivity

Abstract Boron carbide thin films of different thicknesses deposited by ion beam sputtering were studied. The deposited films were characterized by grazing incidence hard x-ray reflectivity (GIXR), resonant soft x-ray reflectivity (RSXR), x-ray photo electron spectroscopy (XPS), resonant Rutherford backscattering spectrometry (RRBS), and time of flight secondary ion mass spectrometry (TOF-SIMS). Depth profile of the chemical elements constitute the films is reconstructed based on analysis of reflectivity curves measured in the vicinity of B K-edge. The composition of films is closely dependent on film thickness. Boron to Carbon (B/C) ratio reaches to ~ 4 as the thickness of deposited films increases. The B/C ratio estimated from RSXR measurements are in agreement with the RRBS measurements. TOF-SIMS data also suggested that decrease in boron content with decrease in film thickness. XPS measurements confirm the presence of little amount of B atoms on the surface of low thickness film.

[1]  S. Rai,et al.  Thermally induced interface changes in W/B4C multilayers , 2015 .

[2]  Richard A. London,et al.  Damage threshold of inorganic solids under free-electron-laser irradiation at 32.5 nm wavelength , 2007 .

[3]  T. Russell,et al.  X-ray and neutron reflectivity for the investigation of polymers , 1990 .

[4]  R A Keski-Kuha,et al.  Ion-beam-deposited boron carbide coatings for the extreme ultraviolet. , 1994, Applied optics.

[5]  G. S. Lodha,et al.  Thermal stability studies of ion beam sputter deposited C/B4C X-ray multilayer mirror , 2013 .

[6]  P. Dowben,et al.  The properties of boron carbide/silicon heterojunction diodes fabricated by Plasma-Enhanced Chemical Vapor Deposition , 1994 .

[7]  Michael Nastasi,et al.  X-ray photoelectron spectroscopy investigation of boron carbide films deposited by sputtering , 2004 .

[8]  W. Braun,et al.  Investigation of the structure of thin HfO2 films by soft x-ray reflectometry techniques , 2009, Journal of physics. Condensed matter : an Institute of Physics journal.

[9]  F. Schäfers,et al.  Soft x-ray reflectometry, hard x-ray photoelectron spectroscopy and transmission electron microscopy investigations of the internal structure of TiO2(Ti)/SiO2/Si stacks , 2012, Science and technology of advanced materials.

[10]  B. L. Henke,et al.  X-Ray Interactions: Photoabsorption, Scattering, Transmission, and Reflection at E = 50-30,000 eV, Z = 1-92 , 1993 .

[11]  F. Salmassi,et al.  Optical constants of magnetron-sputtered boron carbide thin films from photoabsorption data in the range 30 to 770 eV. , 2008, Applied optics.

[12]  A. Srivastava,et al.  Microstructure and composition analysis of low-Z/low-Z multilayers by combining hard and resonant soft X-ray reflectivity , 2016 .

[13]  Daniel Schwen,et al.  Ion beam synthesis of boron carbide thin films , 2002 .

[14]  C. Morawe,et al.  Chemical modification of B 4 C cap layers on Pd/B 4 C multilayers , 2016 .

[15]  S. A. Gusev,et al.  Multilayered mirrors based on La/B4C(B9C) for X-ray range near anomalous dispersion of boron (λ≈6.7 nm) , 2009 .

[16]  H. Sinn,et al.  Comparative study of the X-ray reflectivity and in-depth profile of a-C, B₄C and Ni coatings at 0.1-2 keV. , 2015, Journal of synchrotron radiation.

[17]  Eberhard Spiller,et al.  Soft-x-ray optics , 1994, Optical Society of America Annual Meeting.

[18]  Regina Soufli,et al.  Development and calibration of mirrors and gratings for the soft x-ray materials science beamline at the Linac Coherent Light Source free-electron laser. , 2012, Applied optics.

[19]  P. Dowben,et al.  The structural homogeneity of boron carbide thin films fabricated using plasma‐enhanced chemical vapor deposition from B5H9+CH4 , 1993 .

[20]  P. Dowben,et al.  Sputter deposition of high resistivity boron carbide , 1998 .

[21]  Pankaj Srivastava,et al.  Growth kinetics and compositional analysis of silicon rich a-SiNx:H film: A soft x-ray reflectivity study , 2010 .

[22]  K. L. Chopra,et al.  Thin Film Phenomena , 1969 .

[23]  F. Bijkerk,et al.  Microstructure of Mo/Si multilayers with B4C diffusion barrier layers. , 2009, Applied optics.

[24]  Harald Ade,et al.  Soft x-ray resonant reflectivity of low-Z material thin films , 2005 .

[25]  B. Duval,et al.  Cold boronisation in TCA , 1990 .

[26]  L. G. Parratt.  Surface Studies of Solids by Total Reflection of X-Rays , 1954 .

[27]  Eric Louis,et al.  Spectral properties of La/B--based multilayer mirrors near the boron K absorption edge. , 2012, Optics express.

[28]  S. Rai,et al.  Stability and normal incidence reflectivity of W/B4C multilayer mirror near the boron K absorption edge. , 2013, Applied optics.