Experimental investigation of effect of heat load on thermal performance of natural circulation steam generation system as applied to PTC-based solar system

Abstract An indoor experimental test rig of parabolic trough collector (PTC)-based natural circulation steam generation system consisting in a thermosyphon loop was presented. A series of five heat loads (0.6–1.2 kW) were applied to investigate effect of heat load on thermal performance of the system. Effect of heat load on flow pattern, thermal efficiency and two phase heat transfer coefficient was discussed, respectively. An extended correlation equation was provided for two flow patterns, which is characterized by heat pipe thermal resistance. The critical heat pipe thermal resistance for flow pattern transition was ranged from 34.37 K/kW to 33.35 K/kW. Simultaneously, thermal efficiency shows a continuous increase as heat load kept rising. The effect of backflow was found to be negligible when heat load increased to 1.1 kW. Additionally, the average two-phase heat transfer coefficient in receiver also went up with the rising of heat load for the same flow pattern. Due to the flow pattern transition, which resulted in a dryness fraction drop in receiver, a maximum heat transfer coefficient of 285.86 W/m2 K was obtained at heat load of 1.0 kW under a steam discharging pressure of 0.15 MPa.

[1]  Masud Behnia,et al.  Water-in-Glass Evacuated Tube Solar Water Heaters , 2004 .

[2]  Lacour M Ayompe,et al.  Thermal Performance Analysis of a Solar Water Heating System With Heat Pipe Evacuated Tube Collector Using Data From a Field Trial , 2013 .

[3]  Z. T. Yu,et al.  Investigation and analysis on a cellular heat pipe flat solar heater , 2005 .

[4]  Xin‐Rong Zhang,et al.  Experimental study on solar thermal conversion based on supercritical natural convection , 2014 .

[5]  S. D. Probert,et al.  Natural-circulation solar-energy stimulated systems for heating water , 1982 .

[6]  Xin‐Rong Zhang,et al.  Experimental analysis on a novel solar collector system achieved by supercritical CO2 natural convection , 2014 .

[7]  S. Rittidech,et al.  Experimental study of the performance of a circular tube solar collector with closed-loop oscillating heat-pipe with check valve (CLOHP/CV) , 2009 .

[8]  M. Eickhoff,et al.  Applied research concerning the direct steam generation in parabolic troughs , 2003 .

[9]  Siaka Toure,et al.  Theoretical and experimental study of solar water heater with internal exchanger using thermosiphon system , 2008 .

[10]  Wujun Wang,et al.  An experimental investigation of a natural circulation heat pipe system applied to a parabolic trough solar collector steam generation system , 2012 .

[11]  Lourdes García-Rodríguez,et al.  Application of direct steam generation into a solar parabolic trough collector to multieffect distillation , 1999 .

[12]  Kamal Abdel Radi Ismail,et al.  Performance of a Heat Pipe Solar Collector , 1998 .

[13]  David A.G. Redpath,et al.  Thermosyphon heat-pipe evacuated tube solar water heaters for northern maritime climates , 2012 .

[14]  Feng Zhao,et al.  Thermal performance of an open thermosyphon using nanofluid for evacuated tubular high temperature air solar collector , 2013 .

[15]  Zhou Xi,et al.  Experimental study and exergetic analysis of a CPC-type solar water heater system using higher-temperature circulation in winter , 2012 .

[16]  E. Azad,et al.  Theoretical and experimental investigation of heat pipe solar collector , 2008 .

[17]  Z. Duan,et al.  Dynamic performance of a façade-based solar loop heat pipe water heating system , 2012 .

[18]  W. Beckman,et al.  Solar Engineering of Thermal Processes , 1985 .

[19]  E. Azad,et al.  Assessment of three types of heat pipe solar collectors , 2012 .

[20]  Lin Lu,et al.  A novel all-glass evacuated tubular solar steam generator with simplified CPC , 2014 .

[21]  Abdelmajid Jemni,et al.  Theoretical and experimental investigation of plate screen mesh heat pipe solar collector , 2014 .

[22]  Xudong Zhao,et al.  Developing a theoretical model to investigate thermal performance of a thin membrane heat-pipe solar collector , 2005 .

[23]  Igor Pioro,et al.  Industrial two-phase thermosyphons , 1997 .

[24]  Fabricio I. Salgado,et al.  Short-term operation planning on cogeneration systems : A survey , 2008 .

[25]  Kefa Cen,et al.  An indoor experimental investigation of the thermal performance of a TPLT-based natural circulation steam generator as applied to PTC systems , 2014 .

[26]  S. Kandlikar.  A General Correlation for Saturated Two-Phase Flow Boiling Heat Transfer Inside Horizontal and Vertical Tubes , 1990 .

[27]  Markus Eck,et al.  Direct steam generation in parabolic troughs: Final results and conclusions of the DISS project , 2004 .

[28]  Siaka Toure,et al.  Thermal performance of a solar water heater with internal exchanger using thermosiphon system in Côte d'Ivoire , 2014 .

[29]  Nay Zar Aung,et al.  Numerical investigation on effect of riser diameter and inclination on system parameters in a two-phase closed loop thermosyphon solar water heater , 2013 .

[30]  Lin Chen,et al.  Concept design and formation of a lithium bromide–water cooling system powered by supercritical CO2 solar collector , 2014 .

[31]  A. El Fadar,et al.  Study of a new solar adsorption refrigerator powered by a parabolic trough collector , 2009 .

[32]  M. Pérez-García,et al.  Study of an adsorption refrigeration system powered by parabolic trough collector and coupled with a heat pipe , 2009 .

[33]  H.M.S. Hussein,et al.  Transient investigation of a two phase closed thermosyphon flat plate solar water heater , 2002 .

[34]  D. Mills.  Advances in solar thermal electricity technology , 2004 .

[35]  Markus Eck,et al.  The DISS Project: Direct Steam Generation in Parabolic Trough Systems. Operation and Maintenance Experience and Update on Project Status , 2001 .

[36]  K. N. Sheeba,et al.  Experimental investigation of heat transfer and friction factor characteristics of thermosyphon solar water heater system fitted with spacer at the trailing edge of Left–Right twisted tapes , 2009 .

[37]  Wujun Wang,et al.  An experimental investigation of the heat losses of a U-type solar heat pipe receiver of a parabolic trough collector-based natural circulation steam generation system , 2013 .

[38]  S. Iniyan,et al.  A review of solar thermal technologies , 2010 .

[39]  Süleyman Özkaynak,et al.  Performance parameters for the design of a solar-driven cogeneration system , 2001 .

[40]  H.M.S. Hussein,et al.  Theoretical and experimental investigation of wickless heat pipes flat plate solar collector with cross flow heat exchanger , 2007 .

[41]  Zhen-Hua Liu,et al.  A novel integrated solar desalination system with multi-stage evaporation/heat recovery processes , 2014 .

[42]  Lin Lu,et al.  Thermal performance of an open thermosyphon using nanofluids for high-temperature evacuated tubular solar collectors: Part 1: Indoor experiment , 2011 .

[43]  Eckhard Lüpfert,et al.  Advances in Parabolic Trough Solar Power Technology , 2002 .